We found the following complaints for VOLKSWAGEN EUROVAN (1993)
Read complaints for VOLKSWAGEN EUROVAN (1993)
Air bag did notdeploy at the time of accident. Consumer contacted manufacturer, said no airbags installed in 1993 car.*ml
Horn will not blow can not hear.tt
The horns on my vehicle have been repaired three times and are again not working.the gas and temp gauge are not working and a local dealer said this is a persistent problem with eurovans.the air conditioning has gone out several times.the air conditionercompressor froze one time and melted the serpetine into all of the engine pulleys--cost to repair $4,000.00.headlights filled with water.rear heater fan clanks loudly.excessive noise in vehicle.
Vehicle is hesitant with poor engine acceleration and merging power. Tt
The car does not turn over electrical problem.tt
16 episodes of stalling, dealer and manufacturer say that there is nothing wrong with vehicle.tt
Starterrelaywent out, causing the vehicle to not start at all. Dealer has not seen vehicle. This has happened 3 times.
Dt: contact states a 1993 euro van volkswagen burned while driving.smoke started coming out from underneath the hood.there was no ongoing investigation to determine the cause of fire.
Consumer was traveling about 15mph on a residential street.she had the window rolled up, and she started feeling sick.she pulled over andnoticed white smoke coming from hood area. Consumer went to get her husband,and when she returned vehicle wasin flames.vehicle was totaled. Prior to the recall the fuel line failed (00v-039).customer later found out that there was a recall.
The horns on my vehicle have been repaired three times and are again not working.the gas and temp gauge are not working and a local dealer said this is a persistent problem with eurovans.the air conditioning has gone out several times.the air conditionercompressor froze one time and melted the serpetine into all of the engine pulleys--cost to repair $4,000.00.headlights filled with water.rear heater fan clanks loudly.excessive noise in vehicle.
Cooling system: on the freeway coming home needle got hot red light came on,vehicle started smoking and fumes was coming from vehicle .lost all of the coolant and could not drive it. Had vehicle towed to dealer and they say they can't fix it.
The contact owns a 1993 volkswagen eurovan.while driving 5 mph, the engine on one side of the vehicle became completely loose and fell to the ground.the pan, which supported the engine, fell onto the street and dragged on the ground.an engine bracket, to which the engine is bolted, needed to be replaced.the manufacturer stated that nothing could be done.the vehicle is currently parked at an auto repair shop awaiting the parts for the repair.the parts would cost $450; however, the repair shop is giving him a discount.the manufacturer would not assist.the failure mileage was 131,000.
During vehicle operation, a vibration was experienced coming from the front end due to broken right side motor mount bolt.
While driving consume noticed thick black smoke pouring from under the hood. Whenhood was lifted there was a fire in the engine, and strong odor of gasoline.fire was due by a leaking fuel line caused by defective clamps.the leak was in the fuel line from fuel pump to fuel injector rail directly above the distributor which provided the spark to ignite the gasoline.
While driving the engine cuts off which disconnects the steering and power brakes. Has happened 4 times in a week. Dealer can't find the problem.
Engine fire.
Engine fire.
Serpentine belt failed, causing engine noise.
The horns on my vehicle have been repaired three times and are again not working.the gas and temp gauge are not working and a local dealer said this is a persistent problem with eurovans.the air conditioning has gone out several times.the air conditionercompressor froze one time and melted the serpetine into all of the engine pulleys--cost to repair $4,000.00.headlights filled with water.rear heater fan clanks loudly.excessive noise in vehicle.
Strong smell of raw fuel in passenger compartment and outside of vehicle has occurred itermittently since we purchased the vehicle. More frequently on very cold days.
The horns on my vehicle have been repaired three times and are again not working.the gas and temp gauge are not working and a local dealer said this is a persistent problem with eurovans.the air conditioning has gone out several times.the air conditionercompressor froze one time and melted the serpetine into all of the engine pulleys--cost to repair $4,000.00.headlights filled with water.rear heater fan clanks loudly.excessive noise in vehicle.
Air conditioner compressor exploded causing damage to entire a/c system and engine components.(qcaw)
A/c recall work denied.
The wrench that comes in the vehicle to allow you to change a tire will deform when there is a lot of stress on it.tt
The horns on my vehicle have been repaired three times and are again not working.the gas and temp gauge are not working and a local dealer said this is a persistent problem with eurovans.the air conditioning has gone out several times.the air conditionercompressor froze one time and melted the serpetine into all of the engine pulleys--cost to repair $4,000.00.headlights filled with water.rear heater fan clanks loudly.excessive noise in vehicle.
Raw fuel was dripping from a "t" fitting near the top of the engine.
Leaking fuel lines
Plastic fuel lines from tank leaking at fastening clamps in engine compartment onto distributor cap. Raw fuel smell noticed in passenger compartment while driving. Vehicle was immediately pulled to roadside, shut off and towed to repair facility. Passengers were left stranded. Possibility of fire is high. Investigate for potential recall.
Problem is fuel lines leaking after night time cold soak-common among 93 eurovans. Request national recall of eurovans to prevent deaths from vehicle fires.
Engine compartment fuel line fitting leaks gasoline when ambient temperature is below 60.this fitting is located above the distributor so that gasoline drops onto it.once engine is warm, the leak stops.i have read at least two other similar insidences on a vw eurovan/vanagon newsgroup.
Vehicle experiencing fuel leakages from the fuel line fixing. Repairs were done by a dealer at consumer's cost. Problem is reoccurring, manufacturer notified, and informed consumerthat this vehiclewas not covered underrecall 00v039000 due to vin.
This is an addendum to the earlier voq i posted on 9/10/99. Eurovans were recalled in canada for the very same fuel leak problem - canadian recall # 1994072. The recall is in 1994, therefore vw would not have had any notice of the problem until 1994, after the 1993 model year production had ended. The fuel systems between 1992 canadian and 1993 us eurovans are identical, therefore the problem is common to both.
Afterstoppingcould detect the smell of fuel inside of vehicle, even with the a/c on.consumer thought it wasa fuel line.
Problem has been reported by many eurovan owners.was recalled in canada. No safety defect mentioned in summary.
Smelled gas and noticed dripping of fuel line at start up. Line would seal up once engine warmed up. Took to mechanic who remove connection and added hose clamp. Leak is between rubber and plastic fuel supply line from gas tank.
Fuel line leak.gas fumes in driver's compartment for 6 months before university volkswagen repaired.they couldn't diagnose.i finally took them a copy of a posting from a eurovan list on the web which described the problem in detail.uvw replaced the bad clamps/hoses immediately then.apparently engine fires have ocurred as a result of this problem.
Every eurovan owner i talk to has the same problem!!!. No safety defect listed within summary.
When cold, the fuel lines spray gasoline onto the distributor.
Fuel leakage in engine compartment due todefective rubber fuel line connectors.repaired twice, second repair paid for by vw.*ml
The leaking crimp is directly above the distributor - hence a huge fire hazard.
Fuel line leaks. Vw denied any recall during several telephone calls.
A recall on fuel lines was issued in march or april. Up to this date vwoa refuses to perform the required fuel line replacement. I have had two appointments with a dealer (after vwoa authorized the replacement over the phone) and both times i was sent home. The first time the dealer claimed there was not recall. After vwoa called him he consented to performing the recall. As i picked up the van i received a statement that the lines were performing according to wv specifications. When i checked under the hood i realized that they had not changed the lines. I believe they were fraudulent. When i questioned the manager he claimed there was no recall. The second time he claimed his factory rep did not authorize the repair. The vw dealer in question is land vw in durham, nc. The service manager is dave wilcox. He simply refuses to fix the fuel lines. I believe vwoa is trying to cover up and stall. My lines are leaking but noone will fix them. Why does the government not enforce mandated recalls?? how long will it take before vw and the government will take action? how many eurovans have to go up in flames. I wanted the lines replaced before i drive the van to idaho from nc (we are moving) but the dealer refuses.my new address is 2062 cassia st, pocatello, id 83201 (no phone, yet--but my email remains the same). Hope i get there w/o an engine fire.
Never notified of any recalls, including current, including ones repaired. No safety defect listed in summary.
Recall 00v039000. No notification as required. During telephone calls, etc.vw refuses to fix.
Volkswagen issued a recall for replacing the crimped fuel line fittings at the upper end of the fuel lines (vw campaign un) already.the failed fittings on my vehicle are at the lower end of the plastic fuel line, with the same problem - when "cold" the.
The fuel line leaked as i started the car.i smelled gas, turned it off and investigated.fuel was dripping from the fitting.the fitting is right above the distributor and close to the exhaust manifold.a fire was likely if i had driven the van.i replaced the line, paid out of pocket since vw does not see this as a manufacturing defect.i have replaced line but a gas smell persists and is probably linked to a bad vapor recovery system.this vehicle has problems with fuel lines, as other owners can testify.there have only been 10 000 sold in the us and a reported 3 have caught on fire and i know of several in canada.
I believe it was fuel line related as the majority of the fire damage was centered around the cluster of fuel lines on the driver's side of the engine, above the distribtor.
Crimped fuel line connections at the engine leaks fuel. These connections are directly over the ignition distributor and pose a serious fire hazard. It appears that the cause of the leak is an improperly sized metal crimp: even though the rubber supply and return lines are different sizes they use the same size metal crimp. At low temperatures the age related reduction of compression set retentsion of the rubber hose material causes the hose to loose its seal and leak fuel. Please note that the fuel line that leaked is the low pressure return line, not the high pressure supply line.
Fuel line fittings over engine leak gasoline, typically as weather turns colder. One three port fitting and two connections to lines running to the gas tank are involved.transport canada issued recall #1994072 for 1992 eurovans which had identical components. This issue is common to 5 cyl vw eurovans as reported to the internet eurovan list.
Fuel hose & clamps leaking in engine comparment.many owners reporting exact same problem at about the 6-7 year of ownership, some have reported fires.vw also had same trouble with vw passat which resulted in a recall..cold weather.8ak
Fire hazard. Several vw's burnd to the ground. Vw will not recognize problem with original fuel line and clamps!
Leak at return line and fuel manifold. Fuel dripped on distributor locaded directlybelow. Used halon fire extinguisher to prevent fire.
Temperature at 27f started engine immediately smelled gas checked under the hood gas was dripping from 2 places onto engine block, shutoff engine. In last four ears in cold temps have smelled gas but driven and checked engine afterwards never found any drips guess because had dried up. Casually mentioned it to the dealership when in for service at beginning of problem nothing was found.today the first really cold snap this year that i went to drive my car. I am calling for a repair appointment monday 20 dec 99.
The flexible fuel hoses extending from the hard plastic fuel supply/return lines leak gasoline in cold weather. Leaks have been found at both ends of each hose. Leak ratesvary from "wicking" at hose ends to several drops per second. These leaks are especially dangerous as they occur directly above the distributor.s
No summary listed for above vehicle.
The contact owns a 1993 volkswagen eurovan.the current mileage was 200000.the vehicle was serviced for nhtsa recall# 00v039000, replacing part number 701201363e fuel line, feed and part number 701201363c fuel line, return.the contact stated that his 1995 has the same parts on it, but are not experiencing any problems as of yet.the contact stated that volkswagen should recall the 1995 and any vehicles that are using these parts.the contact wants to get his 1995 repaired but volkswagen will not sell him the part.
Consumer was traveling about 15mph on a residential street.she had the window rolled up, and she started feeling sick.she pulled over andnoticed white smoke coming from hood area. Consumer went to get her husband,and when she returned vehicle wasin flames.vehicle was totaled. Prior to the recall the fuel line failed (00v-039).customer later found out that there was a recall.
Started up vehicle in the driveway and smelled gas.opened the hood, and noticedfuel leakage.contacted dealer. Dealer was not aware of a recall for this problem.
Fuel leaking in engine compartment from union of rubber hose/hard plastic line supplying fuel from tank to fuel injectors. Leak occurs at low (15 f) ambient temperature. Fuel drips in area of ignition distributor. Was alerted to potential problem by postings from other vw eurovan owners and began checking engine at start-up as weather got colder. First detected leak on january 6, 2000 with outside temp approx 15 degrees f. Will attemp repair myself, replacing crimped fitting with clamp.
Gas line malfunction.
Fuel leak in a rubber hose ignited by some type of ignition source in the engine compartment, causing fire.
Significant fuel line leak occurred without apparent cause at junction of plastic fuel line from tank to rubber hose.leaked from unadjustable compression fitting used to seal rubber hose to plastic line immediately above distributor.extreme fire hazard.i have replaced rubber fuel injection hose and used adjustable clamps.should be a recall because of the fire hazard.
While driving in the neighborhood, dropping off a child at school andcontinued down the road,vehicle caught on fire. Vehicla was totalled. 1st and 2nd time they said to bring the vehicle into repair shop, and they replaced gasket/seal on the fuel tank.second time they replaced section of hoses. Contacted the dealer.
Fuel is leaking onto the engine compartment,causing a hazarddue tobad hose clamps which needed to be replaced. Consumer also noticedvery bad fumes/odor insidethe vehicle.
There is a gas leak coming from a gas line that goes to fuel injection due to a factory machine pressure clamp, potential fire hazard. Clamp cannot be tightened, and the parts needed to repair are unavailable.
The pressurized hoses that connect the injector rails and the cold start injector to the main (plastic) fuel supply lines pass directly over distributor.exhaust from radiator cooling also blows directly to this area of the engine compartment.over time / at around 116k miles, said hoses had hardened developing a leak that was squirting fuel directly at the distributor.since one of the leaking hoses is factory crimped to the fuel suppy line, removing it only served to further complicate the replacement process.
Recall 00 v039 000. Parts that are needed to perform the recall are not available.
Recall 00v039000 vw/ fuel leakage; volkswagen of america will not pay the full price of correcting recall campaign.volkswagen wants consumer to pay over $900.00 in labor charges. Please provide any further information.
While driving in the neighborhood, dropping off a child at school andcontinued down the road,vehicle caught on fire. Vehicla was totalled. 1st and 2nd time they said to bring the vehicle into repair shop, and they replaced gasket/seal on the fuel tank.second time they replaced section of hoses. Contacted the dealer.
The horns on my vehicle have been repaired three times and are again not working.the gas and temp gauge are not working and a local dealer said this is a persistent problem with eurovans.the air conditioning has gone out several times.the air conditionercompressor froze one time and melted the serpetine into all of the engine pulleys--cost to repair $4,000.00.headlights filled with water.rear heater fan clanks loudly.excessive noise in vehicle.
Consumer not notified of recall on the fuel lines.
Fuel leak in rubber hose causing vehicle fire.
Please provide further information.
Fuel line leaks and learnt there is a recall in canada with owners complained of the same issues. Defective fuel line system was installed.
Automatic transmission jerks/lurches violently upon upshift from 1st to 2nd (automatic transmission).transmission does not engage for a few seconds after depressing accelerator - very scary when on expressway entrance ramp!dealer inspection determined that transmission control unit was faulty (this is an "adaptive" automatic transmission).parts were not available to repair the problem - long wait required!car is driveable but we are very cautious.
Sealed wheel bearing failure
While driving the clutch went out causing the vehicle to loss acceleration. Ph clutch failed at 22921, 61346 and 80660 miles.other problems included grinding noise, no shift engagement.worn clutch assembly and shift relay bushing replaced.
Vehicle was parked and in gear, manual shift, child turn key and causing the vehicle jump, impact 12:00 position , going wall in garage.tt
Instrument panel gauges not responding, when consumer went ot test gauges the vehicle was parked in first gear with the emergency brake engaged, when the ignition key was turned the vehicle started and ran into the garage causing extensive damage, the design of the manual transmission (no clutach safety switch) allows for acceleration without engagment of the clutch.
Seat belt recall work can not be performed due to lack of parts, unit has failed.
While merging onto the highwaysteering wheel failed. Consumer applied the brakes andpedal went to the floor. Vehicle continued to accelerate.consumer was not able to maintain control of the vehicle,andvehicle went downinto an embankment and flipped over three times.the driver was not injured. Consumer had the vehicle towed to the dealer for inspection, and mechanic was not able to duplicate the problem.consumer informed the driver that recall 94v058000 applied to this vehicle.however,mechanic determined that this recall was not for this vehicle.
Antilock brakes failed.
The steering wheel wobbled, there was clicking in the steering column, and the rubber fell off the tires after only 14k as a result of the steering problem.
The steering wheel wobbled,.
Recall 94v058000. Dealer has not had parts since sept. 1999.
There was a clicking in the steering column.
Steering wheel loose.
Anti-theft alarm came on.
While merging onto the highwaysteering wheel failed. Consumer applied the brakes andpedal went to the floor. Vehicle continued to accelerate.consumer was not able to maintain control of the vehicle,andvehicle went downinto an embankment and flipped over three times.the driver was not injured. Consumer had the vehicle towed to the dealer for inspection, and mechanic was not able to duplicate the problem.consumer informed the driver that recall 94v058000 applied to this vehicle.however,mechanic determined that this recall was not for this vehicle.
Consumer not notified of bumper recall.
Bumper no impact resistance/corroded.
Left front goodyear tire tread separated, also r/front and rear tires were cupped, causing excessive noise when wheels turned.*skd
Tires failed. Replacement tires do not fail. ( dot number: tire size: 195/70r15c )
Rubber fell of the tires only after 14 kas a result of the steering problem.
Fuel/temperature gauge only works occasionally.i was quoted a price of $700.00 to replace at dealer several years ago but i know of three other vw eurovans with the same problem and i just found an article stating that replacement doesn't solve the problem, the existing board has to be soldered.i think vw should cover this as it is dangerous for all concerned to travel without knowing the car temperature or how much fuel there is. *nlm
Instrument panel gauges not responding, when consumer went ot test gauges the vehicle was parked in first gear with the emergency brake engaged, when the ignition key was turned the vehicle started and ran into the garage causing extensive damage, the design of the manual transmission (no clutach safety switch) allows for acceleration without engagment of the clutch.
Engine oil light came on.
Vehicle stalls when down shifting from 2nd to 1st due tothrottle position sensor failure. *dsh
Windshield defroster fails, causing poor visibility.*skd
The horns on my vehicle have been repaired three times and are again not working.the gas and temp gauge are not working and a local dealer said this is a persistent problem with eurovans.the air conditioning has gone out several times.the air conditionercompressor froze one time and melted the serpetine into all of the engine pulleys--cost to repair $4,000.00.headlights filled with water.rear heater fan clanks loudly.excessive noise in vehicle.
Front passenger door window shattered, sending glass inside/outside the vehicle. *dsh
Read more
