We found the following complaints for POLARIS SPORTSMAN 1000XP (2015)
Read complaints for POLARIS SPORTSMAN 1000XP (2015)
The electrical system shorts out when the vehicle gets wet and it drains the battery.water gets into the drive belt when the vehicle gets wet and the belt slips.
Atv polaris sportsman 1000 xp 2015 almost new, 120 miles on it. Exhaust heat melted the transmission speed sensor harness, fender and other smaller plastic parts.flexible heat shields were not enough and distroyed as well.vehicle got on fire (melted plasitc ignited), i turned the fire with hands (tks god i had gloves).dealer want to replace parts only, no changes at all. Have been waiting 9 weeks for the parts to arrive, no parts yet. I'm a mechanical engeneer and almost sure that will not solve the problem. Hope polairs finally listen and protect their cusotmers safety, before some one get hurt. As per forums, more than 50% of these atvs polaris sportsman 1000 xp 2015, have the same problem, melted plastic parts.
Exhaust becomes red hot only after a couple minutes of riding. The exhaust muffler is very close to the plastic fender and right rear tire. Because it gets so hot and sits so close to the rear tire i fear that there will be a fire. In fact, i have noticed leaves and grass catch fire from normal riding but they burned off without causing damage to the plastic. The plastic gets so hot it will soften and bend easily to the touch. The stick on heat shield under the fender gets so hot, it lost its stickyness and is now falling off. It also got so hot that the aluminum heat shield around the exhaust is coming apart at the factory crimp points.
After a 15 minute ride, the muffler was so hot it was glowing red. The heat put off by the muffler actually melted my rear body panel above the exhaust. The heat could have easily caused a fire had i parked the unit without first checking the exhaust, which i do after every ride after reading similar reports from other owners of the same vehicle.
Atv polaris sportsman 1000 xp 2015 almost new, 120 miles on it. Exhaust heat melted the transmission speed sensor harness, fender and other smaller plastic parts.flexible heat shields were not enough and distroyed as well.vehicle got on fire (melted plasitc ignited), i turned the fire with hands (tks god i had gloves).dealer want to replace parts only, no changes at all. Have been waiting 9 weeks for the parts to arrive, no parts yet. I'm a mechanical engeneer and almost sure that will not solve the problem. Hope polairs finally listen and protect their cusotmers safety, before some one get hurt. As per forums, more than 50% of these atvs polaris sportsman 1000 xp 2015, have the same problem, melted plastic parts.
The muffler in the exhaust system glows red as a charcoal briquet under all operational speeds. This produces very excessive heat and renders the plastic above the rear fender well untouchable. The usfs approved heat shield is very flimsy and at one point a twig got caught between the shield and the muffler and was burning. We just happened to have stopped on the trail and smelled the familiar campfire smell and pulled the twig away before it caught the dry leaves on fire. This is an offroad vehicle and i find it hard to believe that a company like polaris would manufacture an atv with this kind of issue. This is not an isolated incident or complaint as the online "polaris atv forums" website is covered up with threads about this issue. Thanks for your time and attention to this matter.
The exhaust muffler gets so hot it glows orange and you can smell melting plastic. I stopped riding this machine due to it being a major fire hazard.
The poor design of the exhaust system routes the header past plastic and your ankle area.my exhaust has, several times,heated up to cherry red.the last time it caught on fire and melted the plastic and burned my boot (my bodily damage to persons).polaris refuses to admit a problem.the heat is so great when riding it is next to impossible to keep your foot in the wheel well on the foot rest making this machine a fire hazard in federal, state and local forests as well as a hazard to being burned or loosing your machine to fire.polaris is refusing to do anything about it.
Purchased this 2015 sportsman 1000 xp brand new in february.most of it's operation has been lower speeds at a local atv park.this past weekend, i had a chance to use it on trails in a national forest in northern wisconsin.i noticed that operation above 25-30 mph resulted in red hot metal on the exhaust system.according to a website forum (polarisatvforums.com), and it's users there, this is not an isolated incedent.however, due to the extreme heat generated by this exhaust system, it appears one of the fasteners has failed on the exhaust system.when this happened, the atv got somewhat louder (not too noticeable when you're going 40 mph).i then noticed my right leg begin to feel very very warm (almost to the point of burning.looked down and saw the body plastics smoldering/smoking and a small amount of fire.stopped the vehicle and was able to put the fire out with a wet towel.had i continued driving (which would have been easy enough to do being that it wasn't significantly louder), i am fairly certain that the atv would have been engulfed in flames in no time.this is unacceptable on a vehicle with only 15 hours of use on it, and only 260 or so miles.it's basically brand new.will be taking it in for warranty repairs, but it appears i am not the only one with these issues.this seems like a very dangerous combination when you consider where these atv's operate most of the time (national forests, swamps, farmer fields etc)- places where there is much fuel to add to a fire.this could result in a forest fire etc., if not addressed soon.
When i ride this brand new sportsman xp 1000 the exhaust system gets glowing red hot, plastic fenders near the exhaust are untouchable, rear tire is extremely hot, and some grass that was thrown onto the exhaust caught fire.this is a two week old atv with 13 miles on it.i am not riding this machine hard.this occurred while driving the machine for about 10 minutes at a minimal rpm.polaris says this is normal break in occurrences.these machines will catch an owner's property on fire and/or hurt someone substantially if this problem is not resolved immediately.
When i ride this brand new sportsman xp 1000 the exhaust system gets glowing red hot, plastic fenders near the exhaust are untouchable, rear tire is extremely hot, and some grass that was thrown onto the exhaust caught fire.this is a two week old atv with 13 miles on it.i am not riding this machine hard.this occurred while driving the machine for about 10 minutes at a minimal rpm.polaris says this is normal break in occurrences.these machines will catch an owner's property on fire and/or hurt someone substantially if this problem is not resolved immediately.
Muffler on this machine becomes red hot with normal use, at speeds of 15-25 mph plastic in area of muffler and heat shield becomes to hot to touch, in some cases melting plastic body parts.if this red hot muffler were to come in contact with brush there would be high probability of fire. Polaris does not seem interested in solving this issue.
The electrical system shorts out when the vehicle gets wet and it drains the battery.water gets into the drive belt when the vehicle gets wet and the belt slips.
Atv polaris sportsman 1000 xp 2015 almost new, 120 miles on it. Exhaust heat melted the transmission speed sensor harness, fender and other smaller plastic parts.flexible heat shields were not enough and distroyed as well.vehicle got on fire (melted plasitc ignited), i turned the fire with hands (tks god i had gloves).dealer want to replace parts only, no changes at all. Have been waiting 9 weeks for the parts to arrive, no parts yet. I'm a mechanical engeneer and almost sure that will not solve the problem. Hope polairs finally listen and protect their cusotmers safety, before some one get hurt. As per forums, more than 50% of these atvs polaris sportsman 1000 xp 2015, have the same problem, melted plastic parts.
Exhaust to heat
Exhaust pipes from motor to muffer cherry red and plastic melting hot to the touch if u ride it for more than ten mins on dirt road or in creeks.
The exhaust muffler gets so hot it glows orange and you can smell melting plastic. I stopped riding this machine due to it being a major fire hazard.
Exhaust becomes red hot only after a couple minutes of riding. The exhaust muffler is very close to the plastic fender and right rear tire. Because it gets so hot and sits so close to the rear tire i fear that there will be a fire. In fact, i have noticed leaves and grass catch fire from normal riding but they burned off without causing damage to the plastic. The plastic gets so hot it will soften and bend easily to the touch. The stick on heat shield under the fender gets so hot, it lost its stickyness and is now falling off. It also got so hot that the aluminum heat shield around the exhaust is coming apart at the factory crimp points.
Muffler on this machine becomes red hot with normal use, at speeds of 15-25 mph plastic in area of muffler and heat shield becomes to hot to touch, in some cases melting plastic body parts.if this red hot muffler were to come in contact with brush there would be high probability of fire. Polaris does not seem interested in solving this issue.
The muffler gets so hot it melts the plastic fender starts on fire
After a 15 minute ride, the muffler was so hot it was glowing red. The heat put off by the muffler actually melted my rear body panel above the exhaust. The heat could have easily caused a fire had i parked the unit without first checking the exhaust, which i do after every ride after reading similar reports from other owners of the same vehicle.
The muffler gets so hot it melts the plastic fender starts on fire
After riding on slower trails or fast speeds. It doesn't matter the muffler begins to glow orange. Causing rider discomfort and fire danger to both vehicle and a danger to are beloved national forest. I have taken back to dealer and got the improved exhaust springs and donut installed. Also had new exhaust systeminstalled under warranty . It also was supposed to be improved. However same issue still remains.
Exhaust running so hot plastic fenders melted. Concerned about fire. Just riding slowly on an off-road trail . Dealer replaced under warranty and the melted again within 20 miles of next ride.
Read more
