We found the following complaints for TOYOTA TUNDRA (2003)
Read complaints for TOYOTA TUNDRA (2003)
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign id number: 14v312000 (air bags) however, the parts needed were unavailable to perform the repairs. The manufacturer was not notified of the failure. The contact had not experienced a failure.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 15v286000 (air bags) however, the part needed to perform the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure.updated 09/09/15*ljthe consumer stated the recall repairs were not rectified. However, he was billed for other repairs. Updated 01/16/16.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 15v285000 (air bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
We have received two safety notices about the recall of our vehicle for front passenger airbag inflator module.the safety notices are not dated, however it has been at least 4 months since receiving.when taking the vehicle to the authorized dealer, we were told they do nothave the parts to repair per recall notice.we were told at that time, we would have to wait for a third notice.what a waste of money to continue to send out recall notices and not be able to complete the work required, let alone the safety factor.the problem has been identified, owners notified and 6 months later, here we sit.
"takata recall"
I received a toyota recall letter on 11/24/2014 that my truck is not safe to drive and to get the passenger airbag replaced.the dealer stated on 11/24/2014 they do not have the parts and cannot fix. I called toyota and they stated the parts will not be available until january 2015 at the earliest.the recall letter states the truck is not safe to drive and i should park it.as my only vehicle how is this possible to have no car for 3 months.
The srs symbol for passenger air bags came on in my toyota tundra on 7/8/17, while driving down the road
The red light on our passenger side is on and has been on
On october 17, 2014 while driving on okla hwy 33 at or about 55 miles per hour, the driver side and the passenger side air bags deployed.the deployment set off the horn and immediately the cabin filled with a fog like residue which in itself can be very startling.the air bag slapped both forearms but luckily i was back far enough it did not reach my face and there was no passenger present. The only physical damage was temporary redness of the forearms and a chronic cough developed later the next day requiring a doctor visit on the 20th of oct.the vehicle has been in the jim norton toyota dealership in okla. City since the 18th of oct. With no determination from gst or tms legal to date.
2003 toyota tundra.consumer writes in regards to air bag recall issues.the consumer stated about an hour after picking up the vehicle, he started the engine and noticed the air bag light was on. According to the recall notice, the air bag issue was the target of the recall. The consumer returned to the service area, and the technician put a computer device on the vehicle and the light went out. The consumer left the dealer and about half way home, the air bag light illuminated again. The consumer did not believe the issue was resolved.
Had safety recall performed on air bag, received car back and air bag light popped on. Prior to recall work, no light was on. Returned car 3 times for air bag light issue. I have car back but air bag light still on. Spoke with toyota motor sales usa and they opened case # [xxx] it appears that what ever they replaced, it triggered air bag light. Work performed at pat lobb toyota of mckinney texas. Www.patlobbtoyota.com. Has there been reports of this occurring? service dept acted very coy when questioned. The customer service rep called me on 9/28/15 @ 3:55pm said he would call me within 1 hour and give me some answers. As of today at 11am, have not received a call back. Thank youfor your time. This started in july 2015. Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Takana recall // and toyota recall
In mid december, 2019,i was driving on the interstate and the spare tire dropped from under my 2003 toyota tundra. Fortunately, no vehicles were behind me at the time.i was so surprised to see that tire bouncing down the road behind me!that spare tire had never been taken from the carrier.i made an appointment with a toyota dealer for inspection/recall in early february.they said the corrosion on the cross-member needed to be replaced but the spare tire carrier corrosion issue causing the tire to drop was only for recalls on the tacoma models,i was responsible for the issue. I feel this is a toyota manufacturing safety issue that needs to be addressed.do i have any recourse?
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 14v312000 (air bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Nhtsa campaign number: 14v312000 (air bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 15v285000 (air bags); however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2003 toyota tundra. The contact received a recall notice for nhtsa campaign number: 14v312000 (air bags) and stated that the parts were unavailable to service the vehicle under the recall. The dealer was uncertain when the parts would become available. The manufacturer was notified of the issue.the contact had not experienced a failure.updated 7/14/15
I received a safety recall notice from toyota, for my vehicle, due to a problem with the front passenger airbag inflator module. I called my local dealership to schedule an appointment for repair and was told they were not authorized by toyota to make the repair at this time.i called the toyota customer experience center at 1-888-270-9371 to ask about the recall. I was told the remedy notice was sent to me by mistake and that only certain states were included, for a no charge remedy, due to limited parts available.my complaint is that all states are not currently repairing this safety issue. The recall notice says "there is a risk of serious injury.
I was in motion and driving on a residential street, while operating vehicle atthe time of accident. After the collision, the airbag did not deploy. The takata airbag was replaced by the auto manufacturer (toyota dealership) prior to my above mentioned accident.the auto accident occurred for unknown reasons, possibly brake failure or unexpected acceleration of the carengine.
Takata recall, i was involved in a collision with my toyota tundra when a nissan altima failed to stop for a stop sign. At witch point my air bags did not go off. The truck is totaled and so was the nissan! i was driving east on quincy ave. And the nissan was driving south on b st. When she failed to stop at the stop sign.
The contact owns a 2003 toyota tundra. The contact was driving 35 mph when the vehicle crashed into two trees and the air bags failed to deploy. The contact sustained head injuries as a result of the crash. The police were contacted and a police report was filed. The vehicle was taken to a private mechanic and the manufacturer was contacted. The vehicle was not repaired. The failure and the current mileages were 155,000.
The contact owns a 2003 toyota tundra. The contact stated that the air bag warning light illuminated. The contact received notification of nhtsa campaign numbers: 05v254000 (air bags) and 15v286000 (air bags); however, the parts to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.
Takata recall-date for "when did this happen?" is approx. Date vehicle was manufactured (according to sticker on driver's door)
My airbag light on and i went to dealer they said is been replace before i bought the car and they i went to my mechanic they been replace some new part related to the airbag is been ok for one month now the lights on again.
Traveling on hwy 11. 4 cars ahead suddenly stop. I had 3 choices: hit the car in front of me. Go into on coming traffic, or head off the side of the road into the bayou. Missed the opportunity of the bayou, hit a parked semi tractor trailer. Nothing happened to the tractor trailor. My toyota got severely crunched on the right passenger side. My air bags never went off. I was going 30 miles per hour, and nothing deployed. Now i understand it is a good thing the airbags didn't go off.
Takata recall. I received a paper in the mail stating to file a ppic proof of claim because i had been identified as a current registered owner of a vehicle with a takata -manufactured airbag inflators containing psan. Despite not having suffered any injury, loss, or death it was recommended that i file this claim.
My air bag has never worked even after i brought it into the dealership 5 years ago
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 05v254000 (air bags); however, the part needed to repair the vehicle was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure.updated 04/06/15*ljthe consumer stated the vehicle was repaired on march 23, 2015.updated 6/25/2015
I know there was a recall on the airbags for the passenger side a few years ago and everytime i would called to get replaced as promised they did not have any airbags to repair and claim it wasn't that big of a deal you just couldn't have a passenger in your car and eventually they might be able to replace the faulty airbag. I just looked up information again on my truck and now it's not even showing that there was a recall but i do have documentation that they're actually was so i don't know if since they didn't have the parts to replace it it's not a valid recall or why they didn't have to comply with the recall because i think it's funny to not enforce recalls if they are supposed to. Nothing happened because i turned off the passenger airbag so i don't know if it's faulty or what but they refuse to replace it is my point and reason for my complaint i don't remember exactly when the recall was but it was actually a few years ago i have called numerous times to toyota and always been told they don't have parts yet i think that it needs to be reinvestigated
Airbag light came on.brought to dealer.dealer found two codes tripped, b0108 and b1100. Dealer reset codes and codes did not return.after owner drove vehicle for 5 miles and upon restart, the airbag light came back on.brought vehicle back to the dealer who found that the same codes had tripped.corrected by dealer by replacing the passenger airbag on/off switch and airbag ecu.parts were $599.51 and labor was $374.50. Background:the passenger airbag switch was never used (turned off) by owner (original owner).owner (an engineer) suspects that a short originated in the switch assembly or associated harness which damaged the ecu.owner did not abuse the vehicle and drove mostly on the highway.first vehicle that owner has ever had an airbag issue.
I was in a major car accident that involved both of my bumpers, the front bumper was completely removed. I was hit from behind at a faster speed than i was going and i was pushed into the truck in front of me (another tundra only a 2004). I had over $8,000 in damage and i suffer from cervical/neck/spine injury and sprained right foot. I am in physical therapy and need an mri, as i am not healing as i should be. My problem here is that my air bags never deployed. I am now worried that there is something wrong with them, the impact i had and injury to my body, should have deployed them.
2003 toyota tundra.consumer writes in regards to a pending recall notice stating a defective wafer possibility in air bag deployment.the consumer stated the recall was never addressed. However, he was giving a list of suggested repairs. The dealer informed the consumer, they had some type of computer issues, and they were not able to perform the work.
Takata recall on proposed airbag inflator. Airbag light is on
The contact owns a 2003 toyota tundra.while driving approximately 10 mph on a gravel road surface, the driver swerved to the left to avoid an obstacle in the road.suddenly, the vehicle rolled down the steep incline into a ditch.the vehicle landed on the passenger side.the air bags failed to deploy and the driver sustained injuries to the arm and neck.the vehicle was completely destroyed and was towed to a body shop.the insurance company was notified of the failure.the contact has pictures of the vehicle.the vin was unable to be entered into the system.the failure and current mileages were 117,000.
Airbag light came on went to toyota in national city capaid alot of money including a newbattery ,witch i got from aaaand still no fix
Received safety recall notice approximately sometime november 2013, while living in roseburg, or, regarding"front passenger airbag inflater module" defect in my 2003 toyota tundra . I have made several calls to dealerships on a regular basis to inquire when i would be able to get this recall completed. I received this notice well before the thousands of other vehicles were recalled for air bag issues. I was told i must wait for a second notice before repairs could take place. I need to know what my rights are or what i can do to get my vehicle fixed. I am concerned for my safety and the safety of others. Thank you,[xxx]information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
The contact owns a 2003 toyota tundra. While the vehicle was parked, the contact noticed that the plate covering the air bag was melted. The failure recurred on one other occasion. The vehicle was taken to the dealer who stated that the vehicle was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 69,700.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign id numbers: 14v350000 (air bags), 09v444000 (structure) and 05v225000 (suspension). The contact was waiting for several months for the recall part to become available and the dealer was not able to determine when the recall repair would be performed. The manufacturer notified of the issue. The contact did not experience a failure.
The contact owns 2003 toyota tundra. The contact received a notification of nhtsa campaign number: 15v285000 (air bags) however, the recall part needed was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 14v312000 (air bags) however, the part needed to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure.
I am driving without airbag safety because toyota dealership did not correct problemthey quoted me $85 to check it out and around $1000 to fix. On 09/03/2013, i took my vehicle to toyota dealership for urgent safety recall to correct airbag defect.i mentioned the airbag light again.i was advised the airbag recall will correct my problem and the light will go away.i picked up my vehicle and noticed my airbag light was still on.toyota advised me that the trouble is the center airbag module.i asked them if the airbags will engage on impact.toyota said the airbags will not deploy with this light on.why did i waste my time taking my vehicle to toyota to correct an airbag defect and to leave with an airbag defect?toyota should have corrected this issue a long time ago when this was under warranty.
Airbag light is on instrument panel. Per toyota dealer service dept,drivers side airbag needs to be replaced.
Took my truck to dealer on 7/11/2013 for air bag light on.dealer said light related to preliminary recall.dealer kept my truck for over 30 days until toyota decided what to do.finallyi picked up my truck on 8/12/2013 air bag light was off. Dealer indicated the airbag is oknotes from dealer: dif- safety recall dof (dif) preliminary notice 2003-2004 model year tundra vehicles front passenger air bag inflater module inspection. Dtc b1100 air bag senso r assembly b0108 short in squib circuit. Dsm oked rental car. ~|~dof applies rental provided w hen truck was in the shop. ~|~auth # d899b040 does not need any further attention light reset reset systemthe air bag light back on 9/9/2013 so i took truck back to dealer.dealer advised the light is not related to recall and is not under warranty.they could not say what was wrong and wanted me to pay for additional diagnosis.they could not say how long it would take or what could be wrong but were insistent that is was not related to safety recall.now i am without an airbag and they won't fix it.this does not make sense!!!how could it not be related to the recall?
Takata recall: the safety recall notice (remedy notice) from toyota motor sales usa states that the repair will take approx. 2 hours. When scheduling the dealer requires two different visits. One to inspect and disassemble the airbag and then reassembles the airbag. The part is ordered. Another appointment is required to install the repaired airbag or part. There is no mention of two appointments being required to remedy the airbag. Contacting toyota directly confirmed that dealers are informed that this remedy consumers to visit the dealers two times and ordering the part between visits. The toyota representative confirmed that the safety recall notice does not correctly state the time or visits needed to remedy the airbag issue. This needs to be changed and the safety notice needs to correctly inform consumers of the requirement to visit a toyota dealer two times for 2 or more hours each to remedy the issue.
Takata recall - i got the recall and went to my dealer to have them check it, 4-01-14, (59,317miles)got another recall toreplace the inflator air bag part (3-13-15). The air bag check light came on after i left the dealer (3-31-2015). I came back and showed them the check light on for the air bag. The serviceman couldn't find the problem.i waited about an hour and half for them to fix the check light problem. This recall started while my truck was still warranty. The dealer said i'm out of warranty back in 3-31-15 when i showed them the check light and i told them it happened when the serviceman replaced the takata inflator.i'm not going to pay for any of this, they probably just left a wire off. I've been driving my truck since then and i'm afraid the air bag will explode anytime or when i hit a bump. I need a good dealer to fix it and pay for a rental car if i need it.i contacted toyota customer and they said, " ....oh, your were out of warranty when they installed it..".are these people stupid or what?????
The contact owns a 2003 toyota tundra. The contact received a recall notification for nhtsa campaign id number: 14v312000 (air bags) and stated that the part needed was unavailable to perform the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure....updated 04/08/15 the consumer stated the vehicle was repaired. Updated 04/14/15
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 14v312000 (air bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Takata recall
Takata recall
The contact owns a 2003 toyota tundra. While the vehicle was undergoing recall repairs for nhtsa campaign number: 15v286000 (air bags) at galaxy toyota (750 nj 30, eatontown, nj 07724), the technician diagnosed that the front of the frame was completely rusted. The technician stated that the failure was not included in a recall. The manufacturer was made aware of the failure and stated that there was no recall. The contact was instructed to sign a waver, noting that the vehicle was unsafe to drive. The vehicle was not repaired. The failure mileage was approximately 295,000.
2003 toyota tundra. Consumer states problem with vehicle air bags *tgwthe consumer stated in september, the air bag light started blinking. He took the vehicle to the dealer, where they supposedly fixed the problem at a cost of $ 177.12. However, that same evening, the light started blinking again. He took the vehicle back to the dealer the next morning.the dealer stated the problem was with the wiring harness and the cost to repair it, would be anywhere from $ 2,506.00- $ 3,177.76 plus $ 975 for labor.
Takara inflatorsand driving down a very busy street and had a driver flashing his lights at me. I pulled over to find out that my spare tire underneath my truck had fallen off and bounced into a building. I go back to get it and notice that it had rusted and fell off. I've been having ball joint issues and now my rack and pinion has started to leak because of rust. I've learned about a recall on my frame has been issued. I called toyota and they said my truck had been looked at and no problem was found. I've got the spare tire and the rusted bracket. I'm really scared to even drive it,and air bag they want to replace it but to scared to drive it
Spiral cable, also called clockspring, failed, identical to other toyota spiral cable failures on other models that were recalled.another recall needs to be issued that corrects this dangerous problem (it disables the driver airbag and horn) for affected tundra models.
Travelling 45 mph in a 55 mph zone on wet surface. Vehicle began to spend out of control due to a vehicle tapping the passenger's rear bumper. After the spinout and contact with cement median losing the front bumper the truck stops. Airbag implodes about 15 secs after the accident.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 15v285000 (air bags); however, the part needed to repair the vehicle was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure.
Takata recall. The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 15v285000 (air bags); however, the part to do the repair was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2003 toyota tundra. The contact stated that the air bag compartment on the driver's side made a clunking/rattling noise. When the contact placed her hand on the center of the steering wheel, she felt a heavy object shifting around inside. The contact called toyota of the desert (located at 68105 kyle road, cathedrial city, california 92234; 760-328-0871) and was informed that there was no driver side recall on the vehicle for the air bag nor was there warranty coverage; therefore, the vehicle would not be repaired for free. The vehicle was not repaired. The manufacturer was made aware of the failure and opened case number: 1708252544. The approximate failure mileage was 115,000.
The contact owns a 2003 toyota tundra. The vehicle was included in nhtsa campaign numbers: 14v350000 (air bags) and 05v254000 (air bags). The dealer stated that the parts would not be available for months and offered to provide an interim repair by disconnecting the front passenger side air bag until the part was available. The contact stated that the delay was unreasonable and wanted a permanent repair for the air bag failure. The manufacturer was notified. The vehicle was not repaired. The contact had not experienced a failure.
My wife and i were traveling north on hwy 49 from oakhurst to mariposa, california.the highway surface was wet and slick as we had just experienced our first rain of the season.our toyota tundra truck went into a skid on a curve, climbed an embankmentand rolled one full turn to the left.we hit a manzanita tree and a fence before coming to a stop and rolling.the airbags were examined by toyota 9-24-2013 in response to a recall and were cleared . In the accident they did not deploy. My wife and i experienced numerous injuries including broken ribs, collarbone and severe whiplash.we are senior citizens and are still recovering from these injuries and dealing with our insurance company.we wrote to toyota 5-21-2014 to report this airbag failure.to date we have received no response.
The contact owns a 2003 toyota tundra. The contact stated that the passenger side of the dashboard's air bag cover melted and was sticky to the touch. The contact stated that, in the past, there was an unidentifiable odor coming from that area. The vehicle was taken to darcars toyota frederick (5293 buckeystown pike, frederick, md 21704 (301) 696-6300). But the cause of the failure could not be diagnosed. The dealer took pictures and sent them to a local toyota representative for darcars. The contact mentioned he was afraid to drive the vehicle due to sun glare and was unsure if the passenger side air bag was safe. The manufacturer was notified of the issue and did not assist. The failure mileage was approximately 65,000.
Takata inflators -i haven't heard back from you...... Complaint # 10948526serviceman was working on the air bag on my truck and service light was on when i left the dealership. This isn't a warranty problem, the serviceman made a mistake and caused the air bad bag light come on.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 14v312000 (air bags) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 14312000 (air bags); however, the part was unavailable to perform the repair. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 15v285000 (air bags), however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign numbers: 15v285000 (air bags) and 05v254000 (air bags);however, the part to do the repair was not available.the contact stated that the manufacturer exceeded a reasonable amount of time to provide the part to do the repair. The contact had not experienced a failure.
No incident has yet happened. We immediately tried to get the airbag corrected after receiving written notice of the recall. We are a military family and we are moving from hawaii to virginia on november 19th. We already sold our second car in preparation for the move a few weeks ago so the truck is the only vehicle we have for our family of 5 until we ship it on november 17th. We called the local dealer twice and the national toyota number once and have been told parts to fix this problem will not be available for at least 6 weeks. We are having the airbag disabled by the dealer on the 12th. We were told not to have anyone ride in the passenger seat (even after they disable the airbag) but since our family has 5 people and there are 5 seats in our only vehicle, we will have to put someone there at some point. We were not offered a rental car to mitigate the risk nor any other feasible solution.
Extreme rust area all around rear differential, pitting in metal, and also the spare wheel tire extreme rust.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign number: 15v285000 (air bags); however, the parts were unavailable to perform the repairs. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall remedy. The manufacturer was not notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2003 toyota tundra. The contact received a notification for nhtsa campaign numbers: 14v312000 (air bags) and 05v254000 (air bags); however, the parts needed to do the repairs were not available. The contact believed that the manufacturer exceeded a reasonable amount of time to perform the recall repairs. The manufacturer was not made aware of the delay. The contact had not experienced a failure.
Have gone to my local toyota store informed them i received a letter for recall on air bag inflators. I was told they when they have the-part they will fix it's been probably 3 to 4 months since i've heard anythingand i have gone to two different toyotas.when will this be resolved
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign numbers: 15v285000 (air bags) and 05v254000 (air bags). The parts to do the repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2003 toyota tundra. The contact stated that the recall notice for nhtsa campaign number: 15v285000 (air bags) was received in august of 2015. After contacting the dealer on multiple occasions, the contact was informed that the parts needed to repair the vehicle were still not available and no estimated time for receiving the parts could be given. The contact had not experienced a failure.
Takata recall. The contact owns a 2003 toyota tundra. The contact received a notification of nhtsa campaign number: 15v285000 (air bags); however, the part for the recall was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Parts distribution disconnect. ...updated 02/08/16 ; updated 04/25/18
2003 toyota tundra.consumer writes in regards to vehicle passenger airbag recall issues.the consumer was informed the parts were not available.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign numbers: 15v285000 (air bags) and 05v254000 (air bags); however, the parts to do the repairs were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Updated 01/27/16*lj updated 4/2318
The contact owns a 2003 toyota tundra. After the vehicle was started, the driver side air bag warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that an unknown part related to the steering wheel needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 261,000.
Takata recallair bags lights is on, the passager side.i took to the shop to fix, a months later came back again the lights.
Takata recall. The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign numbers: 15v285000 (air bags) and 05v254000 (air bags) and stated that the parts needed for the repairs were not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2003 toyota tundra. The contact stated that the recall notification for nhtsa campaign number: 14v312000 (air bags) was received in june of 2014. After contacting the dealer on multiple occasions, the contact was informed that the parts needed to repair the vehicle were still not available and no estimated time for receiving the parts could be provided. The manufacturer was not notified of the delay. The contact had not experienced a failure.
The recall notice is 5 1/2 months old.toyota stresses that no one should occupy the passenger's seat.toyota states that the parts are not yet available and they take no responsibility for anyone injured because of this defect.multiple calls to the toyota corporate office have yielded no help.
Air bag warning light came on in less than 36 months after warranty expired due to mileage.cost to repair exceeded $1,200.shouldn't these government mandated safety features be covered by a longer warranty?
Airbags did not deploy in a 2 vehicle front end crash.
Tl * - the contact has a 2003 toyota tundra.the contact stated that he had a safety recall number (05v254000) on his vehicle.the contact took his vehicle to the dealer 01/16/2007, and the dealer said that they would affix a new sticker to the sun visor and that was there remedy.the contact is concerned that the safety recall stated more to the remedy than what the dealer is willing to repair.the contact would like to know what is correct, what is stated in the safety recall or what the dealer stated he would do.
Battery drains with all electrical components shut off. If vehicle left sitting much over one week it will completely drain the battery to the point that it will no longer hold a charge. I've replaced the battery 5 times in one year and finally put a quick disconnect on the negative battery post. I've had toyota look at it twice and they say there is nothing wrong.
Battery drains with all electrical components shut off if vehicle left sitting much over one week.after third visit to dealer, they replaced a wiring harness.the problem persists.
Spiral cable, also called clockspring, failed, identical to other toyota spiral cable failures on other models that were recalled.another recall needs to be issued that corrects this dangerous problem (it disables the driver airbag and horn) for affected tundra models.
"takata recall"
Vehicle was traveling about 35mphand while making a left turn, without prior warning, vehicle shut off.
2003 toyota tundra. Consumer states problem with vehicle air bags *tgwthe consumer stated in september, the air bag light started blinking. He took the vehicle to the dealer, where they supposedly fixed the problem at a cost of $ 177.12. However, that same evening, the light started blinking again. He took the vehicle back to the dealer the next morning.the dealer stated the problem was with the wiring harness and the cost to repair it, would be anywhere from $ 2,506.00- $ 3,177.76 plus $ 975 for labor.
Takana recall // and toyota recall
The contact owns a 2003 toyota tundra. While driving 65 mph, the contact heard an abnormal dragging noise coming from the vehicle. Upon exiting the vehicle, the contact noticed that the fuel tank was rusted and detached. Also, the check engine indicator illuminated. The contact called don moore toyota(4216 frederica st, owensboro, ky 42301, (270) 926-2500) and was informed to have the vehicle towed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and did not assist. The failure mileage was 129,000.
Seat belts not working properly and frayed webbing also fear of timing belt going out while driving with family and causing me and my family and/ or a oncoming vehicle to wreck and have serious injuries or multiple deaths!
I bought my 2003 tundra new.got 15,000 miles on it when the engine light show.the dealer they fixed it and again nowat 49,000 miles.
The contact owns a 2003 toyota tundra. While exiting his home, he noticed that his vehicles hood was on fire and that there were dripping flames falling from the passenger side tire. The vehicle has not been diagnosed by the dealer and the contact did not notice any warnings prior to the failure. The fire was extinguished and there were no injuries. The current and failure mileage was 71000.
When having an oil change dealer noticed a severe oil leak. The head gasket/ oil pan bolts, and upper oil pan were replaced at different times before oil leak was fixed.
When drivingconsumer smelled fumes coming from the vents, causing the consumer's eyes to burn, and making it hard for the consumer to breath.
Engine light on. I have taken in 3 times. Unknown cause/emission system or fuel system. Engine has 2206 miles on it.*la
Frame and rear end banjo housing rotted to the point where gear oil from rear end leaked out onto the road. Had to have vehicle towed to garage to make temporary repairs.in addition, frame is disintegrated with pieces falling to the ground. Taken to an independent garage and was told to take truck to toyota and both the rear end assembly and frame should be replaced. Garage, stewart's of georgetown, ma., states metal of frame has deteriorated to the point where you could poke holes in it with a screw driver. Frame examined on august 6, 2011 after pieces of frame found under the truck after labor day weekend. Truck has 40,700 miles on the odometer and used to deliver and pick up supplies for property owned.the consumer to date, he has been unable to locate a usable rear end assembly. The consumer believe the failure was directly related to the use of reprocessed metal in the manufacturing, together with the failure to properly treat exposed metal parts with corrosion resistant compounds. The consumer stated after the vehicle was returned to him. The check engine light illuminated. The vehicle was taken to an independent repair shop where it was necessary to replace the oxygen sensor that had been previously replaced in august 2007. Updated ivoq 12/01/11
Dt*: the contact stated the catalytic converter is spewing sulfur dioxide when the engine is running. The vehicle was taken to the dealership for inspection, but could not be repaired because the dealer does not have an updated converter. The dealer could only use the same type of catalytic converter which they determined would have the same problem.the window regulator was replaced.updated 02/07/06.
Narrative:1.normal driving2. Cracked exhaust flange(s).3. Nothing, yet.
Last week i purchased a 2003 toyota tundra limited 4x4 from a used car dealer.after getting the vehicle home (8.5 hours away), i noticed the left side cargo light (exterior next to the 3rd brake light) was burned out.when i removed the lens to determine the light number needed for replacement, i found the housing to be melted.upon inspection, the bulb was the recommended bulb by the manufacturer.my concernis that this is a manufacturer defect that could cause a fire in the vehicle.i can provide photos of the housing and the bulb if required.
The contact owns a 2003 toyota tundra. When the vehicle was preparing to undergo a state inspection, the contact was informed that the brake and back up lights on top of the cabin would not illuminate. While replacing the light bulbs, the contact noticed that the light fixtures on both sides were melted. The vehicle was not taken to the dealer or an independent mechanic for diagnostic testing. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 109,000. *dtupdated 11/2/18
The vehicle's third brake light assembly has melted holes all the way through the internal plastic structure above the both cargo lamp bulbs. After investigating this problem on the internet it is apparently very common problem. There are also previous complaints filed with the u.s. Department of transportation, addressing the same issue. My concern is of fire and/or failure of the thirdbrake light. This is a safety problem that toyota has not addressed.
Takata recallair bags lights is on, the passager side.i took to the shop to fix, a months later came back again the lights.
Tl-the contact owns a 2003 toyota tundra.the contact began to smell gasoline inside the vehicle.the vehicle was taken to an authorized dealer where they were unable to diagnose the failure.the failure continued so the vehicle was taken back to the authorized dealer where a leak was found along the welding within the fuel tank.the fuel tank was replaced.the failure mileage was 52,754 and the current mileage was 54,754.sm.
Check engine light came on and dealer advised the fuel filler tube had to be replaced for several hundred dollars. This seems to happen in most 2003 tundra according to research.because truck has 136,000 miles, dealer refused to provide any help with cost of labor or parts. Dealer did acknowledge this has been a problem for 2003 models.so much for toyota dependability.
My 2003 toyota tundra had a check engine light come on.diagnostic codes pointed to the fuel filler tube and air pressure tests by my personal mechanic (not a toyota dealership) proved that there was a crack in the fuel filler line.the mechanic states that they see this happening in many toyota's they work on.they suggested mentioning this to toyota directly, so when i go in for my other recall (severe corrosion of the rear cross-member) i am going to bring the original fuel filler tube that i had to replace for $300.i also see complaints being filed from other tundra owners about this same issue happening to them.
I received the ssc 90m - tundra vehicles severe corrosion of the rear cross member phase 2 - crc application. My truck has a tonneau cover and a bed rug installed. When i called the dealership to schedule an appointment they informed me that the bed of the truck would have to be removed to complete the repairs. I told them that i did not have the means to remove the tonneau cover and the bed rug. They said that they could not perform the repair without these items removed and that they would not remove them for me. I then contacted toyota customer experience center at 800-331-4331, extension [xxx] and discussed the situation with [xxx]. She claimed that the recall letter states that the truck must be presented in "factory condition" (i guess that means no bed rug or tonneau cover). I reread the letter and that is not stated anywhere in the letter. I called her back and she was unable to assist me nor would she elevate my issue to the management level. This recall work must be done, and again, i have no means to remove these items. I'm sure that i'm not the only tundra owner experiencing this issue. This truck will be unsafe to drive if the recall work is not done. Please help. Thank you.information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Engine light on. I have taken in 3 times. Unknown cause/emission system or fuel system. Engine has 2206 miles on it.*la
Engine check light on due to small leak in evaporation control.toyota dealer inspection determined leaking filler tube.cost to replace $350+.how many of these complaints are necessary before this is recognized as a defect?
Engine check light.during emission inspections it was determined that a repair was necessary.cracked fuel filter was replaced.total cost of repair $320.
As i was traveling at a slow speed when i became aware of a loud grinding noise which had suddenly began as i turned onto a side street.i stopped vehicle immediately and got out to investigate what was causing the noise. I discovered that my fuel tank was dragging beneath the truck. The metalstraps that held tank to frame had rusted thru causing tank to fall to road surface. All the connections to fuel tank were ripped from tank. Toyota is worried about the spare tire falling down do to rusted frame members but i feel they should be more worried about their fuel tanks falling off. If i had been traveling at highway speeds i hate to think of what consequences might have been.
I was driving down the road when the 'check engine' light came on.i took it to the dealer to see what the issue was and they stated it was a leak in the gas cap and that i didn't have cap tight enough.on the way home from the dealer the 'check engine' light came back on, so i took it back to the dealer.they stated that the fuel filler neck needed to be replaced and it's not covered under warranty.
While driving at approximately 60 mphvehicle caught on fire. The fire was discovered after about 45 minutes of driving, and it was between the cab and the bed of the vehicle. Owner contacted the manufacturer, and was told that they would look in to it......
Fuel tank filler was giving as the reason of my trucks problem before it was looked at by a technician. I was told that this was a common problem with these trucks. The fault would cause the emissions system to fail and therefore would also be a hazard because it could cause a fire at the time the truck was being filled or from escaping vapors.the part was (is) being replaced and is costly to the consumer.
I took my 2003 toyota tundra in to toyota motors, guam because i had a check engine light. Toyota then sent a message to my vehicle service contract, warrantech automotive inc and they said that thefuel filler neck hose assembly was not covered. Reading information on the internet indicates that this is a common problem with the 2003 toyota tundra due to a "out of round" gas filler tube. There should be a recall on this part. Please assist consumers like myself for toyota motors to investigate this defect with the 2003 toyota tundra. The word needs to get out.
There is a flawed design of the fuel filler tube causing an intermittent check engine light.this isa known problem that toyota has with its 2003-2004 tundras.the problem affects fuel vapor emissions from the gas tank.they offer no support once one is out of warranty even though they are aware of their faulty design/build of this part.
The contact owns a 2003 toyota tundra.the contact noticed that the main frame of the vehicle was perforated due to severe rust corrosion.the vehicle was taken to an authorized dealer for inspection and they replaced the rusted fuel tank filler neck.the vehicle was taken back to the dealer on a separate occasion.the technician detected a rusted brake backing plate, and the front and rear brakes were replaced.in addition, four new tires were mounted on the vehicle.the technician was unable to perform a tire alignment due to the significant frame damage.the vin was unable to be entered into the system.the failure mileage was unknown and the current mileage was 62,000.
There is a flawed design of the fuel filler neck causing the check engine light to come on.service advisor stated that itwas a known problem but because my warranty was out, they would not cover the repair which ended up costing me $462.32.my mileage is only 14,500.
Check engine light always on giving gas codes.after extensive research this is a common problem with 2003 toyota tundras.mine has been on my truck for 3 years since i bought it, and i constantly need to get it reset, until i decide to pay to get it fixed.
Check engine light on. Code related to evaporation/fuel system. Checked the fuel cap, appears ok, reset light and returned on. Will replace fuel cap.potentially fuel filler pipe as mentioned frequently on here.
Took 2003 toyota tundra in for frame rust corrosion program 09v-444000.was told frame and other components had extensive rust and multiple 10mm holes by lead service technician at local toyota dealership.service manager explained that my 2003 toyota tundra frame was extensively rusted and unsafe to be on the road and they wanted to take my truck immediately and provide a rental car due to safety concerns.asked for a plan of action of the scope of work to be performed (corrosion compound verses frame replacement) before giving possession of vehicle.photos of 2003 toyota tundra frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system were taken and sent to lead service tech three states away in texas.was informed extensive frame rust exists on all components (frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system)but it is not covered because vehicle is no longer registered in wisconsin.purchased this 2003 toyota certified vehicle in wisconsin in april of 2010 and no information was given to me at regarding the nhtsa investigation or any rust inspections that were performed.toyota corporation refuses to repair, replace or add corrosion resistant compound to any severely affected rusted components. Significant rust issues exist on this vehicle and still toyota corporation refuses to provide any documentation of their inspections.toyota corporation will not put in writing that the frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system is safe or road worthy.deadline for all rust repairs is december 31, 2012.toyota corporation is stalling consumers to keep from doing any repairs and leaving unsafe rusted 2003 toyota tundra's on the highways.please initiate a new nhtsa investigation regarding this matter for the safety of consumers.
The contact owns a 2003 toyota tundra. While driving 65 mph, the contact heard an abnormal dragging noise coming from the vehicle. Upon exiting the vehicle, the contact noticed that the fuel tank was rusted and detached. Also, the check engine indicator illuminated. The contact called don moore toyota(4216 frederica st, owensboro, ky 42301, (270) 926-2500) and was informed to have the vehicle towed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and did not assist. The failure mileage was 129,000.
My toyota had a frame recall for rusting which they fixed. Now i'm being told my gas tank is rustingand needs to be replaced.toyota will fix it for 1500. 00 dollarsi believe this is a safety problem and is atoyota problem.
The contact owns a 2003 toyota tundra. While driving various low speeds and approaching a stop, the fuel tank detached from the vehicle and fell onto the ground. The contact temporarily re-attached the fuel tank to the vehicle and was able to drive home. Romano toyota (6400 basile rowe, east syracuse, new york 13057, (315) 445-1070) was made aware of the failure and requested that a diagnostic test be performed. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The contact referenced nhtsa campaign number: 09v444000 (structure). The failure mileage was approximately 155,000.
My 2003 toyota tundra's passenger door light keeps coming on and the locks go off and on by themself.
The frame on my 2003 toyota tundra is rusting badly.toyota was unable to align my front end due to rust, and it has caused the emergency brake system to completely freeze up and the brake will not work. It is a complete failure of the emergency brake system, i have no brake.toyota tried to free up the brakes but were not able to.they gave me a can of lubricant and told me to keep lubing the frozen section.they were completely unable to align my front end.
When returning to my2003 toyota tundra, from a doctors appt, i noticed a pool of liquid, under the rear axle of the truck.having wife back truck up, i checkedthis viscous, clearish fluid, finding it to be a rear end oil/grease, and had been leaking from mid housing of the rearend.upon further inspection, i found this had been leaking for enough time that oil spots were all over the rear window of and tailgate of truck. I called toyota to look at it and they wanted ?$120 just to look at it, so i brought to a mechanic down the road form toyota and he found the rear axle housing had rusted thru. He in 40 years had never heard of this problem, and while searching for a replacement rear end, could only find one "good used" one in new england.he obtained and replaced my damaged one, for a cost of >$1000.he later told me he had another one come inless then a week, same problem. At home, i found oil had been leaking front the back of the truck for some time, evidenced by oil on the ground and wood near where the back of the truck was backed into driveway.
For the third time since i have owned the vehicle where the shift control goes into the steering column, where it connects has broken. This is a piece of metal that has again snapped making it unable to shift the car. What happens if i was in drive and could not shift into park? i have had this fixed twice before, once when i was stuck on the road and once towed to toyota.
The rear differential housing of the truck is rusted through and leaking gear lube, if it goes unnoticed the rear differential could lock up causing the rear wheels to lock up and cause a crash. This a very common issue with the 2000-2003 tundras and is very unsafe, there is no reason the rear differential housing should rust through this quick, 30 year old trucks do have this issue but a whole lot of toyota trucks do, if you do a search on google for rusted through differentials its all toyota trucks, and its not just a differential cover its the entire housing, i would not be writing this if it had a cover i would have replaced it in an hour and called it a day. The frame of the truck was already replaced because it rusted through and now the differential housing is rusted through due to substandard materials used in its construction. This is a serious issue just like the frame that needs to be addressed.
The contact owns a 2003 toyota tundra. The contact stated that while driving 30 mph, he switched from four wheel drive to two wheel drive and the entire front end of the vehicle abruptly and violently seized. The vehicle was taken to the dealer for diagnosis and the entire front differential was replaced. The manufacturer was not notified. The vehicle was repaired.the failure mileage was 120,00 and the current mileage was 125,000. ... Updated 02/27/13
Hello, i am having a really strange problem with my 2003 tundra, the rear axle is actually rusted out and leaking gear lube!i live in a snow area and drove the truck for a couple months before noticing the oil on ground after snow melted, now it is too late as the rear axle is now making a noise and cannot be driven until i replace the entire axle housing!you cannot hear it in the cab unless windows are down!i have taken exceptional care of this truck and all my cars, washing and waxing frequently even in winter. The truck has been back for rust inspections and frame coating but nothing for the axle!i have actually spoken with a number of other toyota owners that are also experiencing the same with their tundra! actually this could cause a serious accident if the bearings seize from no lubrication and cause the truck to lock in the rear!i really can't believe toyota would not stand behind this error!i really cannot afford the 4-5 thousand repair on the truck!i have had many new toyota cars and trucks starting in 1984 with an all wheel tercel followed by 5 tacomas, every 2 or 3 years, a previa, a sienna and in 2009 a camry hybrid. I was going to sell it to my son and buy another tundra but i am not so sure now. I feel toyota should cover this structural defect.i have never seen any other car or truck that actually rusted through the axle housing! also the floor of the bed in the tundra where the cross braces are welded to are rusted through as well, this started within 2 years of ownership!i have read on the internet about all the other tundra owners having the same issue!i have been a big supporter of toyota but maybe that is coming to an end!
Toyota had a recall of rusted out frames for 2003 toyota tundra trucks.mine was replaced, but now the differential has rusted out and it requires an entire new rear axle.i filed a complaint with toyota corporate and was told since my vehicle is out of warranty they will not stand by their product and replace an obviously defective part.this defect could cause the rear end to lock up while driving and possible cause an accident with injuries.
Noticed oily substance on driveway, took truck to mechanic and he informed me the rear axle housing had rusted through!i was shocked at the news and dumbfounded to find out this is a common problem with tundra's and tacoma's and there is no recourse except to pay upwards of $2000 to have it fixed.i have never heard of any newer vehicle having the axle rust through at only 104,000 miles.this is low miles for a 2003 and the truck has been taken care of too.
Took 2003 toyota tundra in for frame rust corrosion program 09v-444000.was told frame and other components had extensive rust and multiple 10mm holes by lead service technician at local toyota dealership.service manager explained that my 2003 toyota tundra frame was extensively rusted and unsafe to be on the road and they wanted to take my truck immediately and provide a rental car due to safety concerns.asked for a plan of action of the scope of work to be performed (corrosion compound verses frame replacement) before giving possession of vehicle.photos of 2003 toyota tundra frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system were taken and sent to lead service tech three states away in texas.was informed extensive frame rust exists on all components (frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system)but it is not covered because vehicle is no longer registered in wisconsin.purchased this 2003 toyota certified vehicle in wisconsin in april of 2010 and no information was given to me at regarding the nhtsa investigation or any rust inspections that were performed.toyota corporation refuses to repair, replace or add corrosion resistant compound to any severely affected rusted components. Significant rust issues exist on this vehicle and still toyota corporation refuses to provide any documentation of their inspections.toyota corporation will not put in writing that the frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system is safe or road worthy.deadline for all rust repairs is december 31, 2012.toyota corporation is stalling consumers to keep from doing any repairs and leaving unsafe rusted 2003 toyota tundra's on the highways.please initiate a new nhtsa investigation regarding this matter for the safety of consumers.
2003 toyota tundra front end making a severe grinding, squeaking, and knocking noise. The cv axle boots are destroyed and seems like the wheel bearings and hub is going out quickly as well. Also have transmission leakage and noise when turning. Vehicle only has 86,000 miles on it.
My 2003 tundra sr5 4x4 access cab broke down coming to a complete stop during interstate driving in 2wd at the posted speed limit. Upon a lengthy and expensive tow to my mechanic, i was advised the rear differential had failed due to extensive rust not only on the rear differential cover, but over the entire rear axle assembly. The rust was so pervasive it allowed differential fluid to leak from the carrier assembly resulting in heat and friction leading to the catastrophic failure of the differential gears.the truck has just over 48,000 miles on it and had previously been recalled for replacement of rusted fuel tank straps. I received no satisfaction from any toyota dealer except to be referred to toyota usa. As such, i contacted toyota motor sales, usa direct on oct. 28, 2013 and was assigned a case number (incident: 131027-000079).as expected, toyota's oral reply on oct. 29, 2013 failed to acknowledge any responsibility for the excessive rust that is plaguing many tundra owners and is resulting in expensive repair costs that would ordinarily be unnecessary had the vehicles been properly manufactured.rather than simply apologize for the inconvenience and advise the matter would be elevated to management and rather than hide behind warranty expiration excuses, toyota should be ashamed of its maleficence and in the interest of maintaining its reputation and owner base, do the right thing and correct this well documented deficiency.toyota's response is typical of what other owner's are reporting on various web sites including "tundra solutions" and others. This is a serious defect for which toyota should accept full responsibility. This failure could have led to a serious accident had there been a rear end collision or had control of the vehicle been lost while steering into a muddy median where road construction was in progress.
The contact owns a 2003 toyota tundra. The contact stated that while shifting from park to reverse, the shift lever fractured and detached from the vehicle. The vehicle remained in reverse. The vehicle was taken to the dealer, who replaced the shift assembly, lever sub assembly, tilt lever and the shift lever. The failure was reported to the manufacturer, who refused to provide any assistance. The failure mileage was 125,426. The current mileage was 125,540. ..updated 08-07-13 the dealer replaced the column and replaced the broken shift components. Updated 08/13/13
Ibelieve toyota sold hundreds, possibly thousands of this type vehicle to customers who asked for a limited slip differential and paid a premium to get one. Many times when on slippery surfaces one rear tire just spins with no traction to the other. My window sticker says i have lsd and i don't. The mechanic at desert toyota told me i didn't have a ls when he changed my rear dif oil. I couldn't believe what he told me, "no, you have a regular drive rear end." several months passed and i drove the vehicle down to precision toyota where i bought the vehicle. They just looked underneath the truck and said i had it. I said i didn't. They pointed to a decal and that was their proof.i asked for a test to be applied to it to prove it but said they were to busy and declined to do it that day. A day or two later i took the vehicle back to desert toyota where the mechanic worked that said i did not have lsd . When i described my concerns and asked for the mechanic they said he wasn't available and gave me some other guy. They jacked the rear end up and told me when they spin one rear tire in one direction and the other tire spins in the opposite direction that proves i have ls. But the information i get off the internet and independent mechanics says the opposite is true. . they say if i spin one rear tire in one direction the other should also spin in the same direction. I believe toyota committed fraud and did not give me what i paid for and will not except the true facts.this rear ends puts me in dangerous slip and slide risks when on slippery surfaces that results in no traction.
I took my 2003 tundra to a transmission repair shop, independent, to have the rear differential evaluated due to crunching sound which occurred when taking off from a stop and leaking of fluid due to corrosion onhousing. The shop called me that day two hours later and informed me that my frame was completely rusted out near the front of the vehicle on both sides making it unsafe to drive and not worth proceeding in any repairs of the rear differential at this point. They contacted the nearest dealership which told them that the frame perforation recall, nhtsa # 09v444 had expired 7/31/2015 six days prior. I was instructed to call toyota, which i did. The lady informed me that the recall was still ongoing. I took the tundra to that same dealership for them to inspect the frame. The next day they call me and inform me that i need to contact toyota again myself. This is a toyota garage telling me this. Tonight i get on toyota's website and find two recalls in regards to the frame perforation. According to the toy website both status' of recalls offer remedies available and this site is updated 8/7/2015. I can see that my nearest dealer isn't going to be very helpful. My truck has 112,000. I'm the 2nd owner and have been diligent with maintenance. I do no off roading and use if to transport my motorcycle to races hundreds of miles from home.
I am a retired toyota master diagnostic technician. As i was replacing my rear brake lines on my 2003 tundra-with 79,962 miles, i saw a fluid leak under rear of vehicle. Upon inspection i found the rear differential housing has rusted so badly that the gear oil is leaking through the housing. Unfortunately the only remedy is the replacement of the complete rear axle/differential assembly. The frame has already been replaced-under recall. The rear brake lines have rusted through which had to be replaced- at my expense. Also the power steering lines have also rusted through which also had to be replaced- at my expense. It is obvious that the material that was used is of very low quality causing very dangerous situations.ie; loss of vehicle control due to differential lock-up, loss of vehicle braking due to rapid fluid loss, loss of vehicle steering control due to rapid fluid loss. I am amazed that toyota motor co. Will not stand behind the product they sold-without being forced to. One quick look under a 2003 tundra is all it takes to see that low/poor quality hardware and materials were used. Without repair and/or replacement of above stated components someone will get injured-possibly fatally. My brakes failed as i was towing a trailer in heavy, citytraffic. I was going 35mph when a vehicle pulled out in front of me and then proceeded to stop suddenly to make a left turn into a parking lot. I slammed on the brakes and the pedal went to the floor. I was lucky there was room to maneuver to the rightso i was able to avoid hitting the vehicle in front of me. I'm sure there have been those less fortunate. Please investigate these complaints as soon as possible. These components should last for the lifetime of the truck. A differential is not an item one expects to ever replace. Owners have been complaining about these failures for years. Thank you.sincerely,....
Shift assembly broke.
Steering column shift bracket broke in 3 places when trying to shift from park to drive, making shifting impossible. See pictures from 2 of 3 fracture locations, 3rd fracture is at an attachment screw (not shown). This is cause by an punderdesigned part made of inferior cast aluminum. There are thousands of reports of this problem on tundras and other toyota models with same defective bracket. This dangerous defect must be recalled and fixed by toyota with a redesigned part.
Toyota had a re-call for excessive corrosion on the 03 tundra. I have been taking the truck in for inspections for 3 years & was told everything was ok. This year toyota said they had an ok to undercoat the frames. While my truck was in for the work it was discovered that the rear differntial had rusted through & was leaking oil. Even though this componenet is on the underside of the truck just like the frame that was covered the repairs were not covered under the recall. It was obvious that the issue was caused by corrosion. Total cost of the repair was $2000 for the rear differntial casing to be replaced.why was this not covered under the recall if the componenet is part of the uderside of the vehicle?
Bad frame rust bad suspension rust bad differential rust bad spare tire rust.if rust condition gets worse the possibility of suspension failure is very real.some of these models need to be recalled or bought back before thereis injury or death.
The contact owns a 2003 toyota tundra.the contact stated that while having the vehicle serviced, he was informed that the differential was rusted out and that fluid was leaking. As a result, the differential needed to be replaced.the vehicle was not repaired.the manufacturer was notified of the failure.the failure mileage was 80,000.
I have a 2003 tundra access cab 4wd truck.took it to the toyota dealership for the rust recall inspection and to investigate oil leaking from the rear differential housing.dealership said that the frame was fine but the cross members and tank supports need coating.they also advised that the rear differential housing was rusted to the point that oil is leaking and would have to be replaced.they said that toyota is not responsible for the replacement of the rear axle housing.the vehicle has 108k miles.i can not believe that with all the known rust issues that toyota will not stand behind this problem.
The vehicle rolled back while in the park position.the transmission assembly was replaced.the consumer requested either a new vehicle or a full refund for the vehicle.mrscc
2003 toyota tundra 4wd with noise and vibration resulting from oil viscosity. Ph
Overdrive malfuncioned at 10,000 miles.randomly the vehicle's overdrive transmission acts oppositely to what shown on the display screen.when "overdrive off" light is on, overdrive gear is still on - turn the overdrive swith on and "overdrive off" lights turns off but the vehicle is still on 3rd gear (overdrive off).malfunction stops when the engine is stopped.toyota states this caused by the customer clicking the overdrive switch quickly several times.this is incorrect statement, the overdrive malfunction happens even with one click.toyota also states this is normal condition as it is designed and the vehicle is safe to drive.i suffer poor gas milage and unsafe condition by transmission acting unexpectedly when malfunction occurs.engine speed goes up very high and noisy on highways when malfunction happens.customer is concerned about engine wear from long driving.
Steering column shift bracket broke in 3 places when trying to shift from park to drive, making shifting impossible.see pictures from 2 of 3 fracture locations, 3rd fracture is at an attachment screw (not shown). This is cause by an underdesigned part made of inferior cast aluminum. There are thousands of reports of this problem on tundras and other toyota models with same defective bracket.this dangerous defect must be recalled and fixed by toyota with a redesigned part.
The contact owns a 2003 toyota tundra. The contact stated that while shifting from park to reverse, the shift lever fractured and detached from the vehicle. The vehicle remained in reverse. The vehicle was taken to the dealer, who replaced the shift assembly, lever sub assembly, tilt lever and the shift lever. The failure was reported to the manufacturer, who refused to provide any assistance. The failure mileage was 125,426. The current mileage was 125,540. ..updated 08-07-13 the dealer replaced the column and replaced the broken shift components. Updated 08/13/13
The contact owns a 2003 toyota tundra. The contact was driving approximately 45 mph. The clutch pedal stuck without fully releasing and the gear selector failed to shift out of gear. The contact was able to continue driving safely. The failure occurred on two separate occasions. The vehicle was unable to slow down unless aggressive force was applied to the brakes or the engine was turned off. The failure mileage was 53,000. The current mileage was 60,000.
Entire rear end housing rusted away requiring a whole new rear end housing.frame is rusting out on whole truck.
When returning to my2003 toyota tundra, from a doctors appt, i noticed a pool of liquid, under the rear axle of the truck.having wife back truck up, i checkedthis viscous, clearish fluid, finding it to be a rear end oil/grease, and had been leaking from mid housing of the rearend.upon further inspection, i found this had been leaking for enough time that oil spots were all over the rear window of and tailgate of truck. I called toyota to look at it and they wanted ?$120 just to look at it, so i brought to a mechanic down the road form toyota and he found the rear axle housing had rusted thru. He in 40 years had never heard of this problem, and while searching for a replacement rear end, could only find one "good used" one in new england.he obtained and replaced my damaged one, for a cost of >$1000.he later told me he had another one come inless then a week, same problem. At home, i found oil had been leaking front the back of the truck for some time, evidenced by oil on the ground and wood near where the back of the truck was backed into driveway.
I own a 2003 toyota tundra.it currently has 101,200 miles on it.i purchased it brand new and when i reached 15,000 miles the shift column to the right of the steering wheel snapped off in my hand.i brought it to the dealer that i bought it and it took them three weeks to fix because they claimed not to have a tool needed to reassemble the various parts of the column.at approximately 39,000 miles the column again snapped off during normal operation.this time i took it to another toyota dealer because i had no confidence in the original one that fixed it.i had to argue with the new dealer over covering the repair under warranty which they did eventually do.once again the second dealer had the vehicle nearly 3 weeks and once again they cited the lack of the appropriate tool to reassemble the column.they actually said they had to fabricate a tool to make the repair.and finally yesterday, the column has snapped for a third time.i can assure you that this is not occurring in a fit of rage, nor am i aggressively handling the shift each time i engage the truck into drive.both dealers claim that this repair is unheard of at their dealerships which is probably true.i wanted to report it to you all in case there were additional reports coming from other areas of the country.thank you.marc a. Lapierre
Truck cab shakes during higher speeds, toyota dealers reviewing the problem say that's just how it rides.
The contact owns a 2003 toyota tundra. The contact took the vehicle in for unrelated repairs when the dealer informed him that the rear differential was leaking and corroded. The dealer advised having the component replaced but the vehicle was not repaired. The current and failure mileage was 107,000. The vin was unavailable.
I'm the owner of a 2003 toyota tundra (limited slip differential) sr5 4x4. In apr i brought my truck into the universal toyota dealer here in san antonio tx to replace a missing clamp and for a rumbling noise coming from underneath the truck. The first mechanic said he couldn't hear the noise, and again i brought the truck back in jun as the noise was getting worse. The lead mechanic then heard it and said that the noise is coming from the differential and that he has another tundra doing the same thing. I asked that he call the toyota tech line to inquire/report this. He notified me the next day that the toyota tech person said that this is a normal sound and not to worry about it. However i do have some safety concerns as i don't believe this to be a "normal" indication of what a differential should sound like.
The contact owns a 2003 toyota tundra. The contact stated that the rear differential was leaking. The dealer stated that the rear end housing needed to be replaced. The vehicle was not repaired and the manufacturer was notified. The vin was unavailable. The approximate failure mileage was 180,000.
The contact owns a 2003 toyota tundra.the contact stated that while having the vehicle serviced, he was informed that the differential was rusted out and that fluid was leaking. As a result, the differential needed to be replaced.the vehicle was not repaired.the manufacturer was notified of the failure.the failure mileage was 80,000.
2003 tundra rpm hang-up - safety issue hello all:i have a 2003 toyota tundra 3.4, v6, 4x4, 5 speed. While traveling at highway speeds, if i have to brake hard the rpm's are maintained for up to 1.5 seconds before the rpm starts to drop. This occurs with and without cruise control being on.i'd like to also note that my last truck was a t-100 with the 3.4 v6 engine - so i am very familiar with how this engine should, in theory, respond.dealer claims this acomputer issue and toyota has not issued a tsb. Dealer also claims that this feature was added to reduce jerky feeling when shifting gears.the issue presents a serious safety issue. When traveling at highway speeds, in an emergency, you can't afford to loose 1.5 seconds of braking time.additionally, there is the added wear on your front disk brake pads due to the engine trying to maintain rpm while brakes are trying to stop the truck.this issue has been reproduced at the dealer.to check a truck, cruise at 55 or 65 mph, note the rpm - then if you have to brake hard try to note if the rpm drops immediately or, hangs up for a second or two. Another way to check this is, while parked, race engine to 2500-3000 rpm then switch foot from gas to brake pedal quickly-simulating an emergency stop. Note the rpm and engine sound. You will find the engine still maintaining that 2500-3000 rpm for 1-1.5 seconds.also, dealer pointed out that unless there are more complaints, toyota 'will not' do anything about this problem.personally i would like this issue resolved beforeincident(s) forces us to look seriously at this.thanks to allmike laudano. *la
2003 toyota tundra, (4wd) vin5tbbt44143s36074there is a very obvious vibration and humming noise coming from the front transfer case / differential.this causes a slight reduction ins speed and / or resistance to acceleration.the problem is most noticeable between 30 ~ 40 mph in colder weather, but is present at all speeds and weather conditions.the problem has been present since purchasing the vehicle as new, and is becoming progressively worse. Toyota recognizes and acknowledges that there is a defect with some of the 2003 thunders and squish (documented in service report for this vehicle).it was describe to me by two toyota service managers and a toyota technical assistance representative as resulting from the fit / mesh tolerance of some gears in the front gear case being too tight.toyota has fixed the problem (re-design) in current production vehicles (starting some time during the 2003 model year production schedule), but has to date refused to repair the defect for all owners presenting this problem to authorized toyota dealers / service centers.some dealers / service centers have repaired the defects at random.i suspect and fear that this problem will eventually lead to a failure of some kind that may present a safety hazard, i.e. Gears wearing, slipping, or binding) when the vehicle is in motion, and this in turn may cause a loss or reduction of, or interference with, driver control.
While driving there was a noise heard coming from under the hood. Dealer has inspected the vehicleand could not duplicate or correct the problem. Tsthe defect was with the transfer case which caused vibration and reduction in speed.*jg
Seat belts not working properly and frayed webbing also fear of timing belt going out while driving with family and causing me and my family and/ or a oncoming vehicle to wreck and have serious injuries or multiple deaths!
The contact owns a 2003 toyota tundra. The contact stated that the seat belt failed to latch. The contact was concerned for her safety and took the vehicle to molle toyota (601 w 103 rd, kansas city, mo 64114, (812) 942-5200) and was informed that the part needed to be ordered. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 273,000.
Seat belt repeatedly unhooks after you insert buckle in to locking mechanism.seat belt was secured in locking mechanism and verified by pulling on strap after locking in place. Later as you drive around the belt unlocks by itself. I have invested and discovered that the spring lock is weak, defective and will no longer stay on the proper lock position. It seems the internal springs are broken or at best weakened an can dislodge from the locked position at anytime in a few seconds or hours after it was secured.this problem gives you a false sense of security. This is an immediate safety and life threatening issue.the unlocking can happen in the park position, driving on a street or driving on a highway.the problem can be detected by the red 'press' button should be all the way extended when the latch is not in place. If the latch does not extend fully and it's not flush with the edge of the buckle then it is defective. Lock button can bemaneuvered into the lock position by wiggling it, but it will not hold in place.
Takata recall-date for "when did this happen?" is approx. Date vehicle was manufactured (according to sticker on driver's door)
Manufacturer recall order osv254 or summary 70a
Seat belt unlock by itself. Had this happen multiple times during hard braking.
I am a retired toyota master diagnostic technician. I had to replace my rear brake lines on my 2003 tundra-with 79,962 miles. The rear brake lines have rusted through which had to be replaced- at my expense. My brakes failed as i was towing a trailer in heavy, citytraffic. I was going 35mph when a vehicle pulled out in front of me and then proceeded to stop suddenly to make a left turn into a parking lot. I slammed on the brakes and the pedal went to the floor. I was lucky there was room to maneuver to the rightso i was able to avoid hitting the vehicle in front of me. I'm sure there have been those less fortunate. Then, as i was replacing the lines, i saw a fluid leak under rear of vehicle. Upon inspection i found the rear differential housing has rusted so badly that the gear oil is leaking through the housing. Unfortunately the only remedy is the replacement of the complete rear axle/differential assembly. Also the power steering lines have also rusted through which also had to be replaced- at my expense. The frame has already been replaced-under recall.it is obvious that the material that was used is of very low quality causing very dangerous situations.ie; loss of vehicle control due to differential lock-up, loss of vehicle braking due to rapid fluid loss, loss of vehicle steering control due to rapid fluid loss. I am amazed that toyota motor co. Will not stand behind the product they sold-without being forced to. One quick look under a 2003 tundra is all it takes to see that low/poor quality hardware and materials were used. Without repair and/or replacement of above stated components someone will get injured-possibly fatally. Please investigate these complaints as soon as possible. These components should last for the lifetime of the truck. A differential is not an item one expects to ever replace-"sorry but your warranty's expired". Thank you. Sincerely,information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
I bought a brand new 2003 toyota tundra and never had any problems with the vehicle until my first cross country retirement trip in september 2013.my planned trip was from tennessee to california.when i reached kingman, arizona (about 1200 miles into the trip), i was traveling uphill on interstate 40 when suddenly the truck accelerated itself to a high rpm and speed.i applied the brakes but they did not respond or slow the truck down.i tried to maintain steering control, but in a split-second, i was thrown off the highway and into the hillside, trees, and bushes.the truck completely rolled over, flipped uphill, and come to a stop facing traffic. The landed driver side down, and was completely totaled.the truck only had 79,000 miles on it.a month later i learned that there was a previous recall done for this type of problem, but did not include the 2003 model.i now wonder how many others were injured due to this problem.i took many pictures of the damages.
Took 2003 toyota tundra in for frame rust corrosion program 09v-444000.was told frame and other components had extensive rust and multiple 10mm holes by lead service technician at local toyota dealership.service manager explained that my 2003 toyota tundra frame was extensively rusted and unsafe to be on the road and they wanted to take my truck immediately and provide a rental car due to safety concerns.asked for a plan of action of the scope of work to be performed (corrosion compound verses frame replacement) before giving possession of vehicle.photos of 2003 toyota tundra frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system were taken and sent to lead service tech three states away in texas.was informed extensive frame rust exists on all components (frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system)but it is not covered because vehicle is no longer registered in wisconsin.purchased this 2003 toyota certified vehicle in wisconsin in april of 2010 and no information was given to me at regarding the nhtsa investigation or any rust inspections that were performed.toyota corporation refuses to repair, replace or add corrosion resistant compound to any severely affected rusted components. Significant rust issues exist on this vehicle and still toyota corporation refuses to provide any documentation of their inspections.toyota corporation will not put in writing that the frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system is safe or road worthy.deadline for all rust repairs is december 31, 2012.toyota corporation is stalling consumers to keep from doing any repairs and leaving unsafe rusted 2003 toyota tundra's on the highways.please initiate a new nhtsa investigation regarding this matter for the safety of consumers.
Brake system - we purchased our 2003 tundra new in 2003.it didn't take long to experience a pad and rotor problem, but my wife has mostly freeway driven the truck about 90 miles per day.she seldom speeds and has a perfect track record to show for it.when i would drive the tundra, i almost always noticed a braking hop (in the pedal).unfortunately, she has a tendency to defer maintenance. For the most part, we have put the tundra in the shop for new rotors or new pads(oem) alternately approx. Every 1500 miles.john elway toyota says they can check to see if there's anything they can do . . . Nothing yet. Toyota knows they have a problem with the downgraded braking system on these vehicles. I don't know , but suspect, a completely new, upgraded brake system, including, but not limited to rotors, pads, drums, bearings and calipers be installed.should i just pay the $2 gs?
Purchased a 2003 toyota tundra july 2016. Frame was undercoated by toyota and did not seem to be any issues at the time of purchase. After a few months of ownership, i have been conducting some of my own maintenance under the vehicle.while under, i noticed large areas had the crc treatment chipping and pealing off. I called my local toyota dealer(prioritytoyota chesapeake, va) the service manager said the corrosion protection has expired and there was nothing further they could do.while attempting to grease my propeller shaft, i was on my creaper trying to pull myself under the vehicle. I grabbed part of the frame, in front of the leaf spring perch. While grabbing this section of frame and pulling myself under the truck, the frame crumbled in to my hand. There were a lot of rust flakes, large and small, i collected as much of the rust and flakes as i could and stored them in a zip lock bag. The size of the deterioration was about 7" long and perforated about 9/16" near the bottom of the c channel. I am very concerned about the integrityof the frameon this vehicleparticularlyin regards to braking system, frame cross members and suspension components. I called toyota customer service soon after to report what happened. I told them my vin and other information. They said they would call back in 1 business day. I received a call from toyota today 10/27/16 and a representative told me that toyota is no longer supporting my vehicle for any campaigns. I asked the representative for further literature regarding the frame corrosion programs for tundras, however, toyota will not let me have this information. At this point toyota will do nothing to help or provide assistance in repairing their poorly designed vehicle. Please do not buy toyotas because in the future there will be failures and toyota will not stand behind their products.plain and simple.
I was in motion and driving on a residential street, while operating vehicle atthe time of accident. After the collision, the airbag did not deploy. The takata airbag was replaced by the auto manufacturer (toyota dealership) prior to my above mentioned accident.the auto accident occurred for unknown reasons, possibly brake failure or unexpected acceleration of the carengine.
Truck was being driven 250mi from destination a to b. While enroute, leaving the highway for a rest stop, the brake pedal went to the floor. Brake failure, unable to properly stop. Had truck towed to a local dealer who identified failure in (2) front steel brake lines.total $ 428; and of course the situation could have been a lot worse.vehicle has been maintained, all recommended service intervals, etc. Service tech stated looked to be due to rust - corrosion.i have never had this occur on a vehicle this little mi. And years.i am going to write toyota as well.
Extreme rust area all around rear differential, pitting in metal, and also the spare wheel tire extreme rust.
The whole chassis frame for my truck is significantly and dangerously rusted and it is breaking apart which is a safety issue for me, my family, and other drivers. This also has lead to my breaks lines failing due to rust which almost caused an accident due to me not been able to stop on a red light. There is significant rust damage to the chassis frame and in some parts of the chassis frame that were welded from factory have broken off. In other sections of the chassis frame pieces have started to fall off and there are holes through the chassis frame where there should not be holes. Parts that should be solid steel have holes through it. The rust is so bad on the chassis frame that it has rusted out the fuel lines as well just like it did the brake lines. Sections where the engine mounts go in the chassis are also heavily damage due to rust. The rust is so bad i have step through parts of the bed of the truck when standing on it. There are also holes on the bed of the truck where you can see through the ground due to the rust damage.
I was recently approaching a red-light about a mile from work when i unexpectedly & suddenly was unable to stop the truck. I nearly collided with traffic in my lane & had to veer into the opposing lanes to avoid a collision. Turns out my brake-lines failed due to excessive rust which i've recently come to learn is a problem on these particular trucks. I've never had this happen before even with vehicles with well over 200k miles on them letalone well-less than 80,000; even from the same manufacturer. My dealer had to retrieve the truck from my job(130-mile round trip) & he even stated he hasn't seen brake lines fail like this one did& speculated it was due to them sitting near the frame where road-salt & "[xxx]" collects which causes them to pre-maturely rot out, potentially(obviously) causing them to burst. It was repaired under its warranty but the near-miss i encountered with it never, in my opinion, should've happened particularly without warning or with the present mileage of the vehicle. The brake warning indicator on the dash did work but only after all fluid shot out of it & braking was suddenly not enough to stop in time. I've contacted the manufacturer(toyota) about this & was run around to no avail. I feel this could be a disaster waiting to happen as there's no doubt still many of these vehicles still on the roads. I have no pictures to upload but my dealer can verify the repairs done after this happened.information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
This is the second time within the last several weeks where i've had brake-line failure(also reported my first one here). My vehicle was just recently repaired under warranty at the dealership i bought it from for a catastrophic brake-line failure which nearly resulted in a major accident. After the repair to the exploded lines my dealer stated he inspected the remaining lines under the truck & said they all looked good & there shouldn't be anymore problems with the lines failing. That didn't happen however as i just had another line spring a sudden leak without any warning while driving to work. My vehicle is now off its warranty(only been 1500 miles since repair-79,000 miles on it now) so i cannot send it back to them. It wasn't a sudden, complete loss of brakes this time but a gradual softening of the brake pedal when trying to stop until all of the fluid was gone then i had next to nothing upon arrival to work. Anyhow, i did make it to work & then put more fluid in it to get it home when i got off shift. Upon searching for the leak i was surprised to notice that the lines had broken where there was no rusting involved, it turns out there's a mounting bracket which once had a grommet in it that either fell out or rotted away causing the bracket to cut through the lines under it from metal-to-metal contact. The lines involved looked as though they'd been cut with a knife at the location. The dealer never would've noticed this as it took me almost 30 minutes to find it myself. I did contact toyota however they choose to do nothing about this however since i've had two sudden brake failures within 4,500 miles i feel i should let someone know before someone else gets the same problem and kills themselves or others when their brakes decide to fail without warning! thank-you!
Frame corrosion was not properly addressed during 2012 recall. As a result the frame has corroded in multiple areas and the brakes just failed due to brake line corrosion. Toyota is refusing any additional claims for damages. However they should have done more to address the frame corrosion during the 2012 recall.
Toyota applied a corrosion resistant compound to the rear cross-member assemblies and to the adjacent areas of the frame.this coating has completely peeled off, rendering the exposed corroded metal back to it's original recalled state.this recall occurred in january of 2012, the problem was supposedly fixed by toyota.all of the coating is gone, and, no longer protecting the exposed and corroded metal.
Anti-lock braking system failed: brakes locked under wet conditions. Vehicle slid off road.vehicle has history of pulsating brake pedal, shuttering and clanging noises under braking.
Have a toyota tundra with front brakes that are warped. Vehicle has extreme vibration when braking. Apparently toyota has a tsb issued for this but the vehicle is now out of warranty. This seems to be a common problem from what i have read.
Front brake caliper corrosion leading to reduced braking capability.
Extreme warping on front disc brake rotors. Driving down the road and steering wheel shakes almost uncontrollably. This leads to longer stopping distances. I contacted the dealership and they said it is not a recall and it is because the rotors are to small for the size vehicle. I know several other owners with the same problem and had them replaced,but about 2000 miles on new equipment and they warp again. This is very dangerous as i own a toyota tundra and a toyota sequoia and both have the same parts and same problem.
Front rotors keep warpping. Turned the original set at 40000, then replaced them with slotted rotors, which have now warpped. Understand there is a techinncal service bulletin stating the rear brakes do not self adjust, subsequently increasing the brake load on the front, causing the warpping. The real fix might be to fix the rear brakes. Apply the brakes and the front wheels shudder or shimmy offically called "pulsation" increased when braking on a downhill or with some load in the bed. Toyota should fix this!!!
2003 toyota tundra with excessive frame rust including all rustable components with any connection to the frame.2011 maine state inspection failed due to rusted emergency brake.the emergency brake had been repaired two years prior for same reason (june 2009).
I bought my tundra new in 2003..i bought it to carry the mail as i was informed that it would last longer and hold up better than other makes..i had to replace the front brake pads the first time at about 15,000 miles but was not to concerned as i use them more heavily than most drivers..the next time was about 12,000 miles and this time it was shuttering very bad and i replaced the rotors along with new pads..this has been an on going problem of replacement of parts to elevate the severe shuttering each time thinking i had it fixed..today for the first time i find out that this is not only problem that toyota knew about but possibly have tried to cover because the real fix is very costly ($2000)..they issued a tbs (br004-02) along with 6 or 7 other tsb's about the problems with brakes from year model 2000-2005..i contacted toyota and they told me that if i would have brought the vehicle to a dealer before my 36,0000 warranty expired it could have been fixed..had i known about the service bulletin i would have taken it to the dealer..since the brake parts are not covered under the 36,000 mile warranty i did not take it to the dealer as the first pad replacement seemed to fix the problem..i was informed that maybe if enough people filed a complaint here that toyota would be forced to fix a problem that they new about but did not inform owners about to have repaired..
The contact owns a 2003 toyota tundra.the contact noticed that the main frame of the vehicle was perforated due to severe rust corrosion.the vehicle was taken to an authorized dealer for inspection and they replaced the rusted fuel tank filler neck.the vehicle was taken back to the dealer on a separate occasion.the technician detected a rusted brake backing plate, and the front and rear brakes were replaced.in addition, four new tires were mounted on the vehicle.the technician was unable to perform a tire alignment due to the significant frame damage.the vin was unable to be entered into the system.the failure mileage was unknown and the current mileage was 62,000.
I read with interest the ap story about problems with brakes on the toyota prius. The first generation tundra (2000-2006) has had front brake problems for years (undersized) and toyota refuses to acknowledge it or issue a recall. The brakes on my 2003 tundra are horrible. They vibrate and shimmy. I had to replace pads and turn the rotors twice already and the vehicle only has approximately 80,000 miles. My mechanic tells me the entire front brakes need to be replaced as the rotors cannot be turned again. Toyota has issued a technical service bulletin on these brakes tsb br004-02 but that's it, and the suggested fix is very expensive.check out some of the online forums for more information about this annoying, expensive problem.http://www.tundrasolutions.com/forums/brakes/65633-upgrade-your-early-tundra-brakes-1-a/http://www.tundratalk.net/http://www.yotatech.com/f28/tire-size-stock-2003-tundra-rims-92790/ just in case you are interested... Thanks for listening.
2003 tundra rpm hang-up - safety issue hello all:i have a 2003 toyota tundra 3.4, v6, 4x4, 5 speed. While traveling at highway speeds, if i have to brake hard the rpm's are maintained for up to 1.5 seconds before the rpm starts to drop. This occurs with and without cruise control being on.i'd like to also note that my last truck was a t-100 with the 3.4 v6 engine - so i am very familiar with how this engine should, in theory, respond.dealer claims this acomputer issue and toyota has not issued a tsb. Dealer also claims that this feature was added to reduce jerky feeling when shifting gears.the issue presents a serious safety issue. When traveling at highway speeds, in an emergency, you can't afford to loose 1.5 seconds of braking time.additionally, there is the added wear on your front disk brake pads due to the engine trying to maintain rpm while brakes are trying to stop the truck.this issue has been reproduced at the dealer.to check a truck, cruise at 55 or 65 mph, note the rpm - then if you have to brake hard try to note if the rpm drops immediately or, hangs up for a second or two. Another way to check this is, while parked, race engine to 2500-3000 rpm then switch foot from gas to brake pedal quickly-simulating an emergency stop. Note the rpm and engine sound. You will find the engine still maintaining that 2500-3000 rpm for 1-1.5 seconds.also, dealer pointed out that unless there are more complaints, toyota 'will not' do anything about this problem.personally i would like this issue resolved beforeincident(s) forces us to look seriously at this.thanks to allmike laudano. *la
Excessive vibration while slowing to a stop. Steering wheel shakes and very minor brake pedal pulsation. Front brake pad replacement minimizes issue for short period of time before recurrence.
While driving at any speed the vehicle vibrated.vehicle was taken to the dealer for inspection, andmechanicdeterminedthat the brakes and discbrakes needed to be replaced. However,problemrecurred.
Dt:the consumer complained about a brake problem.at first the front brakes caused the vehicle to shutter when they were applied.then the brakes faded out, causing the vehicle to not stop in time.the consumer felt that the weight of the vehicle was too much for the brakes.the consumer found that the problem was due to the brakes wearing out too quickly.the front brakes have been replaced once under warranty.also,the rotors and pads were replaced.the problem first started injune 2004 and at 15,000-20,000 miles.the problemalmost caused several accidents.the manufacturer issued fivetechnical service bulletins (tsb) for the front brakes.they had a brake upgrade available for the vehicle.they refused to fix the vehicle under warranty.(11/15/05)*sc
While driving at any speed the vehicle vibrated.vehicle was taken to the dealer for inspection, andmechanicdeterminedthat the brakes and discbrakes needed to be replaced. However,problemrecurred.
Brakes grab when vehicle has come to a complete stop. When the brake pedal is released there seems to be movement from either the steering assembly or axle.
I have a 2003 tundra and the brakes vibrate when applied. This is a safety issue especially in snow slush and rain. I refuse to pay $2,000 for a manufacturing defect. I also see it affects many other owners. Hopefully i don't get hurt!
The front rotors and pads have had to be replaced four times because ofvibration.consumer was involved in a rear end collision because of the brakes.
The front rotors and pads have had to be replaced four times because ofvibration.consumer was involved in a rear end collision because of the brakes.
3 days after purchase of vehicle the rotors were warped. Brought vehicle back to dealer they pointed out the fact that there was already a recall on the brakes. The dealer installed the recall parts which consisted of new calipers, resurfacing the existing rotors, and various other axle related parts. The recall service did not include new pads. 3 or 4 days after the recall service the brakes were again warped!!! they stopped fine for just driving around town, but when you have to panic stop at freeway speed, they fade badly and then warp rotors. This complaint isn't about warped rotors as much as it is the brake fade at high speeds. Very dangerous doesn't stop well at all. Please consider a larger pad and better proportioning between the front and the back brakes.
When applying the brakes they pulsate.
The rotors on my 2003 tundra are warping every 1,000 miles or so.this is a known safety problem and toyota should be responsible for remedying the issue.
I have had my rotors resurfaced twice once at 20000 and just now at 40000. Just about went off a cliff last time because of the vibration. Warped rotors every 20000 miles seems quite much.
When applying the brakes, brakes pulsate, andvehicle is going side to side. Itis hard to control the vehicle. Dealer has inspected vehicle,and could no duplicate or correct the problem.tundra v6.there is also a problem with the slidding doors not shutting properly.
Toyota tundra truck front rotors i had a problem as i bought the new truck . Brakes would pulsate when stopping. I was told from toyota there was a problem at the factory with warped rotors. Took it to the dealer, and all they did was machine the rotors down. The invoice said"out of round rotors. Im' concerned this could reoccur and cause a real safety problem. I also found a "plug" in my tire. Brand new truck and there was a plug in it. Was told by the dealer they couldn't do anything about it.
A recall letter was sent for 2003 tundra for undercoating. Vehicle was taken to dealership and was there for three days. I was told nothing else was needed. I brought attention to dealership about frame recall. I was told my vehicle was not under that recall although the year and model was on the site. Second issue of concern, entire steering line replaced. There was a lack of power steering. Vehicle housed for three days at dealership.fast forward today, 25 september was brought to my attention by service manager of large amount of frame rust and vehicle was not road worthy. Layers of rusted metal crumbled in manager's hand. As a consumer preventive maintenance repairs have been made. I have asked the dealership for help to resolve ongoing concerns. I am a female retired veteran pleading for help. I love my vehicle performance is the reason the mileage is 260,000 (+). Your attention to this concern would greatly be appreciated.
The contact owns a 2003 toyota tundra. After the vehicle was started, the driver side air bag warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that an unknown part related to the steering wheel needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 261,000.
The contact owns a 2003 toyota tundra. While driving any speed, an abnormal winding noise emitted from the steering wheel. The contact mentioned that the steering wheel seized when driving at low speeds. The vehicle was not taken to the dealer. The manufacturer was not made aware of the failure. The failure mileage was 35,000.
I have a 2003 toyota tundra which developed an exhaust leak. The aft oxygen sensor became detached from the exhaust system. Upon further inspection i noticed theattaching hardware was missing, it corroded. Iinspected other hardware and noticed the steering shaft attach point has severe corrosion.the hardware that attaches the shaft to the steering gear rack and pinion is halfway corroded and will eventually fail. If the hardware fails loss of steering will occur. I live in new york and the truck has100,000 miles on it. The truck is in great shape but frame and associated parts have corrosion.[xxx]information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
For the third time since i have owned the vehicle where the shift control goes into the steering column, where it connects has broken. This is a piece of metal that has again snapped making it unable to shift the car. What happens if i was in drive and could not shift into park? i have had this fixed twice before, once when i was stuck on the road and once towed to toyota.
Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).i had the frame inspection recall performed in 2012 and was told the frame is ok so they coated the frame with under coating. A few months later i was driving to work and hit a joint on the highway and ended up in the next lane. As i am in the business i put the vehicle in the air that evening and found the steering rack mount was detached from the frame due to rust. I then spoke to toyota customer service and explained the situation and i was told to bring the vehicle back in and they would look at it. I was told again the frame is ok.. I did explain to the dealer that i had to wld a steel plate to the frame so the vehicle would be safe to drive. They still said the frame is ok and they would re spray the frame as a gesture for the inconvenience. I have made numerous calls and emails to toyota since then because june of 2016 i found rust holes in the frame in 2 different spots.. There is a recall to replace the frame if there are perforations in the frame during the inspection. However i have been told several times they will not assist me any further on this situation.thank you [xxx][xxx] *dl
The frame on my 2003 toyota tundra is rusting badly.toyota was unable to align my front end due to rust, and it has caused the emergency brake system to completely freeze up and the brake will not work. It is a complete failure of the emergency brake system, i have no brake.toyota tried to free up the brakes but were not able to.they gave me a can of lubricant and told me to keep lubing the frozen section.they were completely unable to align my front end.
Gear shifter broke while trying to place in park. The vehicle was in drive and as i attempted to move the shifter up to the park position it broke when it got to neutral. I was stranded away from home and had to call someone to come help me get it home. When looking up on youtube there are over 27,000 views on one post about this. This is faulty parts and should be recalled and fixed.
We own a 2003 toyota tundra with 47,000 miles on it and are the original owners.on friday while putting the truck into reverse in a parking lot, the shift mechanism snapped off in my hand.our certified toyota mechanic came and managed to get it into drive and drive it to his shop,and in opening the steering column, found the entire thing was broken within the steering column.our mechanic, who is a certified toyota mechanic says that this should have never happened.as with another complaint lodged on this problem, it is not as if the mechanism has experienced rough handling in any way.
I am a retired toyota master diagnostic technician. I had to replace my rear brake lines on my 2003 tundra-with 79,962 miles. The rear brake lines have rusted through which had to be replaced- at my expense. My brakes failed as i was towing a trailer in heavy, citytraffic. I was going 35mph when a vehicle pulled out in front of me and then proceeded to stop suddenly to make a left turn into a parking lot. I slammed on the brakes and the pedal went to the floor. I was lucky there was room to maneuver to the rightso i was able to avoid hitting the vehicle in front of me. I'm sure there have been those less fortunate. Then, as i was replacing the lines, i saw a fluid leak under rear of vehicle. Upon inspection i found the rear differential housing has rusted so badly that the gear oil is leaking through the housing. Unfortunately the only remedy is the replacement of the complete rear axle/differential assembly. Also the power steering lines have also rusted through which also had to be replaced- at my expense. The frame has already been replaced-under recall.it is obvious that the material that was used is of very low quality causing very dangerous situations.ie; loss of vehicle control due to differential lock-up, loss of vehicle braking due to rapid fluid loss, loss of vehicle steering control due to rapid fluid loss. I am amazed that toyota motor co. Will not stand behind the product they sold-without being forced to. One quick look under a 2003 tundra is all it takes to see that low/poor quality hardware and materials were used. Without repair and/or replacement of above stated components someone will get injured-possibly fatally. Please investigate these complaints as soon as possible. These components should last for the lifetime of the truck. A differential is not an item one expects to ever replace-"sorry but your warranty's expired". Thank you. Sincerely,information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
This is the 2nd time we have had this problem with the truck shutting down.the company should be made to guarantee there work and/itshould have been a massive recall on the ignition and steering system.
Entire frame has severe rust despite anti-rust/corrosion inhibitor applied in 2010-2012. Small holes are now present in frame and the vehicle only has 108k miles. Recently, the power steering rack and pinion had to be replaced, as it rusted out. The technician noticed rust on other suspension components, indicating that rust had made the system weak and brittle. Copious amounts of corrosion inhibitor has now made it almost impossible to obtain a correct alignment. The rusted frame will soon, if not already, diminish the vehicle's safety. Toyota instituted a frame recall circa 2010 for just this issue. Somehow this vin was omitted. The corrosion inhibitor has proved ineffective.i am requesting that nhtsa demand toyota institute another recall for the excluded vins. These omitted tundras, in their current poor frame condition, present a hazard to drivers and other motorists and must be repaired.
The whole chassis frame for my truck is significantly and dangerously rusted and it is breaking apart which is a safety issue for me, my family, and other drivers. This also has lead to my breaks lines failing due to rust which almost caused an accident due to me not been able to stop on a red light. There is significant rust damage to the chassis frame and in some parts of the chassis frame that were welded from factory have broken off. In other sections of the chassis frame pieces have started to fall off and there are holes through the chassis frame where there should not be holes. Parts that should be solid steel have holes through it. The rust is so bad on the chassis frame that it has rusted out the fuel lines as well just like it did the brake lines. Sections where the engine mounts go in the chassis are also heavily damage due to rust. The rust is so bad i have step through parts of the bed of the truck when standing on it. There are also holes on the bed of the truck where you can see through the ground due to the rust damage.
Steering column shift bracket broke in 3 places when trying to shift from park to drive, making shifting impossible. See pictures from 2 of 3 fracture locations, 3rd fracture is at an attachment screw (not shown). This is cause by an punderdesigned part made of inferior cast aluminum. There are thousands of reports of this problem on tundras and other toyota models with same defective bracket. This dangerous defect must be recalled and fixed by toyota with a redesigned part.
Dt:the contact's vehicle was involved in an accident while traveling at 50 mph due to the lower ball joint causing a reduced steering effort. He lost control ofvehicle. He contacted the dealership,they instructed him to contact theinsurance company.the vehicle was totaled as a result of the accident.
I am a retired toyota master diagnostic technician. I had to replace my rear brake lines on my 2003 tundra-with 79,962 miles. The rear brake lines have rusted through which had to be replaced- at my expense. My brakes failed as i was towing a trailer in heavy, citytraffic. I was going 35mph when a vehicle pulled out in front of me and then proceeded to stop suddenly to make a left turn into a parking lot. I slammed on the brakes and the pedal went to the floor. I was lucky there was room to maneuver to the rightso i was able to avoid hitting the vehicle in front of me. I'm sure there have been those less fortunate. Then, as i was replacing the lines, i saw a fluid leak under rear of vehicle. Upon inspection i found the rear differential housing has rusted so badly that the gear oil is leaking through the housing. Unfortunately the only remedy is the replacement of the complete rear axle/differential assembly. Also the power steering lines have also rusted through which also had to be replaced- at my expense. The frame has already been replaced-under recall.it is obvious that the material that was used is of very low quality causing very dangerous situations.ie; loss of vehicle control due to differential lock-up, loss of vehicle braking due to rapid fluid loss, loss of vehicle steering control due to rapid fluid loss. I am amazed that toyota motor co. Will not stand behind the product they sold-without being forced to. One quick look under a 2003 tundra is all it takes to see that low/poor quality hardware and materials were used. Without repair and/or replacement of above stated components someone will get injured-possibly fatally. Please investigate these complaints as soon as possible. These components should last for the lifetime of the truck. A differential is not an item one expects to ever replace-"sorry but your warranty's expired". Thank you. Sincerely,information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
- while driving at 55 mphthe2003/toyota/tundra ran into the retainer wall because the tie rod on the passenger's side snapped, lifting the truck.on january 11 2006 the dealer fixed the recalled tire rod end and ball joint.the contact believed that they should have also replaced the entire rod itself, they did not.he had the truck for seventeen days when the tierod snapped. This almost killed his entire family. His was told to callthe hot line by the dealer.the current and failure mileage were both 41000.
While driving at 45 mph the tie rod broke, then the vehiclesuddenly pulled to the left on flipped unto its side.
The bushings used to attach the rack and pinion steering to the frame is too soft, causing the steering linkage to move. The steering linkage is not properly secured to the frame and i have to oversteer and it causes the vehicle to have the feeling of floating.
The contact owns a 2003 toyota tundra. The contact stated that when the vehicle was taken to be serviced under an unknown recall, the technician informed that the vehicles frame was moderately corroded. The contact stated that the technician serviced the vehicle with an adhesive on top of the corroded frame. The contact stated that six years prior to the failure, the vehicle was taken to the dealer to be serviced under nhtsa campaign 09v444000 (structure) but thetechnician stated that the vehicle showed no signs of corrosion and the vehicle was not serviced under the recall. The contact was informed by an independent mechanic that the frame was severely corroded. The manufacturer was notified of the failure. The failure mileage was approximately 48,913.
The contact owns a 2003 toyota tundra. The contact stated that while the vehicle was at an independent mechanic for a routine check, the mechanic became aware that the subframe was severely corroded. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 118,000.
On may 14 2010 i took my 2003 toyota tundra in for a recall regarding "excessive corrosion of the rear cross member".reference: nhtsa campaign number 09v444000, november 18, 2009& toyota safety recall no. Ssc9090m. My truck was inspected and subsequently was sprayed with corrosion protection compound. However, the spare tire mounting bracket was not sprayed nor was the differential with the required corrosion protection compound. Reference nhtsa campaign number 09v444000 which states "dealers will inspect the rear cross member and related components, including the brake lines and replace them if necessary" or "will be sprayed with a corrosion protection compound". On january 8, 2014 at 103,793 miles, i was forced to replace the entire differential at a cost of $4,657.67 due to the differential rusting completely through to the point it would no longer retain oil. More recently, o/a september 15, 2014 at approximately 105,500 miles i was driving at 30 mph when the mounting bracket that retains the spare tire in place rusted through and the spare tire fell off of my truck and ended up on the side of the road approximately 1/4 mile away. Fortunately, there was no one driving behind me and no other damage or injuries occurred. In both of the above issues at the time of each incident contacted toyota customer service and was told that they could not assist me in either matter. I would like to submit this complaint in the hopes that it may help others in similar situations and i also would like to know if there is means or process i can follow to possible obtain restitution from toyota. I have all necessary documentation to support my claims as outlined above. Thanking you in advance for your consideration in this matter.
2003 toyota tundra. Consumer writes in regards to rust holes near front sway bar and left rear at shock mount. *ldthe consumer stated the vehicle was inspected for rust holes multiple time none were found, but the vehicle was previously treated for frame rusting.
2003 tundra has excessive rust on frame. Deal offers no remedy.
The contact owns a 2003 toyota tundra. The contact received notification of nhtsa campaign id numbers: 14v350000 (air bags), 09v444000 (structure) and 05v225000 (suspension). The contact was waiting for several months for the recall part to become available and the dealer was not able to determine when the recall repair would be performed. The manufacturer notified of the issue. The contact did not experience a failure.
Frame rust through.toyota claims rust hole is not in the correct location on the truck.says there is nothing they can do.
As i was traveling at a slow speed when i became aware of a loud grinding noise which had suddenly began as i turned onto a side street.i stopped vehicle immediately and got out to investigate what was causing the noise. I discovered that my fuel tank was dragging beneath the truck. The metalstraps that held tank to frame had rusted thru causing tank to fall to road surface. All the connections to fuel tank were ripped from tank. Toyota is worried about the spare tire falling down do to rusted frame members but i feel they should be more worried about their fuel tanks falling off. If i had been traveling at highway speeds i hate to think of what consequences might have been.
The contact owns a 2003 toyota tundra. While driving 2 mph and making a left turn, an abnormal noise was heard the vehicle was towed to a dealer where it was diagnosed that the upper control arm was corroded and needed to be replaced. The vehicle was not repaired. The contact also mentioned that the vehicle was previously repaired per nhtsa campaign number: 09v444000 (structure). The manufacturer was notified of the failure. The failure mileage was approximately 74,000.updated 04/19/17 *lj
My 2003 toyota tundra is rusting away on the frame. The frame of my truck looks like it could bend, crack or brake at any time. This truck has been washed top and bottom at least once a month since it was new and all of a sudden i notice the entire under carriage is brittle and looks unsafe. I have loved everything about this truck but am now worried that it may become unsafe to drive.
2003 tundra subject to frame rust deterioration recall which ended this year 2019. This vehicle underwent this recall inspection at toyota dealership. I was told "paint with rust inhibitor will solve problem". Recent inspections x2 by frame mechanics (now a few years later) resulted in immediate recommendation to not drive due to danger of imminent frame collapse. This vehicle has only 118,000 miles and is otherwise in very good condition. I am sure many others are in same condition - not having frame replaced by manufacturer, or misled by manufacturer's service center. Many accidents likely will occur in future. Owners of these vehicles need to be warned of this danger.
The contact owns a 2003 toyota tundra. The contact stated there was a recall associated with nhtsa campaign id number 09v444000 (structure: frame and members: underbody shields). The contact stated that the parts continued to remain on a massive back order for over a year. The dealer was uncertain when the parts would become available. The contact had concern of the safety deffect mentioned in the recall. The manufacturer was not notified of the problem. The contact had not experienced failure at this time.
The contact owns a2003 toyota tundra. The contact stated that there were holes corroded throughout the frame. There was a manufacturer's recall that had expired for the frame failure. The manufacturer was made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 56,000.
2003 toyota tundra showing severe signs of frame rust and corrosion damage rendering vehicle unsafe to operate on a public roadway.this vehicle in every other way gas been manufactured to perform for many more years excepting the foundation of the vehicle, the framework.many, many of these vehicles are in use on american streets by individuals and families who are in dire risk and posing a life threatening risk to all other drivers on the road.
Frame has several rust perforation holes.toyota refuses to repair.vehicle bought used in march of 2013.
The cross member on my 2003 toyota tundra (part no. 51206) is exhibiting extensive and premature rust and corrosion at both connection points with the main frame rails such that the main frame rails have rusted through, leaving multiple holes approximately the size of a quarter.the cross member supports the fuel tank, among other components, and thus the corrosion poses a significant safety hazard.as a result, the vehicle, which is otherwise in satisfactory and operational condition, failed its annual state inspection.toyota previously applied a rust inhibitor to the frame under its limited service campaign which was intended to remedy the defect, but such application failed to prevent the premature corrosion and toyota has since refused to remedy the defect.
From 2001-2003 is a frame recall on these tundra's due to massive rust issue. I went into my local toyota dealership here in norfolk, va, and they gave me the run around saying i "missed the window" for this issue. Then i called corportate and they gave me a different reason, saying they "applied" anti-rust spray" in 2016. Which is not a thing. Clearly it did not work because there are massive holes in my frame. I would like them to own up and do my recall when so many other people i know have the exact same truck and got theirs done. I am active duty as well, and it frustrates me that they would treat a veteran like this. I brought up my spare tire latch being very rusted underneath, which there is also a re-call for. They said they could not do anything for me. 3 weeks later my spare tire flew off from my truck, thank goodness no one was injured.
I took my 2003 tundra to a transmission repair shop, independent, to have the rear differential evaluated due to crunching sound which occurred when taking off from a stop and leaking of fluid due to corrosion onhousing. The shop called me that day two hours later and informed me that my frame was completely rusted out near the front of the vehicle on both sides making it unsafe to drive and not worth proceeding in any repairs of the rear differential at this point. They contacted the nearest dealership which told them that the frame perforation recall, nhtsa # 09v444 had expired 7/31/2015 six days prior. I was instructed to call toyota, which i did. The lady informed me that the recall was still ongoing. I took the tundra to that same dealership for them to inspect the frame. The next day they call me and inform me that i need to contact toyota again myself. This is a toyota garage telling me this. Tonight i get on toyota's website and find two recalls in regards to the frame perforation. According to the toy website both status' of recalls offer remedies available and this site is updated 8/7/2015. I can see that my nearest dealer isn't going to be very helpful. My truck has 112,000. I'm the 2nd owner and have been diligent with maintenance. I do no off roading and use if to transport my motorcycle to races hundreds of miles from home.
A few years ago my truck was recalled for rust of the frame. I took it to the dealer and they decided it was fine and spray coated the bottom of the truck as a remedy for the recall work, where other trucks were given new frames. In my state inspection this month i was advised that there was substantial rust problems (holes) on the frame in the front upper part of the frame, just 10,000 miles since the recall remedy was done. The dealer tells me they can do nothing, it is a toyota problem, toyota tells me it is a dealer issue since they already "repaired" the vehicle under the recall. The work they performed under the recall was not sufficient to make their trucks safe, and i believe another recall must be done and the frames need to be replaced as this is an unsafe situation both to myself and others on the road.
Truck has 98k miles.brought in 2003 new.took good care of it.had a recall on frame corrosion and have it recoated in 2011.took the truck in to mechanic for non frame related issue.the truck frame broke dead center (between the truck and the bed area) while on the lift (thankfully no one got hurt).i called toyota and they are telling me they took care of my truck with the re-coat.it is at owners expense to fix it.they are not admitting their recall was not effective in fixing the underlying issue.this is well know flaw in their design.even the local dealership told me he had couple broke the same way while on their lift.i am totally disappointed with toyota.i brought the truck for toyota's reliability, but i was wrong.having a truck frame broke less than 100k miles is like having someone died at age 25.totally unacceptable.
The contact owns a 2003 toyota tundra. The contact stated that the entire frame exhibited rust and corrosion, which caused extensive damage to the rear differential casing. The vehicle was taken to an authorized dealer for diagnosis. There was a recall associated with nhtsa campaign id number 09v444000 (structure: frame and members: underbody shields). The part was ordered and the contact was advised that it would be available within six to eight weeks. The contact expressed that the recall remedy should include the replacement of the rear differential casing. The manufacturer was not notified of the problem. The approximate failure mileage was 46,000.
A few years ago i bought a used toyota tundra with 70k miles on it thinking i was getting a reliable vehicle with lots of life left on it.what i got was the most unreliable expensive piece of crap i have ever owned.it even nearly ruined our honeymoon.we took the truck on a road trip to see the southwest and kick off our marriage.it was very exciting thanks to toyota.at the grand canyon we had the pleasure of hunting down the last overpriced bottle of power steering fluid.rather than relaxing at the south rim i had to figure out how to limp the truck to the nearest shop.that was over $1200 out of our budget.the next obstacle was even more exciting.we discovered the back tires where ready to fall off and the front wheels had developed some issue also.so we limped the truck to elk city oklahoma in the midst of tornado warnings.we even got to spend the night in a run down motel 6.i think they rented rooms by the hour.that was another $1400 over our budget for a two day stay in scenic elk city.at least we got a free loaner from the folks at smith family nissan.it's more than toyota has done for us.i had to drive up to keene to just get pushed right out the door politely. They could have at least saved me the trip by simply returning my email.we got the same treatment from toyota corp.and for a souvenir we are left with a very expensive piece of scrap metal in the driveway. It appears as though toyota cheeped out on the steel for the frame.cheap chinese steel.the solution was to spray some cheap crap on the frame and cover up the problem.it won't be long before it breaks in half just sitting in the driveway.thanks toyota for all the help and the great customer service. You sure know how to take care of customers.thanks to toyota's patch job the frame issues did not appear in a car fax report.
Takata recall, i was involved in a collision with my toyota tundra when a nissan altima failed to stop for a stop sign. At witch point my air bags did not go off. The truck is totaled and so was the nissan! i was driving east on quincy ave. And the nissan was driving south on b st. When she failed to stop at the stop sign.
The contact owns a 2003 toyota tundra. While undergoing routine maintenance, the technician stated that the frame was severely rusted and the vehicle was unsafe to drive. The vehicle was taken to pearson toyota (12978 jefferson ave, newport news, va 23608, (757) 874-6000) where it was diagnosed that the frame was in poor condition and the vehicle was unsafe to drive. The frame needed to be replaced. The vehicle was not repaired. The contact mentioned that the vehicle was repaired in 2012 per a manufacturer recall for frame rust in which an anti-corrosive agent was sprayed onto the frame. The manufacturer was notified and did not assist. The failure mileage was 137,430. The consumer requested an update.
My complaint is with toyota motor company and their admission but yet no resolution to a known problem. My story of this toyota truck begins with my son owning this tundra for about 5-7 years then selling me, his father the same tundra.before buying said truck i was assured it was of god structural integrity, due to an inspection at a toyota dealership.upon inspection they did find that the frame had visible rust and proceeded to treat it with anti-corrosion.forward to three weeks ago a local inspection was to be done in which i was told that it would not pass due to frame problems as it was not safe to drive.toyota engineers know that the frames are going to rust because no exterior application of any anti-corrosion is going to prevent any corrosion within a tubular boxed frame.i was refused any solution from toyota, who have previously admitted that these particular trucks all have the same issue.how can you help with getting toyota to resolve this completely instead of passing the little guy aside?
The frame is rusted through to the point the truck cannot even be jacked up. It has been maintained and garage kept,it is not due to a lack of care for the vehicle.
The entire frame is rusted - to my shock and i just failed inspection but the truck is gorgeous and runs great with all new tires. I'm currently low income and wonder how the frame recall was missed but the airbag was replaced. Please advise and thank you.
Crake in frame
Excessive rusting of frame on 2003 tundra, car was taken multiple times to dealership, issue was not fixed at all....i have contacted toyota but have gotten the run around. Please advise.
I was driving down the road and lost my spare tire the cross member rotted off the truck i had toyota under coat the truck in 2012 i hope no one got hurt or killed from the tire falling off
The contact owns a 2003 toyota tundra. While driving unknown speeds. The vehicle began to sway. Additionally, the frame was rusted and chunks of the frame was detached. The vehicle was taken to an independent mechanic. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified and opened case number: 1710030430. No further assistance was offered. The vin was unknown. The failure mileage was 135,000. Consumer stated called toyota directly to inform them of issue of frame being cracked in several places. This was detected ny my mechanic who is certified and has his own repair facility. He indicated frame will not last another year. Toyota denied consumer any claim due to a re-call which the consumer was never notified. Vin is invalid updated 7/25/18
Frame is severely rotten
The contact owns a 2003 toyota tundra. The contact stated that the vehicle was taken to an independent mechanic and a dealer where the vehicle was deemed unsafe to drive. The technician stated that the frame was rusted and needed to be replaced. The vehicle was not repaired under nhtsa campaign number: 09v444000 (structure). The manufacturer was made aware of the failure. The failure mileage was approximately 170,000.
The contact owns a 2003 toyota tundra. After inspecting the vehicle, the contact discovered that the frame was rusted. The contact mentioned that the failure occurred after the vehicle was serviced under nhtsa campaign number: 09v444000 (structure). The vehicle was taken to the dealer where it was diagnosed that the frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 149,000.
The contact owns a 2003 toyota tundra. While the vehicle was stationary, the contact recognized multiple holes in the subframe. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 102,000.
Spare tire retainer failed due to rust and tire fell off while the vehicle was in motion
In may 2016, i purchased a 2003 toyota tundra from a used car dealer.in october, as i was changing the oil, i noticed a rust hole in the front section of the frame and as i further inspected, there were rust holes and cracks in the front section of the frame.i checked the passenger side and found the same problem. I went to my local toyota dealer and they informed me that the recall had expired in 2012.i then contacted toyota headquarters and they reviewed my case and sent it to a case manager.the case manager contacted me 2 days later and said there was nothing they could do because it was a warranty issue and it had expired.this is troubling to comprehend because a co-worker of mine who owns a 2001 toyota truck had his frame replaced, no questions asked, in 2015.i find this extremely troubling because this is a safety issue that could lead to potentially injuring myself and my family if the frame were to further crack or split.toyota states that they "want our customers to have a great ownership experience, so we are pleased to resolve litigation in a way that benefits them and demonstrates that we stand behind the quality and reliability of our vehicles."i find this hard to believe considering they are not willing to resolve my safety issues and concerns.
Bad frame rust bad suspension rust bad differential rust bad spare tire rust.if rust condition gets worse the possibility of suspension failure is very real.some of these models need to be recalled or bought back before thereis injury or death.
Purchased my 2003 toyota tundra in may 2016, shortly after i purchased it i noticed that the frame was rotting in the front on both sides, i contacted the dealer i bought it from crazy jims in milwaukeewhich was absolutely no help. He applied a undercoat but didn't do a very good job as it has alreadyworn off. I then contacted toyota thinking they would do something they opened a claim number which resulted in absolutely nothing being done. I am appalled that toyota will not stand behind their product, i know that the truck is not new but toyota is known for the quality and durability of their vehicles. I have spoken to several mechanics and many of my friends and family and they cannot believe that the toyota manufacturer would allow a unsafe vehicle to be driven on the roads and highways. I drivemyself and my children in this vehicle and i feel this should be covered by the dealer it is unsafe to drive but unfortunately i have no other vehicle to drive in and no funds to purchase a new one as i am still paying the loan on this one. Please help me.
My 2003 tundra frame is rusted and cracking.i believe this should be covered by the limited service campaign (lsc) a0f.
Unsafe to drive so much corrosion on frame
The contact owns a 2003 toyota tundra. While driving 2 mph, the spare tire fell from under the vehicle. The contact noticed that the spare tire retaining plate was rusted and corroded, but no other rust was noticed on the undercarriage of the vehicle. The vehicle was not taken to an independent mechanic or dealer for diagnostic testing and repairs. The local dealer (lee toyota, 115 main st, topsham, me 04086, (207) 729-3358) was contacted about the repair cost. The manufacturer was made aware of the failure and confirmed that there were no open recalls. The failure mileage was approximately 138,000. The vin was not available.
In mid december, 2019,i was driving on the interstate and the spare tire dropped from under my 2003 toyota tundra. Fortunately, no vehicles were behind me at the time.i was so surprised to see that tire bouncing down the road behind me!that spare tire had never been taken from the carrier.i made an appointment with a toyota dealer for inspection/recall in early february.they said the corrosion on the cross-member needed to be replaced but the spare tire carrier corrosion issue causing the tire to drop was only for recalls on the tacoma models,i was responsible for the issue. I feel this is a toyota manufacturing safety issue that needs to be addressed.do i have any recourse?
Shock absorbers broken from frame.part of frame broken.
My vehicle has sustantial frame rust which affects the safe operation and the resale/trade-in value. Toyota refuses to offer any remedy because the frame replacement program ended in 2012. My vehicles frame passed a frame inspection in 2011 by a local dealer. I took them at their word. I dont feel that the frame on a 12 year old vehicle should havae such a short service life. This is a hardship for hundereds of tundra owners who have otherwise good vehicles that are now potentially un-safe and utterly worthless. The dealer did offer to patch the frame in one area but it is corroded in several areas. Any assistance would be greatly appreciated as toyotas actions did not go far enough.
Upon inspection there is total rust of the frame and bolts on the suspension. Unusual tire wear. I have read about some recalls but this is an exceptional low miles vehicle (less then 50,000) and it is found to be in unsound condition and current value should be at least $18,000.
After mechanic recently inspected under side, it was found that the frame had significant rust and rot. Frame is not expect to maintain structure for very long.
My tundra 2003 sr5 accesscab 4x4 trd. It has rusted so bad the last 5 yrs.it will no longer pass hawaii safety inspection. I have had the truck since about 2007.it has been a great running truck. Engine and transmission are in good shape. New brakes. But the rust has ruined the frame, tailgate and back of bed! have not driven for a year!
Recall id u7bs-ztw. Took in for airbag recall. Inspection of frame. Frame needs to be replaced and dealership would not let me have my truck back.they gave me a inferior loaner..took truck in first week of s january.as of 3-5-21 they have no repair schedule either!.truck is at toyota of muncie in. Alec baily is my service manager. [email protected] order number nc736011 and ncoo1101. I have been in contact with toyota customer experience since february. Severe run around. Incident #s 210125000031, 210217000381,210304000232. National ref#s 210250103,2103042076. If it cannot be repaired i would like to know
Driving and made a left turn when the right front wheel went flying and the truck started swirving in circles. And caused a major damage in which the dealer doesnt want to respond.
The contact owns a 2003 toyota tundra. While the contact was servicing his vehicle, he looked underneath and noticed that the sway bar was rusted along with the entire frame. The contact stated that the vehicle exhibited the same symptoms as listed in nhtsa campaign number: 09v444000 (structure). The vehicle was not taken to a dealer to be diagnosed or repaired.the manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
My frame is rotten. It's totally unsafe
The contact owns a 2003 toyota tundra. The contact stated that the rear of the frame was rusted and corroded. The vehicle was taken to an independent mechanic. The technician stated that the entire frame needed to be replaced. The vehicle was not replaced. The manufacturer was notified of the failure. The approximate failure mileage was 92,000.
I recently had an exhaust leak on my truck and would occasionally hear some clunking noises under the vehicle.i went under the truck to investigate the extent of the exhaust leak and noticed that one of the sway bar links was no longer connected and that one end was rusted off.i ordered replacement parts and tried to jack the vehicle up under the frame and i heard crunching and saw the jack pressing into the frame from the bottom and crumbles of rust came showering down.i relocated the jack to a different portion of the frame and continued to jack it up and more creaking of the frame and rusty parts broke free and fell to my driveway. The frame behind the driver's side front wheel is badly rusted and has lost its structural integrity.there are several 5"+ horizontal and vertical "cuts" into the frame both on the side and bottom surrounding the nearby front cross-member.this excessive rust corrosion compromises the vehicle's safety, stability, and crash-worthiness.we can no longer use this truck for its intended purpose of hauling a heavy payload or towing a trailer which were engineered by toyota.this has also greatly affected the value of the vehicle.we took the vehicle to the toyota dealer in westminster, md and they performed the anti-rust spray treatment to the frame in 2010 under the limited service campaign which obviously didn't work.the exterior painted surfaces of the body are all in excellent condition as i applied a coating of wax at least annually.the truck has just now reached 90,000 miles and i don't feel that i got the value out of the truck for what i paid brand new for it back in 2003 when i trusted the toyota name.i recently contacted the toyota dealer in westminster, md again and i was told thatthe recall for the frame expired in 2012 and that there was nothing else they could do.
The contact owns a 2003 toyota tundra. While the vehicle was undergoing recall repairs for nhtsa campaign number: 15v286000 (air bags) at galaxy toyota (750 nj 30, eatontown, nj 07724), the technician diagnosed that the front of the frame was completely rusted. The technician stated that the failure was not included in a recall. The manufacturer was made aware of the failure and stated that there was no recall. The contact was instructed to sign a waver, noting that the vehicle was unsafe to drive. The vehicle was not repaired. The failure mileage was approximately 295,000.
On 12/05/11 newark toyota completed recall ssc90m phase 2-crc application to my rusted frame. Almost immediately i notice a bonding failure and delamination of the crc application. By november of 2013 i asked the same service lane manager, bill c. And the technician that performed the work to inspect the failed application. I asked the technician why it failed and he stated "i did not prepare the surface correctly before i placed the application". I appreciated his honesty but was told then that there was nothing else they could do about it.my frame is now very rusted so i asked bill c. To reinspect my frame on 12/5/19 while my tundra was in for a takata airbag recall. William told me that he had a manager inspect my frame and that no perforations were found (please see all attached photos). They did not mention the catastrophic failure of the frame c channel lower flanges. This exponentially expansive corrosion has reached the leaf spring bracket flange rivets (see photo 8810); catastrophic failure of the rear axle assembly will result. I am a mechanical engineer with extensive training and experience in corrosion related failure. This frame and vehicle are unsafe!on 12/21/19 i emailed this information, including the photographs and copies of all service records, to the toyota customer care center.they emailed me back on 12/28/19 and asked me to call them.the toyota representative, jeffery m., called my dealership and told me that the frame was not perforated so i am not eligible for the frame replacement recall.i asked jeffery multiple times if the dealer said the frame is safe or not.he refused to answer that question and would only state that my frame is not perforated. The nhtsa/toyota 10mm perforation criteria is inadequate and the phase 2 application bonding failure exacerbated moisture and road salt retention.
Vehicle was towed to toyota dealer due to gear shift selector would no longer work.issue was found to be transmission cable rusted thru and broke.during a successful repair of above issue; a frame inspection was performed.i was notified by the local toyota service manager rust had compromised the frame putting a few holes in the right front frame rail. The service people took pictures and submitted a package to the regional contacts with "a recommendation to replace my vehicle's frame." again, the local toyota dealership repair technicians and mgmt. Are recommending the frame be replaced under a extended warranty issue.at this point in the process toyota has denied remediation and or corrective work on their part !!this is a tundra truck which has had all factory recalls performed;and in other aspects is in excellent mechanical and running shape with just under 70k mi.i have called toyota corporate customer service on 8/7, case # 1508070842 and am waiting for feedback.i am creating this safety complaint as i don't believe toyota will do anything, yet i want to be positive on the matter.i expect toyota to either replace the frame, remediate and repair, or offer to purchase it back towardsthe purchase of a new one.
Received the recall notice, brought vehicle to local dealer which stated there was no corrosion, dealer did not spray under carriage. Family member also owns this truck and stated that his was sprayed and then subsequently eroded and replaced. I will be calling the dealer tomorrow for reevaluation as the fuel filler may be eroded or cracked.
Traveling on hwy 11. 4 cars ahead suddenly stop. I had 3 choices: hit the car in front of me. Go into on coming traffic, or head off the side of the road into the bayou. Missed the opportunity of the bayou, hit a parked semi tractor trailer. Nothing happened to the tractor trailor. My toyota got severely crunched on the right passenger side. My air bags never went off. I was going 30 miles per hour, and nothing deployed. Now i understand it is a good thing the airbags didn't go off.
In june of2012 i took my tundra to have the frame campaign performed, in january of 2013 i contacted toyota stating the frame / corrosion recall was not performed properly and i felt the frame needed to be replaced as there was a lot of rust. They contacted the dealer i took it back and they reinspected the frame and i was told it was no rust found.a few months after this i would be driving and i would hit a bump and end up in the next lane. I took it to work and put the vehicle on a lift and found the steering rack mount cracked at the frame. I welded it back together.about a month ago the same thing the frame where the rack mounts cracked in another spot so this time i need to take l angle steel and weld in place.on 3/4/ 2016 i decided i was going to go back and undercoat my frame correctly. At this time i have found holes in my frame exactly where the points of the frame that the recall falls under. Toyota has stated they are not going to offer any assistance
The contact owns a 2003 toyota tundra. The contact stated that the passenger side of the dashboard's air bag cover melted and was sticky to the touch. The contact stated that, in the past, there was an unidentifiable odor coming from that area. The vehicle was taken to darcars toyota frederick (5293 buckeystown pike, frederick, md 21704 (301) 696-6300). But the cause of the failure could not be diagnosed. The dealer took pictures and sent them to a local toyota representative for darcars. The contact mentioned he was afraid to drive the vehicle due to sun glare and was unsure if the passenger side air bag was safe. The manufacturer was notified of the issue and did not assist. The failure mileage was approximately 65,000.
The contact owns a 2003 toyota tundra.the contact stated that while the vehicle being serviced, the contact was informed that the frame was fractured. The vehicle was taken to the dealer, who diagnosed that the frame needed to be replaced.the manufacturer was notified of the failure.the approximate failure mileage was 173,566.
The frame is rustingapart will not pass state inspection.
A recall letter was sent for 2003 tundra for undercoating. Vehicle was taken to dealership and was there for three days. I was told nothing else was needed. I brought attention to dealership about frame recall. I was told my vehicle was not under that recall although the year and model was on the site. Second issue of concern, entire steering line replaced. There was a lack of power steering. Vehicle housed for three days at dealership.fast forward today, 25 september was brought to my attention by service manager of large amount of frame rust and vehicle was not road worthy. Layers of rusted metal crumbled in manager's hand. As a consumer preventive maintenance repairs have been made. I have asked the dealership for help to resolve ongoing concerns. I am a female retired veteran pleading for help. I love my vehicle performance is the reason the mileage is 260,000 (+). Your attention to this concern would greatly be appreciated.
Entire frame has severe rust despite anti-rust/corrosion inhibitor applied in 2010-2012. Small holes are now present in frame and the vehicle only has 108k miles. Recently, the power steering rack and pinion had to be replaced, as it rusted out. The technician noticed rust on other suspension components, indicating that rust had made the system weak and brittle. Copious amounts of corrosion inhibitor has now made it almost impossible to obtain a correct alignment. The rusted frame will soon, if not already, diminish the vehicle's safety. Toyota instituted a frame recall circa 2010 for just this issue. Somehow this vin was omitted. The corrosion inhibitor has proved ineffective.i am requesting that nhtsa demand toyota institute another recall for the excluded vins. These omitted tundras, in their current poor frame condition, present a hazard to drivers and other motorists and must be repaired.
I had a safety recall for corrosion and had it repaired at the dealership in july, 2015. Recently i returned to the dealership for an exhaust leak. When they put it on the rack they noted several areas on the frame which had rusted all the way through. The mechanic informed me the truck was unsafe to drive and the frame needed to be replaced. I contacted toyota and was told my vin was not part of any recall and therefor toyota would not replace the frame. I believe the same inferior steel was used on my frame as was on the recalled toyotas. I live in virginia which while we don't experience the large amounts of snow here, we are still considered a northern state per toyota. The truck has never been in an accident and was used as a daily driver and now will be a total loss.
I recently purchased my vehicle from a auto dealer and a few months after the purchase i noticed the frame was rotted. I took it back to the dealer and they would not replace the parts. I went to toyota who states that they will not do anything either my truck is not safe to drive on any road for myself or other drivers.
The contact owns a 2003 toyota tundra. The vehicle was included and repaired under nhtsa campaign id number: 09v444000 (structure: frame and members:underbody shields). After the repairs while the contact was driving approximately 45 mph, he noticed that the front driver's side of the vehicle was unbalanced. The vehicle was taken to an independent mechanic for diagnostic testing. The technician advised that the rings around the strut had become corroded, causing the spring to detach from the vehicle. The vehicle was repaired. The contact later discovered that the fuel filter bracket, rear differential seals and the front rack were also corroded. The vehicle was not further repaired. The approximate failure mileage was 60,000.
Frame rusted to the point of being non-repairable and unsafe to drive.
The contact owns a 2003 toyota tundra. The contact stated while having the vehicle repaired under an unknown recall, he was informed that the sub frame needed to be replaced. The manufacturer was informed of the failure but offered no assistance. The failure mileage was approximately 118,485.
Frame recallinferior steel used on the frame has led to premature failure and rot. Toyota applied a sealant to the frame to address the rust issue.the sealant was also an inferior product and did not adhere to the frame. Because toyota considered the recall closed there was no warning to indicate a hazard could exist. A recall will not show up on car fax if the manufacturer deems the recall is complete.toyota's position that road salt is the cause of the premature frame rot ignores these facts.
The contact owns a 2003 toyota tundra. While the vehicle was stationary, the contact noticed that the frame was rusted from the inside out and contained holes. The contact stated that the frame was undercoated for rust and corrosion on july 12, 2012. Heritage toyota in burlington, vermont discovered the severe frame rust and stated that the contact would have to pay for a new frame. The manufacturer was made aware of the issue and stated that the frame was undercoated, which is what they were required to do. The manufacturer also stated that the vehicle was out of mileage warranty coverage. The failure mileage was approximately 150,000. ...updated 10/23/17
Rear cross member that holds on spare tire is completely rusted.toyota refuses to replace because the recall has expired.
The contact owns a 2003 toyota tundra. While driving 65 mph, the contact heard an abnormal dragging noise coming from the vehicle. Upon exiting the vehicle, the contact noticed that the fuel tank was rusted and detached. Also, the check engine indicator illuminated. The contact called don moore toyota(4216 frederica st, owensboro, ky 42301, (270) 926-2500) and was informed to have the vehicle towed. The vehicle was not diagnosed or repaired. The manufacturer was contacted and did not assist. The failure mileage was 129,000.
The contact owns a 2003 toyota tundra. The contact noticed damage to the frame. The vehicle was taken to an authorized dealer and repaired under a recall associated with nhtsa campaign id number 09v444000 (structure: frame and members:underbody shields). In conjunction to the remedy repair the brake calipers were a required replacement which was not mentioned in the recall; however, they were replaced at the owner's expense. The manufacturer was notified and offered to reimbursement for the parts and partial labor cost. The failure mileage was 154,000.updated 06/18/13*ljthe consumer stated after being refunded for the repairs of the calipers, on 1/31/13, rust was found on the new frame. Updated 06/24/2013
The contact owns a 2003 toyota tundra. While driving, the trailer hitch became detached. The contact coasted the vehicle to the side of the road and noticed that the hitch dropped low to the ground and was bent. The contact used the trailer jack to lift up the trailer and straighten the hitch to the receiver in order to drive home. The contact stated that the trailer hitch was bolted to the reinforcement bumper, which was corroded. The contact was concerned the passengers in the vehicle would not be protected in the event of a crash. The contact removed the trailer from his vehicle and placed it in the back of the vehicle. The vehicle was taken to new country toyota of saratoga springs (located at 3002 ny-50 building # 1, saratoga springs, ny 12866, (518) 584-7272) where it was determined that the reinforcement bumper was not included in nhtsa campaign number: 09v444000 (structure). The recall only included the frame and all the crossmembers; therefore, the dealer could not assist. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and provided case number: 1906120378. The approximate failure mileage was 114,000.
The contact owns a 2013 toyota tundra.while having routine maintenance at an independent mechanic on the front wheel bearing, the frame cracked into two places behind the cab without warning.the vehicle was un-drivable. The contact called graham toyota (1515 w 4th st, mansfield, oh 44906 (419) 529-1800) but was not diagnosed or repaired.the manufacturer was contacted who provided case 2001 021145 however, no further assistance was provided. The failure mileage was approximately 126,000.
The contact owns a 2003 toyota tundra. While the vehicle was being repaired according to nhtsa campaign number: 09v444000 (structure), the technician discovered that there was corrosion on the rear cross member. The vehicle was repaired; however, the remedy failed to repair the failure. While driving at approximately 45 mph, the vehicle started to shake and the rear driver side tire detached. The manufacturer was notified of the failure. The failure mileage was unknown.
The contact owns a 2003 toyota tundra. The contact received a "bxd" recall in 2014 for severe frame corrosion inspection. The nhtsa campaign number was not provided. The vehicle was taken to the harr toyota dealer, located at 100 gold star blvd, worcester ma 01606, where the technician inspected the vehicle and sprayed a rust resistant compound on the frame. The contact stated that the spray started to flake off within a short time. The vehicle was taken back to the dealer and the technician stated that the flaking was normal and took pictures of the failure. The contact called noxudol,the spray manufacturer, at (301)-972-0860 and was informed that the flaking was not normal. The vehicle was taken to westboro toyota, located at 271 turnpike rd, westborough, ma, 01581, where the technician performed a thorough inspection of the undercarriage and found holes and rust in the front passenger side and rear driver side of the frame. The manufacturer (toyota) was made aware of the failure and stated that there was no recall. The contact was provided a case number. The vehicle was not repaired. The failure mileage was 70,833.
Fram excessiverust."recall" , yet toyota acknowledged , treated , then denied the recall replacement.kindly advise .
2003 toyota tundra with low mileage and well-maintained but excessive frame rust that will eventually become unstable.
The contact owns a 2003 toyota tundra. The contact stated that the vehicle was leaking differential fluid from the housing wall of the rear end of the vehicle. The contact took the vehicle to an independent mechanic and was informed that the rear end housing needed to be replaced. The contact took the vehicle to continental toyota (6701 south la grange road, hodgkins, il 60525, (708) 716-4497) where it was previously repaired per nhtsa campaign number: 09v444000 (structure). The contact was informed that due to the age of the vehicle, they could not repair the vehicle. The manufacturer was contacted and denied assistance. The vehicle was not repaired. The failure mileage was 250,000.
The frame by the driver side front wheel is almost broken in half...it has a 2 foot long section missing...other steering component affected stablizer bar almost rusted in half..bracket and bushing almost nonexistent...this is my daily driver for me,my wife and my 10 year old daughter...i fear for their safety should it completely let loose...i drive very slow...i am 59 years old...plz help me get a new framefrom toyota...thanx
Frame corrosion was not properly addressed during 2012 recall. As a result the frame has corroded in multiple areas and the brakes just failed due to brake line corrosion. Toyota is refusing any additional claims for damages. However they should have done more to address the frame corrosion during the 2012 recall.
The contact owns a 2003 toyota tundra.the contact noticed a rusted holein the rear frame. The vehicle was taken to the dealer for diagnostic testing. The technician stated that the frame would have to be replaced. The contact referenced nhtsa campaign id number: 09v444000 (structure: frame and members:underbody shields) but was advised by the manufacturer that the location of the hole was not part of the frame and it was not covered under the recall. The contact stated that the frame had been previously treated with a corrosion compound under the recall campaign. The vehicle was not repaired. The approximate failure mileage was 115,000.
Frame is completely rusted through. Car has only 130k miles. Toyota denies culpability, frame is made of inferior material not able to withstand use.
When applying the brakes, brakes pulsate, andvehicle is going side to side. Itis hard to control the vehicle. Dealer has inspected vehicle,and could no duplicate or correct the problem.tundra v6.there is also a problem with the slidding doors not shutting properly.
2003 toyota tundra with excessive frame rust including all rustable components with any connection to the frame.2011 maine state inspection failed due to rusted emergency brake.the emergency brake had been repaired two years prior for same reason (june 2009).
The contact owns 2003 toyota tundra. The contact stated they took the vehicle to the dealer for nhtsa recall campaign id number: 09v444000 (structure: frame and members: underbody shields) repair to be performed. The dealer moved a hammer along the frame and ruled there was no damage to the frame. The contact stated the test was not adequate since the dealer only scraped a hammer along the edge of the frame. The contact spoke with the manufacturer was advised that was the proper procedure. The contact was concerned that the test was not sufficient as well as the vehicle being a safety risk. The failure mileage was unknown, but the current mileage was 160,000.
The contact owns a 2003 toyota tundra li. The driver noticed a couple years ago that the frame was beginning to rust. The driver also stated that he spray painted the frame. He contacted the dealer and they said it was not a recall yet. The failure mileage was 30,000. The current mileage was 95,000. The driver also stated that backing plate that holds the rear brake assembly in place was rusted as well.
The contact owns a 2003 toyota tundra. The contact stated that the frame was fractured. The vehicle was taken to a certified toyota mechanic where it was diagnosed that the frame needed to be replaced. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 134,000.
I have a 2003 toyota tundra that i bought new and have had serviced at the same toyota dealership since the purchase.in june 2008, i had the 60,000 service done and had front brakes replaced.in august 2008, while pulling out of my driveway, the driver's side lower control arm rusted through and the wheel was no longer connected to steering.after having the truck towed, i had to have both lower control arms replaced.toyota usa paid for half.since then, i have tried repeatedly to have toyota and the dealership step up and accept the responsibility for the rust issue.the dealership says it's not their problem and toyota usa states they have no program in place to address this issue.neither of these excuses are acceptable.my truck is spotless except for frame rust.toyota needs to do something before a serious accident happens and someone is hurt or killed.
I have a 2003 tundra access cab 4wd truck.took it to the toyota dealership for the rust recall inspection and to investigate oil leaking from the rear differential housing.dealership said that the frame was fine but the cross members and tank supports need coating.they also advised that the rear differential housing was rusted to the point that oil is leaking and would have to be replaced.they said that toyota is not responsible for the replacement of the rear axle housing.the vehicle has 108k miles.i can not believe that with all the known rust issues that toyota will not stand behind this problem.
The contact owns a 2003 toyota tundra. While having the brakes replaced he was informed that the entire frame was corroded. No repairs were made. The vehicle has not been diagnosed by the dealer. The failure and current mileages were 21000.
I purchased a brand new 2003 toyota tundra pickup truck, , from a local dealer on december 2, 2002.on 9/9/05,i discovered various sections of the frame and brackets that attach to theframe had excessive corrosion.the vehicle at this time had 37,488 miles on the odometer.today the mileage is 47,569 miles and the rust condition is getting worse.i brought this condition to the service advisor at this dealership and he concurred that the vehicle had excessive corrosion.i contacted toyota customer service and spoke with a rep who gave me case number 200509090921.both the local dealership and toyota motor corp. Refused to repair the excessive corrosion.due to this condition, this will continue to develop and subsequently the truck will have frame rot ,causing an unsafe condition to operate.in 2005, two independent autobody shops inspected my truck and gave meestimates to repair the rust.
The contact owns 2003 toyota tundra. The contact stated that the emergency brake rusted and snapped off of the frame. The brake was welded to middle of the cross frame right under the drivers seat. When the contact took the vehicle to the dealer, they were told that it could not be repaired, because they do not make the part to replace it. The manufacturer had an engineer look at the vehicle as well and they also said that there was nothing they could do. The contact stated that the piece that was connected to the cable holding the spare tire also rusted and broke off. The contact had to carry the spare tire in the back of the truck. The contact feels that this is the same is the recall campaign 09v444000 for the structure, which deals with the under body shields rusting.the manufacturer stated that his year, make and model was not included and cant be repaired. The failure mileage was 100,000 and the current mileages were 120,000.
Rusted vehicle frame.driver side leaf spring broke due to rust corrosion.replace leaf spring.applied rust inhibiter to exposed frame.vehicle underbody rust free.
The contact owns a 2003 toyota tundra.the contact noticed that the main frame of the vehicle was perforated due to severe rust corrosion.the vehicle was taken to an authorized dealer for inspection and they replaced the rusted fuel tank filler neck.the vehicle was taken back to the dealer on a separate occasion.the technician detected a rusted brake backing plate, and the front and rear brakes were replaced.in addition, four new tires were mounted on the vehicle.the technician was unable to perform a tire alignment due to the significant frame damage.the vin was unable to be entered into the system.the failure mileage was unknown and the current mileage was 62,000.
Rusting frame and spare tire falling off.
We own a 2003 toyota tundra with 56,000 miles on it. Upon recent state inspection our mechanic said that the frame of this truck is so badly rusted that it probably wouldn't pass inspection next year. We called toyota headquarters and were told that they are recording this information but there is a 36,000 mile, 3 year warranty on toyotas and that they could do nothing more for us.
My 2003 toyota tundra is rusting away on the frame. The frame of my truck looks like it could bend, crack or brake at any time. This truck has been washed top and bottom at least once a month since it was new and all of a sudden i notice the entire under carriage is brittle and looks unsafe. I have loved everything about this truck but am now worried that it may become unsafe to drive.
2003 toyota tundra has serious frame rot.the paint on the frame has bubbled up as the rust has proliferated leaving the entire frame in a compromised state.the rear axle and leaf springs are completely coated in rust.driver's side rear drum brake locked up due to corrosion, which required replacing a tire and brake shoes.vehicle has been dealer serviced since day one, with the exception of oil changes.
My 2003 toyota tundra with only 73000+ miles on it has significant rusting in the truck bed.the truck is not used for commercial purposes and is only used for periodically carrying normal household items.there is also signs of significant rusting underneath the truck.since toyota had a recall with certain tacoma's for a similar condition, i am very concerned of the safety of this truck.
On may 17, 2010 the spare tire fell off my 2003 toyota tundra while it was being driven down the street.fortunately, the vehicle was being driven on a back road and no accident occurred as a result of the tire falling off.part of the spare tire mount was still attached to the wheel after it fell off and you could see that the spare tire mount had extensive rust/rot.i was told that toyota had a recall relating to excessive rust which could lead to the spare tire falling from the mount under the vehicle. On june 3, 2010 i took the tundra to a local toyota dealership service department and they inspected the vehicle.they told me that the vehicle passed their rust inspection so repairs would not be covered under the recall.when i reminded them that my spare tire fell off the vehicle they advised me that they could replace the rotted spare tire mount parts for $350.00.on june 11, 2010 i contacted the national toyota customer service center and was told that based on my vehicle's vin i was not listed in their system as the owner of the vehicle.they advised that if i was not listed in their system i would have not gotten any recall notice. After updating the information i explained what happened with my vehicle and was first told that based on the vin, my vehicle was not part of the recall.the person then said that the vehicle was included in the recall.i was then told that i would receive a telephone call from the local toyota dealer within 3 days to schedule another service appointment.my concerns are that i am now being sent back to the same service center that first inspected it and passed it even though their invoice states "found carrier has rotted away from cross-member bracket that holds the tire" and it is obvious that the spare tire had fallen from the vehicle due to extensive rot.
Driving at highway speed, the spare tire/wheel assembly (mounted beneath the vehicle) fell without warning to the roadway below.the tire/wheel ended up in the middle of the driving lane, causing numerous vehicles following behind me to swerve to avoid it.i pulled over to confirm the wheel was from my vehicle, and this was verified.i then turned around to pick up the wheel and remove it from the highway.i found the bracket still in place in the center of the wheel, however it was severely corroded and had no structural strength left.there was no sign of the chain or cable that held the wheel and bracket to the underside of the truck.this vehicle had recently been to a toyota dealer earlier in the year for an inspection of the frame (corrosion recall), as well as for replacement of gas tank straps (which were replaced due to corrosion issues).it had been determined that no action was needed with regards to frame corrosion.the gas tank straps were replaced.there was no comment from the toyota dealer on any potential issues with the spare tire mounting system.
Entire rear end housing rusted away requiring a whole new rear end housing.frame is rusting out on whole truck.
I have a 2003 toyota tundra which is experiencing a great amount of rust underneath the vehicle. I see that there was a recall issued yesterday regarding that problem. I lived in florida for 6 months and in vermont the other 6 months. We left the latter part of october and return to vt the last part of april or early may. I do drive the truck up to vt around the holidays so it has experienced a vtwinter for 2 to 3 weeks a year. Several years ago the truck started to show signs of rust on the back bumper and the underside. 2 years ago i had to replaced all the bolts on the exhaust system replaced due to rust. Due to a flat tire this past summer i had to use the spare. The tire rim was extremely rusty as well as the holder. I sprayed both with oil in hopes of stopping the rust.the front skid plate bolts were so rusty that. Yesterday, the dealer had to replace 4 bolts saying the 5th hole was so rusty that it could not accept the bolt. The recall is for northern trucks are for states that use road salt during the winter but, given the rust on my truck, i can't believe that 2 to 3 weeks per year in vt caused that much rust. I believe it is a problem with the metal used for the underside of the truck, therefore i believe my fl truck should be included in the recent recall. Even the dealer commented on the amount of rust on the underside. This truck has been used only for pleasure and not commercial use. To summarize i would request that my truck that waspurchased in fl be included in the recall and be subject to the inspection the same as the northern trucks. Although we live a few miles from the gulf in florida my wife's 2004 highlander shows no underside rust so the florida weather can't be the problem and itin vtthe same time as the truck except for the 2 to 3 weeks around the holidays. Thank you.
My fathers 2003 toyota tundra getting checked out recently by a local mechanic when he was made aware that the frame is excessively rusty. With this information the truck was brought to a toyota dealer for inspection. The dealer stated there is so much rust the vehicle the vehicle is unsafe to drive. Dealer also stated there is nothing toyota will do about it until the rust actually creates a hole in the frame. My parents are in there seventies on fixed incomes, they don't have a choice but to operate this unsafe vehicle. If a dealer is able to state a vehicle is unsafe to drive toyota should back the determination of the dealer and do everything possible to remedy the problem. My parents were told to bring the vehicle back after a hole rust through the frame and then toyota will do something about it. A 2003 truck should not have rusted to the point of being unsafe in a 7 year period. Please help my parents.
Anti-lock braking system failed: brakes locked under wet conditions. Vehicle slid off road.vehicle has history of pulsating brake pedal, shuttering and clanging noises under braking.
My 2003 toyota tundras under carriage is completely rusting away and it scares the hell out of me to drive my 4 year old daughter in the truck because i'm afraid something going to fall off.
I own a 2003 toyota tundra that has severe frame rust. Big pieces of metal are flaking off, sooner or later some component attachment point will fail. The rest of the underneath, and truck as a whole, is rust free. I religiously wash the underside of the truck. There is a defect with these frames.
Took 2003 toyota tundra in for frame rust corrosion program 09v-444000.was told frame and other components had extensive rust and multiple 10mm holes by lead service technician at local toyota dealership.service manager explained that my 2003 toyota tundra frame was extensively rusted and unsafe to be on the road and they wanted to take my truck immediately and provide a rental car due to safety concerns.asked for a plan of action of the scope of work to be performed (corrosion compound verses frame replacement) before giving possession of vehicle.photos of 2003 toyota tundra frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system were taken and sent to lead service tech three states away in texas.was informed extensive frame rust exists on all components (frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system)but it is not covered because vehicle is no longer registered in wisconsin.purchased this 2003 toyota certified vehicle in wisconsin in april of 2010 and no information was given to me at regarding the nhtsa investigation or any rust inspections that were performed.toyota corporation refuses to repair, replace or add corrosion resistant compound to any severely affected rusted components. Significant rust issues exist on this vehicle and still toyota corporation refuses to provide any documentation of their inspections.toyota corporation will not put in writing that the frame, rear cross members, spare tire carrier, rear brake lines & fuel tank mounting system is safe or road worthy.deadline for all rust repairs is december 31, 2012.toyota corporation is stalling consumers to keep from doing any repairs and leaving unsafe rusted 2003 toyota tundra's on the highways.please initiate a new nhtsa investigation regarding this matter for the safety of consumers.
The contact owns 2003 toyota tundra. The contact stated that while having the oil changed by an independent mechanic, he was informed that the rear end needed to be replaced due to corrosion. The manufacturer was notified, but the vehicle was not repaired. The failure mileage was 92,375 and the current mileage was 92,575.updated 03/05/12*ljtoyota informed the consumer, the rear frame was not covered under current frame corrosion recall. Updated 03/07/12
Rear differential housing rotted out dumping oil all over road.
Frame and rear end banjo housing rotted to the point where gear oil from rear end leaked out onto the road. Had to have vehicle towed to garage to make temporary repairs.in addition, frame is disintegrated with pieces falling to the ground. Taken to an independent garage and was told to take truck to toyota and both the rear end assembly and frame should be replaced. Garage, stewart's of georgetown, ma., states metal of frame has deteriorated to the point where you could poke holes in it with a screw driver. Frame examined on august 6, 2011 after pieces of frame found under the truck after labor day weekend. Truck has 40,700 miles on the odometer and used to deliver and pick up supplies for property owned.the consumer to date, he has been unable to locate a usable rear end assembly. The consumer believe the failure was directly related to the use of reprocessed metal in the manufacturing, together with the failure to properly treat exposed metal parts with corrosion resistant compounds. The consumer stated after the vehicle was returned to him. The check engine light illuminated. The vehicle was taken to an independent repair shop where it was necessary to replace the oxygen sensor that had been previously replaced in august 2007. Updated ivoq 12/01/11
2003 toyota tundra under bed spare tire mount failure. While driving, the spare tire mount failed causing the spare tire to become dislodged. I was unaware until flagged down by another driver who had swerved erratically to avoid the tire. Updated 03/25/10 received pictures of frame. Updated 09/14/10
The contact owns a 2003 toyota tundra. Upon inspection of the vehicle by an independent mechanic, the contact was made aware of severe frame corrosion. The dealer (cobb county toyota, 2111 barrett lakes blvd, kennesaw, ga) was contacted and confirmed the corrosion; however, they refused to perform the remedy per nhtsa campaign number: 09v444000 (structure) because the vehicle was previously serviced per the recall. The manufacturer was notified of the failure and confirmed that the vehicle had already been repaired per the recall. The failure mileage was 78,000. The vin was not provided.
Purchased a 2003 toyota tundra july 2016. Frame was undercoated by toyota and did not seem to be any issues at the time of purchase. After a few months of ownership, i have been conducting some of my own maintenance under the vehicle.while under, i noticed large areas had the crc treatment chipping and pealing off. I called my local toyota dealer(prioritytoyota chesapeake, va) the service manager said the corrosion protection has expired and there was nothing further they could do.while attempting to grease my propeller shaft, i was on my creaper trying to pull myself under the vehicle. I grabbed part of the frame, in front of the leaf spring perch. While grabbing this section of frame and pulling myself under the truck, the frame crumbled in to my hand. There were a lot of rust flakes, large and small, i collected as much of the rust and flakes as i could and stored them in a zip lock bag. The size of the deterioration was about 7" long and perforated about 9/16" near the bottom of the c channel. I am very concerned about the integrityof the frameon this vehicleparticularlyin regards to braking system, frame cross members and suspension components. I called toyota customer service soon after to report what happened. I told them my vin and other information. They said they would call back in 1 business day. I received a call from toyota today 10/27/16 and a representative told me that toyota is no longer supporting my vehicle for any campaigns. I asked the representative for further literature regarding the frame corrosion programs for tundras, however, toyota will not let me have this information. At this point toyota will do nothing to help or provide assistance in repairing their poorly designed vehicle. Please do not buy toyotas because in the future there will be failures and toyota will not stand behind their products.plain and simple.
Within a year of toyota inspecting frame and spraying .i lost spare tire with out knowing .approximately 3/14 a mechanic saw holes in frame .towed to toyota dealership and they looked at it and reported it to company.i got a call saying there was no frame recall and i would have to complain to toyota my self. I did and filed a complaint.a woman named jay called me and said there was no current recall on 2003 tundras and mine was recalled just for spraying the frame.i shared my opinion of the situation and thought they would reconsider there decision. I have heard nothing and my truck sits in my driveway.
1990 toyota 4 runner, 2003 toyota tundra, 1999 toyota sienna. Consumer states rust and corrosion issues with all three vehicles *tgwthe consumer stated the tailgate holders on the passenger and driver's side broke due to severe rust. The driver's side tailgate fell onto the top bumper and caused dents in the metal.
I received the ssc 90m - tundra vehicles severe corrosion of the rear cross member phase 2 - crc application. My truck has a tonneau cover and a bed rug installed. When i called the dealership to schedule an appointment they informed me that the bed of the truck would have to be removed to complete the repairs. I told them that i did not have the means to remove the tonneau cover and the bed rug. They said that they could not perform the repair without these items removed and that they would not remove them for me. I then contacted toyota customer experience center at 800-331-4331, extension [xxx] and discussed the situation with [xxx]. She claimed that the recall letter states that the truck must be presented in "factory condition" (i guess that means no bed rug or tonneau cover). I reread the letter and that is not stated anywhere in the letter. I called her back and she was unable to assist me nor would she elevate my issue to the management level. This recall work must be done, and again, i have no means to remove these items. I'm sure that i'm not the only tundra owner experiencing this issue. This truck will be unsafe to drive if the recall work is not done. Please help. Thank you.information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
The contact owns a 2003 toyota tundra. The contact stated that the vehicle was taken to prime toyota - saco (783 portland rd, saco, me 04072) for the free takata air bag recall and was informed that the sub-frame was extremely corroded. The contact was informed that the sub-frame received a rust inhibitor treatment in 2010 under a customer satisfaction program. The contact stated that the rust inhibitor treatment failed to prevent the failure. The vehicle was not repaired. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was approximately 172,000.
The contact owns a 2003 toyota tundra. While driving 60 mph, the spare tire detached from the vehicle. The contact inspected the vehicle and found severe corrosion around the cross member. The contact called a local dealer and was informed of nhtsa campaign number: 09v444000 (structure). The manufacturer was notified of the failure and stated that the recall had expired. The failure mileage was 89,200.updated 06/21/17*lj
The contact owns a 2003 toyota tundra. While the vehicle was stationary, the contact noticed that the spare tire was absent from the undercarriage of the vehicle. Also, the spare tire carrier was severely rusted and corroded. As a result, the spare tire detached from the vehicle while driving various speeds. Waldorf toyota (2600 crain highway, waldorf, maryland 20601, (301) 843-3700) was made aware of the failure and stated that the vehicle exceeded the three year/36,000 mile warranty coverage. The manufacturer was made aware of the failure and provided the contact with case number: 1811171313. In addition, the contact stated that the vehicle was coated with a preventative rust protection on december 24, 2011 per an unknown recall that expired. The failure mileage was 453,839.
Toyota had a re-call for excessive corrosion on the 03 tundra. I have been taking the truck in for inspections for 3 years & was told everything was ok. This year toyota said they had an ok to undercoat the frames. While my truck was in for the work it was discovered that the rear differntial had rusted through & was leaking oil. Even though this componenet is on the underside of the truck just like the frame that was covered the repairs were not covered under the recall. It was obvious that the issue was caused by corrosion. Total cost of the repair was $2000 for the rear differntial casing to be replaced.why was this not covered under the recall if the componenet is part of the uderside of the vehicle?
2003 toyota tundra.consumer writes in regards to frame rust recall notice.the consumer stated last year, there was a recall on the frame. She took the truck to the dealer, and they replaced the entire frame. Shortly after, she heard a popping noise coming from the truck. At first, she didn't think much of it, but as time went on, it became worse. The consumer took it back to the dealer, where an inspection revealed the right rear leaf spring was broke. The consumer requested to see the leaf spring, which turned out to be rusted, which caused it to break. The consumer believed the leaf spring should have been included in the check, when the frame was replaced. The consumer also discovered the left rear leaf spring needed to be replaced, as well.
Toyota applied a corrosion resistant compound to the rear cross-member assemblies and to the adjacent areas of the frame.this coating has completely peeled off, rendering the exposed corroded metal back to it's original recalled state.this recall occurred in january of 2012, the problem was supposedly fixed by toyota.all of the coating is gone, and, no longer protecting the exposed and corroded metal.
The contact owns a 2003 toyota tundra. The contact stated that the vehicle was taken for state inspection and the contact was told there was severe rust on the frame. The contact referenced nhtsa campaign id number:09v444000(structure: frame and members: underbody shields) and spoke with the manufacturer but was told that the recall had expired.the failure and the current mileages were 47,000. Updated 08/28/12*lj
My toyota had a frame recall for rusting which they fixed. Now i'm being told my gas tank is rustingand needs to be replaced.toyota will fix it for 1500. 00 dollarsi believe this is a safety problem and is atoyota problem.
My dad bought this tundra new in 2003.the frame started rusting in a couple of years and in 2011 he received a recall letter from toyota stating that he needed to take the truck in and have the frame inspected.he took it to hickory toyota to have the dealer evaluate it.because the frame was heavily rusted my dad assumed the frame would be replaced.however, the service manager at the dealership stated that the frame was structurally fine and intact and did not need replacement.my dad gave me the truck in 2012 and i took it to my mechanic to have brakes replaced.my mechanic commented on the excessive rust and told me i should take it to a dealer to be inspected.i told him my dad had taken it and supposedly everything was ok.skip ahead to june of this year and i had the tundra in again for a regular state inspection.as soon as my mechanic put my truck up on the lift, the frame bent in the middle on both sides and holes were torn in the frame.i contacted both toyota and the dealer that did the inspection in 2011 and was told that the extended warranty period for the recall on these frames had expired and they were going to do nothing.i feel that the toyota dealer that told us we didn't need a new frame in 2011 before the recall expired was trying to save both himself and toyota money by not replacing the frame when it needed it. I believe the dealer and toyota still bear responsibility for replacing the frame.
Frame rust through.toyota claims rust hole is not in the correct location on the truck.says there is nothing they can do.
2003 toyota tundra. Consumer writes in regards to nhtsa safety recall related to rusted frames.
The contact owns a 2003 toyota tundra. The contact stated that the undercarriage of the vehicle was corroded. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 136,000.
Vehicle failed state inspection due to excessive rust ofthe frame.
The contact owns 2003 toyota tundra. The contact stated that one of the fuel straps, which held the fuel tank in place, was rusted and corroded. As a result, the strap fractured and the fuel tank was hanging downward. The vehicle was taken to an authorized dealer and the strap was repaired. The manufacturer was notified, but offered no assistance. The failure mileage was 126,190.
On may 14 2010 i took my 2003 toyota tundra in for a recall regarding "excessive corrosion of the rear cross member".reference: nhtsa campaign number 09v444000, november 18, 2009& toyota safety recall no. Ssc9090m. My truck was inspected and subsequently was sprayed with corrosion protection compound. However, the spare tire mounting bracket was not sprayed nor was the differential with the required corrosion protection compound. Reference nhtsa campaign number 09v444000 which states "dealers will inspect the rear cross member and related components, including the brake lines and replace them if necessary" or "will be sprayed with a corrosion protection compound". On january 8, 2014 at 103,793 miles, i was forced to replace the entire differential at a cost of $4,657.67 due to the differential rusting completely through to the point it would no longer retain oil. More recently, o/a september 15, 2014 at approximately 105,500 miles i was driving at 30 mph when the mounting bracket that retains the spare tire in place rusted through and the spare tire fell off of my truck and ended up on the side of the road approximately 1/4 mile away. Fortunately, there was no one driving behind me and no other damage or injuries occurred. In both of the above issues at the time of each incident contacted toyota customer service and was told that they could not assist me in either matter. I would like to submit this complaint in the hopes that it may help others in similar situations and i also would like to know if there is means or process i can follow to possible obtain restitution from toyota. I have all necessary documentation to support my claims as outlined above. Thanking you in advance for your consideration in this matter.
Frame is severely rotten
There were 2 issues with the frame on the 2003 toyota tundra that were addressed on my son's truck when they were issued. Now, the frame is extremely rusted and possibly a hazard to drive. The truck was taken to a local dealer who did not even look at the frame but, pulled up information from toyota and told us that there was nothing they could do. I do not understand as i see others online to this day getting frames replaced. I called toyota corporate who claims that is not possible as the frame is no longer available. This is really a poor way to treat customers that pay very heavily for these trucks and expect them to last. The vehicle was purchased originally in ny and eventually pa which are the cold weather states that were involved. The coating placed on the truck did nothing as far as we can tell as there is nothing that shows it was ever there. I have additionaldocuments, videos, etc that i was unable to upload.
The contact owns a 2003 toyota tundra. While the vehicle was being repaired according to nhtsa campaign number: 09v444000 (structure), the technician discovered that there was corrosion on the rear cross member. The vehicle was repaired; however, the remedy failed to repair the failure. While driving at approximately 45 mph, the vehicle started to shake and the rear driver side tire detached. The manufacturer was notified of the failure. The failure mileage was unknown.
Fram excessiverust."recall" , yet toyota acknowledged , treated , then denied the recall replacement.kindly advise .
Driving and made a left turn when the right front wheel went flying and the truck started swirving in circles. And caused a major damage in which the dealer doesnt want to respond.
I bought a new 2003 toyota tundra limited 4x4 tuck here on guam. I've been experiencing shaking since about 2005. All the recalls supposily have been taken care of by the dealer ex: lower ball joint replaced, brakes replaced and passenger airbag disconnected by dealer. Shaking became minimal, but now my truck shakes more than ever. I even had one of the dealer's mechanics test drive the truck with me. He said it was because the road is bumpy. I even drove on a newly paved road and the shaking was even more noticable. I told him to look at the side view mirror at the bed shaking. That's when he agreed with me. The dealer had my truck for four months or so trying to figure what was causing the shaking with no prevail. Hince, i have been dealing with the compensating of braking and shaking of my truck. I am really fed up taking my truck in for this problem. All my records of service are at the toyota dealer. I hope you can find a solution to this problem and help me out.
My tundra 2003 sr5 accesscab 4x4 trd. It has rusted so bad the last 5 yrs.it will no longer pass hawaii safety inspection. I have had the truck since about 2007.it has been a great running truck. Engine and transmission are in good shape. New brakes. But the rust has ruined the frame, tailgate and back of bed! have not driven for a year!
The contact owns a 2003 toyota tundra. The contact stated that the front driver's side ball joint was faulty, rusted, and could no longer support the front driver's side of the vehicle. There were no warning indicators illuminated. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 133,000.
The frame by the driver side front wheel is almost broken in half...it has a 2 foot long section missing...other steering component affected stablizer bar almost rusted in half..bracket and bushing almost nonexistent...this is my daily driver for me,my wife and my 10 year old daughter...i fear for their safety should it completely let loose...i drive very slow...i am 59 years old...plz help me get a new framefrom toyota...thanx
2003 toyota tundra front tires had excessive outer tire wear.*mrthe tire were rotated and now all four tires have excessive wear.
The frame is prematurely severely rotten and crumbling. This is a massive safety issue and needs to be brought to every tundra owners attention. I have had it sprayed, but was only done for the back crossmember by toyota. The other half is ready for a catastrophe in due time. There may be others in my situation and no way is a frame supposed to crumble without sitting in constant salt. Please, please, please help the other owners and make them aware if they haven't yet. The frame will buckle while driving and cause harm to others on the road. Mine has pieces as big as 12 by 8 come off. The toyota dealership i have went to told me to keep an eye on it since the recall has lapsed.
Bad frame rust bad suspension rust bad differential rust bad spare tire rust.if rust condition gets worse the possibility of suspension failure is very real.some of these models need to be recalled or bought back before thereis injury or death.
Purchased a 2003 toyota tundra july 2016. Frame was undercoated by toyota and did not seem to be any issues at the time of purchase. After a few months of ownership, i have been conducting some of my own maintenance under the vehicle.while under, i noticed large areas had the crc treatment chipping and pealing off. I called my local toyota dealer(prioritytoyota chesapeake, va) the service manager said the corrosion protection has expired and there was nothing further they could do.while attempting to grease my propeller shaft, i was on my creaper trying to pull myself under the vehicle. I grabbed part of the frame, in front of the leaf spring perch. While grabbing this section of frame and pulling myself under the truck, the frame crumbled in to my hand. There were a lot of rust flakes, large and small, i collected as much of the rust and flakes as i could and stored them in a zip lock bag. The size of the deterioration was about 7" long and perforated about 9/16" near the bottom of the c channel. I am very concerned about the integrityof the frameon this vehicleparticularlyin regards to braking system, frame cross members and suspension components. I called toyota customer service soon after to report what happened. I told them my vin and other information. They said they would call back in 1 business day. I received a call from toyota today 10/27/16 and a representative told me that toyota is no longer supporting my vehicle for any campaigns. I asked the representative for further literature regarding the frame corrosion programs for tundras, however, toyota will not let me have this information. At this point toyota will do nothing to help or provide assistance in repairing their poorly designed vehicle. Please do not buy toyotas because in the future there will be failures and toyota will not stand behind their products.plain and simple.
Entire frame has severe rust despite anti-rust/corrosion inhibitor applied in 2010-2012. Small holes are now present in frame and the vehicle only has 108k miles. Recently, the power steering rack and pinion had to be replaced, as it rusted out. The technician noticed rust on other suspension components, indicating that rust had made the system weak and brittle. Copious amounts of corrosion inhibitor has now made it almost impossible to obtain a correct alignment. The rusted frame will soon, if not already, diminish the vehicle's safety. Toyota instituted a frame recall circa 2010 for just this issue. Somehow this vin was omitted. The corrosion inhibitor has proved ineffective.i am requesting that nhtsa demand toyota institute another recall for the excluded vins. These omitted tundras, in their current poor frame condition, present a hazard to drivers and other motorists and must be repaired.
The whole chassis frame for my truck is significantly and dangerously rusted and it is breaking apart which is a safety issue for me, my family, and other drivers. This also has lead to my breaks lines failing due to rust which almost caused an accident due to me not been able to stop on a red light. There is significant rust damage to the chassis frame and in some parts of the chassis frame that were welded from factory have broken off. In other sections of the chassis frame pieces have started to fall off and there are holes through the chassis frame where there should not be holes. Parts that should be solid steel have holes through it. The rust is so bad on the chassis frame that it has rusted out the fuel lines as well just like it did the brake lines. Sections where the engine mounts go in the chassis are also heavily damage due to rust. The rust is so bad i have step through parts of the bed of the truck when standing on it. There are also holes on the bed of the truck where you can see through the ground due to the rust damage.
Upon inspection there is total rust of the frame and bolts on the suspension. Unusual tire wear. I have read about some recalls but this is an exceptional low miles vehicle (less then 50,000) and it is found to be in unsound condition and current value should be at least $18,000.
The contact owns 2003 toyota tundra. The contact stated that while having the oil changed by an independent mechanic, he was informed that the rear end needed to be replaced due to corrosion. The manufacturer was notified, but the vehicle was not repaired. The failure mileage was 92,375 and the current mileage was 92,575.updated 03/05/12*ljtoyota informed the consumer, the rear frame was not covered under current frame corrosion recall. Updated 03/07/12
My 2003 tundra frame is rusted and cracking.i believe this should be covered by the limited service campaign (lsc) a0f.
Rear cross member that holds on spare tire is completely rusted.toyota refuses to replace because the recall has expired.
Frame corrosion was not properly addressed during 2012 recall. As a result the frame has corroded in multiple areas and the brakes just failed due to brake line corrosion. Toyota is refusing any additional claims for damages. However they should have done more to address the frame corrosion during the 2012 recall.
The contact owns a 2003 toyota tundra. The contact stated that there was differential fluid leaking from the rear axle housing due to rust. The vehicle was taken to the dealer but the dealer advised that there were no failures with the rear axle. Pictures were taken of the vehicle and sent to the manufacturer but the manufacturer advised that there were no failures seen from the pictures. The contact stated that the pictures were taken with an epoxy on the axle to help seal the leak so the manufacturer would not be able to see the actual failure. The contact stated that the rust ate through the epoxy and the rear differential continued to leak. The failure mileage was 65,000 and the current mileage was 72,000... Updated 08-07-12.the consumer the vehicle has been repaired.updated 08/08/2012
In june of2012 i took my tundra to have the frame campaign performed, in january of 2013 i contacted toyota stating the frame / corrosion recall was not performed properly and i felt the frame needed to be replaced as there was a lot of rust. They contacted the dealer i took it back and they reinspected the frame and i was told it was no rust found.a few months after this i would be driving and i would hit a bump and end up in the next lane. I took it to work and put the vehicle on a lift and found the steering rack mount cracked at the frame. I welded it back together.about a month ago the same thing the frame where the rack mounts cracked in another spot so this time i need to take l angle steel and weld in place.on 3/4/ 2016 i decided i was going to go back and undercoat my frame correctly. At this time i have found holes in my frame exactly where the points of the frame that the recall falls under. Toyota has stated they are not going to offer any assistance
2003 toyota tundra front end making a severe grinding, squeaking, and knocking noise. The cv axle boots are destroyed and seems like the wheel bearings and hub is going out quickly as well. Also have transmission leakage and noise when turning. Vehicle only has 86,000 miles on it.
Two items here: first i went to change my tire with my spare and it was missing. The tire service company said the tire must have fallen off somewhere as the cable holding the spare tire was rusted off.2nd, i had my tundra put up on a lift to see what the banging sound was. One of the shock's connections was rusted off and just hanging.he also stated that the whole frame and crankcase on the rear drive area looked like "bark on a tree"and could be very dangerous to drive in this condition
2003 toyota tundra. Consumer writes in regards to rust holes near front sway bar and left rear at shock mount. *ldthe consumer stated the vehicle was inspected for rust holes multiple time none were found, but the vehicle was previously treated for frame rusting.
Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).i had the frame inspection recall performed in 2012 and was told the frame is ok so they coated the frame with under coating. A few months later i was driving to work and hit a joint on the highway and ended up in the next lane. As i am in the business i put the vehicle in the air that evening and found the steering rack mount was detached from the frame due to rust. I then spoke to toyota customer service and explained the situation and i was told to bring the vehicle back in and they would look at it. I was told again the frame is ok.. I did explain to the dealer that i had to wld a steel plate to the frame so the vehicle would be safe to drive. They still said the frame is ok and they would re spray the frame as a gesture for the inconvenience. I have made numerous calls and emails to toyota since then because june of 2016 i found rust holes in the frame in 2 different spots.. There is a recall to replace the frame if there are perforations in the frame during the inspection. However i have been told several times they will not assist me any further on this situation.thank you [xxx][xxx] *dl
The contact owns a 2003 toyota tundra. While driving 2 mph and making a left turn, an abnormal noise was heard the vehicle was towed to a dealer where it was diagnosed that the upper control arm was corroded and needed to be replaced. The vehicle was not repaired. The contact also mentioned that the vehicle was previously repaired per nhtsa campaign number: 09v444000 (structure). The manufacturer was notified of the failure. The failure mileage was approximately 74,000.updated 04/19/17 *lj
From 2001-2003 is a frame recall on these tundra's due to massive rust issue. I went into my local toyota dealership here in norfolk, va, and they gave me the run around saying i "missed the window" for this issue. Then i called corportate and they gave me a different reason, saying they "applied" anti-rust spray" in 2016. Which is not a thing. Clearly it did not work because there are massive holes in my frame. I would like them to own up and do my recall when so many other people i know have the exact same truck and got theirs done. I am active duty as well, and it frustrates me that they would treat a veteran like this. I brought up my spare tire latch being very rusted underneath, which there is also a re-call for. They said they could not do anything for me. 3 weeks later my spare tire flew off from my truck, thank goodness no one was injured.
Takara inflatorsand driving down a very busy street and had a driver flashing his lights at me. I pulled over to find out that my spare tire underneath my truck had fallen off and bounced into a building. I go back to get it and notice that it had rusted and fell off. I've been having ball joint issues and now my rack and pinion has started to leak because of rust. I've learned about a recall on my frame has been issued. I called toyota and they said my truck had been looked at and no problem was found. I've got the spare tire and the rusted bracket. I'm really scared to even drive it,and air bag they want to replace it but to scared to drive it
I took my 2003 tundra to a transmission repair shop, independent, to have the rear differential evaluated due to crunching sound which occurred when taking off from a stop and leaking of fluid due to corrosion onhousing. The shop called me that day two hours later and informed me that my frame was completely rusted out near the front of the vehicle on both sides making it unsafe to drive and not worth proceeding in any repairs of the rear differential at this point. They contacted the nearest dealership which told them that the frame perforation recall, nhtsa # 09v444 had expired 7/31/2015 six days prior. I was instructed to call toyota, which i did. The lady informed me that the recall was still ongoing. I took the tundra to that same dealership for them to inspect the frame. The next day they call me and inform me that i need to contact toyota again myself. This is a toyota garage telling me this. Tonight i get on toyota's website and find two recalls in regards to the frame perforation. According to the toy website both status' of recalls offer remedies available and this site is updated 8/7/2015. I can see that my nearest dealer isn't going to be very helpful. My truck has 112,000. I'm the 2nd owner and have been diligent with maintenance. I do no off roading and use if to transport my motorcycle to races hundreds of miles from home.
Took it to the dealer to inspect the frame and they told me it was unsafe to drive. Recommended me not to drive it. As the frame was rust and had multiple rust perforations in the front half of the frame
Frame recalled, toyota replaced tire carrier, sprayed frame. But the cross member and everything attached to it has rusted completely through. Making truck unsafe to drive. I have a 1991 ford f-150 with more frame integrity.
Vehicle vibrates at highway speeds. Despite repeated tire balancing, replacement and alignment. Vibrates between 50 and 80 mph. Dealer states it is because of standard 17 inch wheels on these vehicles.
The contact owns a 2003 toyota tundra. The contact stated that when the vehicle was taken to be serviced under an unknown recall, the technician informed that the vehicles frame was moderately corroded. The contact stated that the technician serviced the vehicle with an adhesive on top of the corroded frame. The contact stated that six years prior to the failure, the vehicle was taken to the dealer to be serviced under nhtsa campaign 09v444000 (structure) but thetechnician stated that the vehicle showed no signs of corrosion and the vehicle was not serviced under the recall. The contact was informed by an independent mechanic that the frame was severely corroded. The manufacturer was notified of the failure. The failure mileage was approximately 48,913.
The contact owns a 2003 toyota tundra. The contact stated that while driving 70 mph, the front driver's side wheel became detached from the vehicle. The contact applied the brakes and began to skid until the vehicle came to a stop. The vehicle was not taken to the dealer for inspection and wasrepaired. The manufacturer was notified and stated that they would assist with the cost of the failed ball joint but not for any additional damages as a result of the failure.the failure mileage was 174,000. Updated 5/17/13
The contact owns a 2003 toyota tundra.the contact received a recall notice for nhtsa campaign id number 05v225000 (suspension:front:control arm:lower ball joint).he scheduled an appointment with the dealer to have the vehicle repaired when the parts arrived.the recall repair was performed on august 24, 2005.when the vehicle was taken to a different dealer for another failure, it was discovered that the vehicle had an outstanding repair for the ball joints.the contact was informed that the first dealer only inspected the ball joints instead of replace them as stated on toyota's website.the dealer advised him to go to the original dealer that performed the recall inspection.the dealer then scheduled a second appointment for the recall repair, but when he arrived for the repair, he was informed that the repair work had been performed the first time.currently, the records indicate that the repair work had been performed, which is incorrect.the failure mileage was 48,270.
While towing a small trailer the front end of the vehicle started floating and became impossible to control. As a result the truck went out of control and flipped over causing over 10,000.00 in damages to the pickup. It was a bout a month or two after this that we received the recall on the front ball joint. Even though it was supposedly fixed??? it still continues to have problems.i have contacted the insurance company and they had never heard of the recall. I think toyota should stand up and do the right thing and give us a new truck that doesn't have potentially fatal recalls. Or maybe a class action legal response may be in order? i am contacting a lawyer asap i broke both wrist and cannot use my right arm now as a direct result of irresponsibility for this not being done right. If anyone else is interested let me know. Email me at the very least the dealer who sold us this vehicle should be liable for stating there is "nothing at all wrong with that truck" it is in perfect condition. What all that knowledge the pretend to posses about vehicles and they are not intelligent enough to check for recalls prior to reselling them to their "valued customers".
Right front ball joint separated, causing loss of control while driving, resulting in over $10,000 in damage.
Dt: the contact states there is nhtsa recall campaign 05v225000 concerning the lower ball joints. The parts needed to repair the vehicle are not available at the local dealership. Hespoke to their manufacturer, who has confirmed thatthe parts were not available.
The bolts on my tudnra's left ball joint sheared off and the left front wheel collapsed on june 12, 2006. The failure occurred in page, arizona while we were on vacation. The failure occurred after our dealer fixed the joints on april 17, 2006 pursuant to toyota's recall notice for this problem.we consider ourselves fortunate to be alive.i am giving similar notices today to dealer and toyota.our tundra is currently at the body shop in page, az.there was some body damage to the right front side.the work will be done by this friday, june 7.we intend to pick up the car then.i have three of the bolts that came off (two of them that i picked up on the street were sheared) and have asked the repair shop to save all parts that they removed and replace.i also have photos of the tundra at its point of rest in the street.because of traffic control problems, the page police responded to this incident.the officer in charge was c. Miller, badge 523.he also provided me with a another number (i don't know if this is an incident number): 06/06/1420.
Dt:the contact's vehicle was involved in an accident while traveling at 50 mph due to the lower ball joint causing a reduced steering effort. He lost control ofvehicle. He contacted the dealership,they instructed him to contact theinsurance company.the vehicle was totaled as a result of the accident.
Dt*:the contact stated recall work was performed a month ago on the vehicle, while driving 40 mph, the front of the vehicle dropped.the vehicle was moved off the road and towed to the dealer.a nhtsa recall, #05v225000 was performed on the vehicle concerning, the front lower ball joint however, the recall did not remedy the problem.the dealership did offer a second repair without charge under the recall.updated 11/21/2006 -
- the contactowns a 2002 toyota tundra pickup.the contact stated that therewasa safety recall on the lower ball joints. The contact tookthe vehicle to have the safety recall repaired, and two weeks later while driving at 30 mph in beautiful weather,the lower ball joint on the front left sidecame apart, and the contact's vehiclehit a second vehicle.the contact stated that the police did not take a report.the contactwasemployed as a senior engineer technician, and he neededthe vehicle to do his job, and he has not been provided another vehicle whilethevehicle was being investigated.
Dt*:the contact stated the steering wheel was hard to turn.there is an nhtsa recall #05v225000 concerning the front lower ball joint.the contact has been waiting for six months to get a letter from the manufacturer so that the dealer will repair the recalled part.
Front suspension lower ball joint recall on 2003 toyota tundra. Consumer states that his son had a serious accident and was injured.*njthe consumers son heard a loud noise and the right front of his truck dropped while he was driving. He was unable to steer the vehicle and hit aretaining wall.the consumer received a recall notice regarding the lower ball joint problem 9 months after the accident.
While towing a small trailer the front end of the vehicle started floating and became impossible to control. As a result the truck went out of control and flipped over causing over 10,000.00 in damages to the pickup. It was a bout a month or two after this that we received the recall on the front ball joint. Even though it was supposedly fixed??? it still continues to have problems.i have contacted the insurance company and they had never heard of the recall. I think toyota should stand up and do the right thing and give us a new truck that doesn't have potentially fatal recalls. Or maybe a class action legal response may be in order? i am contacting a lawyer asap i broke both wrist and cannot use my right arm now as a direct result of irresponsibility for this not being done right. If anyone else is interested let me know. Email me at the very least the dealer who sold us this vehicle should be liable for stating there is "nothing at all wrong with that truck" it is in perfect condition. What all that knowledge the pretend to posses about vehicles and they are not intelligent enough to check for recalls prior to reselling them to their "valued customers".
2003 toyota tundra.consumer writes in regards to frame rust recall notice.the consumer stated last year, there was a recall on the frame. She took the truck to the dealer, and they replaced the entire frame. Shortly after, she heard a popping noise coming from the truck. At first, she didn't think much of it, but as time went on, it became worse. The consumer took it back to the dealer, where an inspection revealed the right rear leaf spring was broke. The consumer requested to see the leaf spring, which turned out to be rusted, which caused it to break. The consumer believed the leaf spring should have been included in the check, when the frame was replaced. The consumer also discovered the left rear leaf spring needed to be replaced, as well.
The truck has a severe pull to the right while driving.this occurs because an incorrect tire size was installed on the truck at the factory. Consumer has gone through arbitration, in which the manufacture is blaming on to the dealership and not correcting the problem .*la
Driving at highway speed, the spare tire/wheel assembly (mounted beneath the vehicle) fell without warning to the roadway below.the tire/wheel ended up in the middle of the driving lane, causing numerous vehicles following behind me to swerve to avoid it.i pulled over to confirm the wheel was from my vehicle, and this was verified.i then turned around to pick up the wheel and remove it from the highway.i found the bracket still in place in the center of the wheel, however it was severely corroded and had no structural strength left.there was no sign of the chain or cable that held the wheel and bracket to the underside of the truck.this vehicle had recently been to a toyota dealer earlier in the year for an inspection of the frame (corrosion recall), as well as for replacement of gas tank straps (which were replaced due to corrosion issues).it had been determined that no action was needed with regards to frame corrosion.the gas tank straps were replaced.there was no comment from the toyota dealer on any potential issues with the spare tire mounting system.
The contact owns a 2003 toyota tundra. While driving, the trailer hitch became detached. The contact coasted the vehicle to the side of the road and noticed that the hitch dropped low to the ground and was bent. The contact used the trailer jack to lift up the trailer and straighten the hitch to the receiver in order to drive home. The contact stated that the trailer hitch was bolted to the reinforcement bumper, which was corroded. The contact was concerned the passengers in the vehicle would not be protected in the event of a crash. The contact removed the trailer from his vehicle and placed it in the back of the vehicle. The vehicle was taken to new country toyota of saratoga springs (located at 3002 ny-50 building # 1, saratoga springs, ny 12866, (518) 584-7272) where it was determined that the reinforcement bumper was not included in nhtsa campaign number: 09v444000 (structure). The recall only included the frame and all the crossmembers; therefore, the dealer could not assist. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and provided case number: 1906120378. The approximate failure mileage was 114,000.
We sent our truck for the insurance (progressive insurance) company to the garage for an alignment and they told us the front/right side of the frame is broke. Making the truck unsafe to drive.
The frame is prematurely severely rotten and crumbling. This is a massive safety issue and needs to be brought to every tundra owners attention. I have had it sprayed, but was only done for the back crossmember by toyota. The other half is ready for a catastrophe in due time. There may be others in my situation and no way is a frame supposed to crumble without sitting in constant salt. Please, please, please help the other owners and make them aware if they haven't yet. The frame will buckle while driving and cause harm to others on the road. Mine has pieces as big as 12 by 8 come off. The toyota dealership i have went to told me to keep an eye on it since the recall has lapsed.
My truck's frame has large, major rust perforation holes all over the frame and will soon need replacement. I feel that this will soon be a safety factor, as the frame is the only part of the vehicle that holds the truck in one piece when driving down the road. I'm afraid my frame will not protect me in a collision and that my truck may snap in half during normal driving conditions. Toyota corporate had me immediately bring the vehicle in to my local dealer for a frame inspection and the rust perforation was noted and verified, but toyota corporate will not replace my frame because the areas specified in their current open recalls aren't as rusted as what would be normally deemed qualified for frame replacement. The condition of my frame is terrible and may be considered more dangerous soon, compared to what could happen to the frame concerns of the current recalls.
Steering column shift bracket broke in 3 places when trying to shift from park to drive, making shifting impossible. See pictures from 2 of 3 fracture locations, 3rd fracture is at an attachment screw (not shown). This is cause by an punderdesigned part made of inferior cast aluminum. There are thousands of reports of this problem on tundras and other toyota models with same defective bracket. This dangerous defect must be recalled and fixed by toyota with a redesigned part.
Takata recall, i was involved in a collision with my toyota tundra when a nissan altima failed to stop for a stop sign. At witch point my air bags did not go off. The truck is totaled and so was the nissan! i was driving east on quincy ave. And the nissan was driving south on b st. When she failed to stop at the stop sign.
I have read the recalls for toyota tundras 2003 models which doesn't reflect in my area where i reside, guam. Does these recalls also pertain to guam, since the island is surrounded by salt air and salt water? if it does, how do i go about in fixing or remeding the situation? thank you.
I took my truck into a local dealership for a recall on the frame it was rusted. They said it didn't need to be replaced. So they undercoated it and all the undercoat fell off. They didn't undercoat the whole thing and now it's rusting even more. Don't know what to do.
The entire frame is rusted - to my shock and i just failed inspection but the truck is gorgeous and runs great with all new tires. I'm currently low income and wonder how the frame recall was missed but the airbag was replaced. Please advise and thank you.
Extreme rust area all around rear differential, pitting in metal, and also the spare wheel tire extreme rust.
In november 2011, our 2003 toyota tundra was taken in to shepards toyota in rockland, me where they sprayed "corrosion treatment" onto the frame to try and address their defective frame issues on this product (this was done under warranty). This "corrosion treatment" product failed and flaked off within a year. When we took the truck back to shepards, we were told that toyota had changed to a different product, as they had found that the original "corrosion treatment" product they were using was failing. However, they would not re-do our truck, saying that they had met the "minimum federal requirements" by doing the treatment in 2011.we have recently been told by our mechanic that the frame will likely not pass inspection next year, due to the amount of rusting on the frame. We only have 100,670 miles on this truck, and had hoped to have a usable truck for many more miles to come.i contacted toyota several times over the past two weeks, trying to get them to help fix this issue. Toyota is telling us that because they did the "corrosion treatment" in 2011, that they "met the minimum federal requirements" to address this issue, are under no obligation to help us any further, and will not do so. If the treatment had worked, then i would have no argument. Their "fix" was not a fix - in fact, within a year, they had switched over to using a different product, as they'd discovered that this original product was failing. Think of all of us who were being responsible consumers and getting our trucks in early for treatment once word got out about the frame issues, and who were given the treatment that was doomed to fail. It is so not fair.our case number with them is [xxx].during the work day, i'm most easily reached by e-mail. I am not at the home phone until after 4pm most days. Sincerely,[xxx]information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).?
Vehicle was on recall for rusted frame, two different occasions, for 2000-2004 and 2007 models. We brought truck in, they said it wasnt bad enough for a new frame, and did the coating. We got home and saw that the coating didn't cover all it should have. We brought it back a second time. Apparently it wasn't done properly as a stabilizer bar is rusted clean through and is hanging on by a thread. We bought the truck used at a dealership. What recourse do we have? can we get them to replace the frame now? they had it in their hands twice and didn't coat it well enough to keep it safe. Now i need a new frame. Otherwise the truck is in great condition, and we maintain it and care for it properly.
The 2003 toyota tundra access cab truck is not compatible with the latch carseat system. The top hook on the truck is larger in size than the hooks on the carseats. It is impossible to install a carseat in either the right or left position in the rear seat of the tundra. I complained to toyota and the did redesign the 2004 tundra to be compatible but did not offer a solution for the problem with the 2003 tundra. My local toyota dealership made a modified tether for my child's carseat with a larger hook attached that would fit the tundra hook. Toyota as a manufacture did not provide a solution however.
Every time i go on a trip that requires the truck to be running for longer then 20 min or so it begins to make a really loud grinding clunking sound and you can feel it. It's seemingly coming from the back and is associated with the moving of the tires. My buddy thinks it is the transmission box and that it is stuck between four wheel drive and reg. It also won't go out of four lot and four hi when i want it to.
"takata recall"
The frame is rotting prematurely. There is multiple hole developing in a couple spots of the frame. Vehicle was at the garage for a brake job and while on the lift the mechanic noted the frame rot.
The frame by the driver side front wheel is almost broken in half...it has a 2 foot long section missing...other steering component affected stablizer bar almost rusted in half..bracket and bushing almost nonexistent...this is my daily driver for me,my wife and my 10 year old daughter...i fear for their safety should it completely let loose...i drive very slow...i am 59 years old...plz help me get a new framefrom toyota...thanx
Steering column shift bracket broke in 3 places when trying to shift from park to drive, making shifting impossible.see pictures from 2 of 3 fracture locations, 3rd fracture is at an attachment screw (not shown). This is cause by an underdesigned part made of inferior cast aluminum. There are thousands of reports of this problem on tundras and other toyota models with same defective bracket.this dangerous defect must be recalled and fixed by toyota with a redesigned part.
Rear differential rusted through and fluid leaked out.
Gas tank straps rusted so bad that gas tank fell down.
My 2003 tundra frame in 2009 was determined to be in ok condition ,that is a result of low miles , the frame is now 6 years old with visible rust as i mentioned to my falmouth toyota service center ,with that i got a rust preventative compound . This compound was to stop the rust , i wouldn't be doing this if that was the case , now january 2017 with just 98000 miles and cosmetically a clean truck with my expectations only 1/3 used , the next 200,000 miles i expected to put on this truckwill not happen as falmouth toyota shows me the frame work around the gas tank brackets is ready to fail along with other visible holes and cracks in other portions of the frame , why am i not protected ? it's a known failure and all fames should have been replaced not a selected few , please i want results . I was sold on toyota when they advertised a truck or car stopping on a bridge and photographed the odometer at 500,000 , my guess is that is a thing of the past as they made there billions of.
Takana recall // and toyota recall
Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).i had the frame inspection recall performed in 2012 and was told the frame is ok so they coated the frame with under coating. A few months later i was driving to work and hit a joint on the highway and ended up in the next lane. As i am in the business i put the vehicle in the air that evening and found the steering rack mount was detached from the frame due to rust. I then spoke to toyota customer service and explained the situation and i was told to bring the vehicle back in and they would look at it. I was told again the frame is ok.. I did explain to the dealer that i had to wld a steel plate to the frame so the vehicle would be safe to drive. They still said the frame is ok and they would re spray the frame as a gesture for the inconvenience. I have made numerous calls and emails to toyota since then because june of 2016 i found rust holes in the frame in 2 different spots.. There is a recall to replace the frame if there are perforations in the frame during the inspection. However i have been told several times they will not assist me any further on this situation.thank you [xxx][xxx] *dl
My 2003 toyota tundra reved up while i was coming to a stop sign and it hit the car in front of me that was stopped at the stop sign; what happened to me is very similar to the story that was written in the usa today on 3/10/04 about your investigation of a similar malfunction on camry, solara and lexus 300 models.
My 2003 toyotatundra was involved in a accident february of 2008 due to sudden acceleration in which my vehicle spin out of control and went over a concrete barrier, my vehicle sustained heavy rear end and side damage. The damage to my vehicle cost me $5,663.14, i have the accident report. How could i get toyota to reimburse for the cost of the damage. Please advised.
I was in motion and driving on a residential street, while operating vehicle atthe time of accident. After the collision, the airbag did not deploy. The takata airbag was replaced by the auto manufacturer (toyota dealership) prior to my above mentioned accident.the auto accident occurred for unknown reasons, possibly brake failure or unexpected acceleration of the carengine.
My wife was driving her 2003 toyota tundra on the h3 freeway, changing from the right lane to the left lane,when the car suddenly accelerated, crashed into the center concrete highway divider, and continued to crash into the divider until it stopped running.she stepped on the brake the whole time but the truck would not slow down or stop until the engine died.when our insurance company inspected the truck it found that the repeated impact into the concrete barrier had bent the frame of the truck and then declared the truck a total loss.after they inspected the truck our local toyota dealer said there was nothing wrong with the truck to cause it to suddenly speed up and go out of control.
The contact previously owned a 2003 toyota tundra. In 2006, while driving approximately 20 mph, he engaged the brake pedal tostop thevehicle and suddenly the vehicle accelerated. He crashed into the rear end of a vehicle. There were no injuries. A police report was filed. The body shop mechanic inspected the vehicle but found no mechanical problems that would have caused the acceleration. He traded the vehicle in immediately after the mechanic diagnosed the failure. The vehicle identification number was not available at the time of the complaint.the current and failure mileages were approximately 32,000.
Consumer applied the brakes and vehiclewould suddenly accelerated on its on.consumerplaced both feet on the brake pedal and vehicle would not stop.consumer was able to maintain control of thevehicle , and drove it to the dealer for inspection. However,mechanic could not duplicate the problem.
At least since 2003 toyota has had many of their vehicles with sticking accelerators.i have a 2003 toyota tundra that i have taken to auto dealer to have work done to resolve issue.they have also had trouble with their 4 wheel drive vehicles with their clunking universals on the second drive shaft.toyota fights off the consumer complaints repeatedly and will not admit to their many faults.
The overdrive indicator on the dash display at times will indicate that the od is off when it is in fact on and indicate it is on when in fact it is off.the engine must be shut off and restarted to correct the problem.this has happenedmany times since i bought the truck new.
The contact owns a 2003 toyota tundra. The contact was driving up an incline approximately 60 mph in rainy weather conditions. The vehicle accelerated uncontrollably offof the road, and rolled over two times. The passenger sustained minor injuries to the ankle. The vehicle was destroyed and was towed to a collision center. A police report was filed. The failure and current mileages were 119,000.updated 6/3/10 updated 06/25/10.
Dt: the contact states the engine surgedwhen pulling out from a stop position. As soon as iraccelerated itsurged forward. The acceleration was more than expected based on the pressure being applied to the gas pedal.the dealership serviced the vehicle five times, including lubricating the entire acceleration system, and could not diagnose or duplicate the problem.updated 1/4/2006 -
I bought a brand new 2003 toyota tundra and never had any problems with the vehicle until my first cross country retirement trip in september 2013.my planned trip was from tennessee to california.when i reached kingman, arizona (about 1200 miles into the trip), i was traveling uphill on interstate 40 when suddenly the truck accelerated itself to a high rpm and speed.i applied the brakes but they did not respond or slow the truck down.i tried to maintain steering control, but in a split-second, i was thrown off the highway and into the hillside, trees, and bushes.the truck completely rolled over, flipped uphill, and come to a stop facing traffic. The landed driver side down, and was completely totaled.the truck only had 79,000 miles on it.a month later i learned that there was a previous recall done for this type of problem, but did not include the 2003 model.i now wonder how many others were injured due to this problem.i took many pictures of the damages.
My wife was driving on the freeway in my truck which is a 2003 toyota tundra, on board as well were my two daughters 10years old and 6 moths old, when suddenly the truck did not responded to the accelerator pedal so the truck started to slowing down. As you can imagine my wife started to panic, as all these cars were honking at her, plus, it was very difficult for her to get off the freeway since she could not accelerate. Good think no accidents happened. But i don't think this is too safe.
Dt*: the contact stated the catalytic converter is spewing sulfur dioxide when the engine is running. The vehicle was taken to the dealership for inspection, but could not be repaired because the dealer does not have an updated converter. The dealer could only use the same type of catalytic converter which they determined would have the same problem.the window regulator was replaced.updated 02/07/06.
2003 toyota tundra extended cabi checked my front brake pads.when i replaced the tire, two lug bolts failed at 70ft/lbs of torque.the specifications are tighten to 80ft/lbs.when i purchased new bolts at a dealer, the parts counterman said he was selling a lot of these lately.
The contact owns a 2003 toyota tundra. While the vehicle was being repaired according to nhtsa campaign number: 09v444000 (structure), the technician discovered that there was corrosion on the rear cross member. The vehicle was repaired; however, the remedy failed to repair the failure. While driving at approximately 45 mph, the vehicle started to shake and the rear driver side tire detached. The manufacturer was notified of the failure. The failure mileage was unknown.
Two items here: first i went to change my tire with my spare and it was missing. The tire service company said the tire must have fallen off somewhere as the cable holding the spare tire was rusted off.2nd, i had my tundra put up on a lift to see what the banging sound was. One of the shock's connections was rusted off and just hanging.he also stated that the whole frame and crankcase on the rear drive area looked like "bark on a tree"and could be very dangerous to drive in this condition
After putting the vehicle in gear and starting the drive, a grinding/squealing sound started coming from the front driver's side wheel. This sound continued until the vehicle could be parked and taken to an auto repair shop to be looked at (parked within 1 mile of original starting point). The repair shop deemed the vehicle unsafe to drive due to a failed wheel bearing. The repair shop had a similar experience with a previously worked on toyota prerunner where the same incident occurred, but the driver continued to drive the vehicle. The truck was eventually towed back to the shop after the wheel became cocked at a 90 degree angle while the driver was on the road.
The wheels rusted inside all the wheel wells. Manufacturer/dealer had done nothing, stating that the problem was due to the severe winter and refused to fix under warranty.scc
Driving and made a left turn when the right front wheel went flying and the truck started swirving in circles. And caused a major damage in which the dealer doesnt want to respond.
2003 toyota tundra extended cabi checked my front brake pads.when i replaced the tire, two lug bolts failed at 70ft/lbs of torque.the specifications are tighten to 80ft/lbs.when i purchased new bolts at a dealer, the parts counterman said he was selling a lot of these lately.
Read more
