We found the following complaints for RAM 5500 (2011)
Read complaints for RAM 5500 (2011)
-control modules require updates (ecm and tcm) which you have to pay $120.00 for the updates. It may cause drivability issues.-intake tube clamps need replacing which you can't buy the clamp you have to purchase the intake hose for $379.92.
Contacted by chrysler on or about 12/1/2014, concerning recall, p65. This recall effects the diesel fuel heater assembly, which as notified by chrysler could cause a engine compartment fire.as of an inquiry on 2/18/2015, they still have no estimated time frame for making parts and repairs available.our first inquiry on 12-19-2014, yielded the same results.i contacted our local dodge dealer 2/18/2015, who stated "there are no parts available for the recall".
Check engine light went on.the truck is still under warranty so we took it in to go arapahoe dodge. They were unable to fix the problem.we are not sure if something is wrong w/ the engine because dodge can not get the check engine light to turn off.the warranty we currently possess is only applicable until we reach 100,000 miles.we think dodge should be able to fix the problem under the warranty.
The contact owned a 2011 dodge ram 5500. The contact stated that the vehicle caught on fire under the front of the vehicle near the engine compartment. The fire department was able to extinguish the fire. The vehicle was destroyed. It was unknown if a police and a fire report were filed. The vehicle was included in nhtsa campaign numbers: 14v635000 (engine and engine cooling, fuel system, diesel) and 13v527000 (steering); however, the recall notices were received after the vehicle was destroyed due to the failure. The manufacturer was notified of the failure. The failure mileage was not available.
The contact owned a 2011 dodge ram 5500. The contact stated that the vehicle caught on fire under the front of the vehicle near the engine compartment. The fire department was able to extinguish the fire. The vehicle was destroyed. It was unknown if a police and a fire report were filed. The vehicle was included in nhtsa campaign numbers: 14v635000 (engine and engine cooling, fuel system, diesel) and 13v527000 (steering); however, the recall notices were received after the vehicle was destroyed due to the failure. The manufacturer was notified of the failure. The failure mileage was not available.
-control modules require updates (ecm and tcm) which you have to pay $120.00 for the updates. It may cause drivability issues.-intake tube clamps need replacing which you can't buy the clamp you have to purchase the intake hose for $379.92.
Diesel exhaust fluid (def) system failure.engine light came on with warning to have serviced or vehicle would not start after xx miles.was def system, pipe, injector, and sensors.
The contact owns a 2011 dodge ram 5500. The contact received notification of nhtsa campaign numbers: 14v635000 (engine and engine cooling, fuel system, diesel) and 13v527000(steering); however, the parts needed to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Check engine light went on.the truck is still under warranty so we took it in to go arapahoe dodge. They were unable to fix the problem.we are not sure if something is wrong w/ the engine because dodge can not get the check engine light to turn off.the warranty we currently possess is only applicable until we reach 100,000 miles.we think dodge should be able to fix the problem under the warranty.
2011 dodge ram 5500.attorney representing consumer writes in regards to vehicle fire and diesel fuel heater electrical connector recall notice.
2011 dodge ram 5500.attorney representing consumer writes in regards to vehicle fire and diesel fuel heater electrical connector recall notice.
While driving, at random, a warning will display stating the following: "service def system. Engine will not start at 200 miles. See dealer" this has happened 10 or more times since we purchased the truck. We have the same problem with another 2011 dodge ram 5500 which we purchased with this one. When we bring it to the dealer, they cant give an exact reason why this keeps occurring. They once told me "its because the vehicle was going 65 mph on the high way while towing a vehicle." the check engine light has been on in this vehicle since the month we purchased it. The dealership has a hard time shutting it off & keeping it off. This system lock-down of our ram tow truck's is unpredictable, and a major problem for our business & needs to be properly addressed and fixed.
The metal stem that is connected to the plastic housing acts as a guide for the springing action of the sender. As the fuel pump heated up, indicated by the black area on the fuel sender, it heated the metal tube and burned a hole through the tank.this caused a leak in the fuel tank and a spill of fuel in excess of 25 gallons at a gas station.
The contact owns a 2011 dodge ram 5500. The contact received notification of nhtsa campaign numbers: 14v635000 (engine and engine cooling, fuel system, diesel) and 13v527000(steering); however, the parts needed to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Received safety recalls #p65/nhtsa 14v-635and #n63/nhtsa 13v-527chrysler states in their notice that the parts are not available but they would send a letter to the vehicle owner when they are.have contacted the dealer several times to check on the parts.as of this date nothing has been received from chrysler and the dealer hasn't an answer.this vehicle is a fire dept emergency response vehicle.would like an update from chrysler.the fire dept just received another safety recall on this vehicle#p27.
Contacted by chrysler on or about 12/1/2014, concerning recall, p65. This recall effects the diesel fuel heater assembly, which as notified by chrysler could cause a engine compartment fire.as of an inquiry on 2/18/2015, they still have no estimated time frame for making parts and repairs available.our first inquiry on 12-19-2014, yielded the same results.i contacted our local dodge dealer 2/18/2015, who stated "there are no parts available for the recall".
The contact owns a 2011 ram 5500. The contact received notification of nhtsa campaign number: 17v821000 (power train) months ago. The manufacturer had not supplied the part to the dealer. The dealer (jeff wyler eastgate auto mall, 513-752-3447) was called and could not determine when the parts would become available to schedule the recall repair. The manufacturer was contacted. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2011 dodge ram 5500. The contact received a recall notification for nhtsa campaign number: 13v527000 (steering); however, the parts were not available to repair the vehicle. The dealer was unable to provide an estimated date for when the parts would become available. The contact was informed that the parts were on back order. The manufacturer was notified. The contact had not experienced a failure.
Driver was traveling east on nicholson lane, slowed to make a left turn onto nebel st. At which time he was traveling 10 mph or less.the driver made the turn and lost steering on the 2011 dodge ram 5500 and went into the oncoming lane of traffic on nebel st. Striking 3 vehicles.the accident investigator determined the accident to be a mechanical failure.a chrysler representative said it was not.this is the second 2011 dodge ram 5500 that has had the same failure.both resulting in an accident.this accident involved other people and property.i have full documentation on the previous accident which happened in 2011 on a vehicle with vin: [xxx] which had approximately 65,000 miles at the time of the incident.i begged chrysler to look into the problem then, they denied any faulty parts and claimed the damage was a result of the accident.i have not touched the truck since the incident that occurred on 2/1/2013.please contact me so we can stop any further injury and or property damage. Thank you in advance for your time and attention to this matter.updated 3/28/13 information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).updated 05/09/2013
The contact owns a 2011 dodge ram 5500.while driving various speeds, the power steering malfunctioned and caused the steering wheel to become very difficult to maneuver.the vehicle was taken to the dealer, who stated that the steering box was defective and needed to be replaced.the vehicle was repaired, but the failure recurred.the manufacturer was not notified.the vehicle was not repaired a second time.the failure mileage was 60.
The contact owns a 2011 dodge ram 5500. The contact received notification of nhtsa campaign number: 13v527000 (steering) however, the part needed to repair the vehicle was unavailable. The dealer was unable to provide an expected date for the part to become available. The manufacturer was made aware of the problem. The contact had not experienced a failure.
Left side tie rod end broke off and fell to the ground.this occurred in our parking lot as the truck pulled in at the end of the day.thankfully it didn't happen while he was driving.this is a huge safety hazard!!!
Received safety recalls #p65/nhtsa 14v-635and #n63/nhtsa 13v-527chrysler states in their notice that the parts are not available but they would send a letter to the vehicle owner when they are.have contacted the dealer several times to check on the parts.as of this date nothing has been received from chrysler and the dealer hasn't an answer.this vehicle is a fire dept emergency response vehicle.would like an update from chrysler.the fire dept just received another safety recall on this vehicle#p27.
The contact owns a 2011 dodge ram 5500. The contact stated that while driving approximately 5 mph, there was a sudden loss of steering power without warning. The contact was a independent mechanic where he diagnosed that the left outer tie rod was corroded and caused the steering cylinder to bend. As a result, the left outer tie rod and the steering cylinder needed to be replaced. The manufacturer was notified of the failure and stated that the vehicle was not included in nhtsa campaign number: 10v657000 (steering). The vehicle was repaired. The approximate failure and current mileage was 47,621.
The contact owns a 2011 dodge ram 5500. The contact received notification of nhtsa campaign numbers: 14v635000 (engine and engine cooling, fuel system, diesel) and 13v527000(steering); however, the parts needed to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2011 dodge ram 5500. The contact stated that the vehicle emitted an abnormal noise. After inspecting the vehicle, the contact discovered that the driver's side tie rod was fractured due to a sheered outer bolt joint. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure and current mileage was 16,908.
The contact owns a 2011 dodge ram 5500. The contact stated that while driving 5 mph, he heard a loud clunking sound. After inspecting the vehicle, the contact noticed that the tie rod had fractured. The contact mentioned that the vehicle was previously repaired under the manufacturer's recall for the tie rod. The vehicle was taken to an independent mechanic where it was confirmed that the tie rod had failed. The manufacturer was made aware of the failure and stated that they would review his case and contact him back at a later date. The vehicle was not repaired. The failure and current mileage was 46,000.
The contact owns a 2011 dodge ram 5500. The contact stated that while driving approximately 5 mph, there was a loud clunking sound from the driver's side of the vehicle. Upon inspection, it was found that the driver side tie rod end was fractured. The vehicle was towed to a dealer where it was diagnosed that the tie rod needed to be replaced. The contact mentioned that the vehicle was previously repaired under the manufacturer's recall for the tie rod. The manufacturer was made aware of the failure. The vehicle was repaired but the failure recurred. The approximate failure mileage was 20,000 and the current mileage was 22,775. Updated 9/10/13 the consumer stated the vehicle also had excessive front tire wear. New steering tires were installed 3 times in a span of 2 years. There were 23,00 miles on the vehicle. Updated 9/13/2013
Driver was traveling east on nicholson lane, slowed to make a left turn onto nebel st. At which time he was traveling 10 mph or less.the driver made the turn and lost steering on the 2011 dodge ram 5500 and went into the oncoming lane of traffic on nebel st. Striking 3 vehicles.the accident investigator determined the accident to be a mechanical failure.a chrysler representative said it was not.this is the second 2011 dodge ram 5500 that has had the same failure.both resulting in an accident.this accident involved other people and property.i have full documentation on the previous accident which happened in 2011 on a vehicle with vin: [xxx] which had approximately 65,000 miles at the time of the incident.i begged chrysler to look into the problem then, they denied any faulty parts and claimed the damage was a result of the accident.i have not touched the truck since the incident that occurred on 2/1/2013.please contact me so we can stop any further injury and or property damage. Thank you in advance for your time and attention to this matter.updated 3/28/13 information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).updated 05/09/2013
Received safety recalls #p65/nhtsa 14v-635and #n63/nhtsa 13v-527chrysler states in their notice that the parts are not available but they would send a letter to the vehicle owner when they are.have contacted the dealer several times to check on the parts.as of this date nothing has been received from chrysler and the dealer hasn't an answer.this vehicle is a fire dept emergency response vehicle.would like an update from chrysler.the fire dept just received another safety recall on this vehicle#p27.
This vehicle is on the buy back program.chryslers 3rd party took several months to file the paperwork with a preliminary offer of 35 thousand dollars on the buy back.at the time they guaranteed that price and that it could not be lowered.now they are coming back and offering 24k for the same vehicle and are refusing to speak to us under any circumstances unless we decline the offer or accept the offer. Fca and impartial services is refusing to re-purchase or repair our vehicle that is part of the 13v-527 campaign.we have been fighting with them non stop since october of 2015 and they are still refusing.this is the second time i have attempted to reach nhtsa and even you guys are refusing to assist.so we still have a broken truck in our driveway that fca will not fix!!!!!!!!..updated 01/20/16
While driving, at random, a warning will display stating the following: "service def system. Engine will not start at 200 miles. See dealer" this has happened 10 or more times since we purchased the truck. We have the same problem with another 2011 dodge ram 5500 which we purchased with this one. When we bring it to the dealer, they cant give an exact reason why this keeps occurring. They once told me "its because the vehicle was going 65 mph on the high way while towing a vehicle." the check engine light has been on in this vehicle since the month we purchased it. The dealership has a hard time shutting it off & keeping it off. This system lock-down of our ram tow truck's is unpredictable, and a major problem for our business & needs to be properly addressed and fixed.
The windshield washer fluid reservoir tank is cracked and will not hold fluid. Driving into the sun the windshield needed clearing and no fluid to clean it. Basically driving blind until out of the glare.
The contact owns a 2011 dodge ram 5500. The contact stated that while driving approximately 5 mph, there was a loud clunking sound from the driver's side of the vehicle. Upon inspection, it was found that the driver side tie rod end was fractured. The vehicle was towed to a dealer where it was diagnosed that the tie rod needed to be replaced. The contact mentioned that the vehicle was previously repaired under the manufacturer's recall for the tie rod. The manufacturer was made aware of the failure. The vehicle was repaired but the failure recurred. The approximate failure mileage was 20,000 and the current mileage was 22,775. Updated 9/10/13 the consumer stated the vehicle also had excessive front tire wear. New steering tires were installed 3 times in a span of 2 years. There were 23,00 miles on the vehicle. Updated 9/13/2013
Read more
