We found the following complaints for FORD F-350 (2002)
Read complaints for FORD F-350 (2002)
While traveling 55 mph and pulling a trailer, truck was involved in an accident with the right front absorbing most of the impact due to a vehicle running stop sign.dual air bags did not deploy.owner could only exit out of rear doors due to both front doors being jammed.please describe details. There was 1 injury
While driving at 50 mph on the highway driver lost control of the vehicle, causing vehicle to crash into a guardrail head on. Upon impact,both frontal air bags did not deploy.
While coming to a stopaccelerated to a high rate. Consumer managed to stop the vehicle.dealership was notified, but did not resolve the problem. Dealer installed a flight recorder which was borrowed from another vehicle.with the flight recorder installed, consumer didn't experience any incident for 4 weeks.the dealer then called the consumer stating that the flight recorder had to be returned, and consumer's vehicle again malfunctioned 3 times.*la
Consumer took vehicle to a dealership due to loss of power and unknown ticking noise from the engine.this had been a problem twice since the3,000 mile checkup. Dealership cleaned the engine, and returned the vehicle.dealership states noise was normal, and should not affect the engine's performance.took vehicle back to dealer, and was told that the engine blew out.another mechanic looked at the engine, and found the spark plugs were improperly installed.consumer was aware of other complaints on nhtsa's website.the conumer stated that the exhaust sounded like it had a leak.*tc
The vehicle is dependent upon a vehicle security module to open doors, show if doors are open or closed, automatically lock and unlock doors, turn on and off lights, etc. The unit installed in my vehicle has been replaced by another unit by ford. Ford has not recalled this device. Many owners have reported and have had to replace these devices because of the problems with locks not working (open and close), headlights not working or turning off while driving, false safety indications being displayed, etc. I am now experiencing this problem and have to replace this module to stop these same issues in my vehicle. It is a thermal problem and only occurs whenever the vehicle is warmed during the day in the heat. It begins to work properly after the air conditioner cools the cab down or at night when the temperatures are cooler. The original part # is 2c7t-15k602-aj, the replacement part # is 4c7z-15604-ac.every website blog that includes super duty trucks from 2002 have volumes of people with the same issue and ford replacing the vsm. The fact that the part number has changed to a new rev and a high volume of owners are experiencing the same issue is proof of a faulty part.
The digital compass and temperature display in the upper console breaks. I rely on the display to prevent from crashing on icy roads. I have looked and thousands of people have same issues, a wire coming loose.ford needs to recall this instead of charging up to 400.00 for the replacement part.it almost got me killed, im surprisedno one has been injured.
Headlights go off and on when i move the tilt steering wheel, when driving or sitting still
The contact owns a 2002 ford f-350. The contact stated the starter engaged without the key being inserted into the ignition. The vehicle started moving on its own and crashed into a boat that was attached to it and then crashed into a refrigerator. There were no injuries. The contact stated that the starter was still engaged and could smell it overheating. The manufacturer was notified. The approximate failure mileage was 124,000.
The contact owns a 2002 ford f-350. While driving approximately 50 mph, the engine stalled. The vehicle was able to be restarted, but the failure recurred multiple times. The vehicle was taken to the dealer and an independent mechanic. The technician stated that the camshaft sensor needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was notified of the failure. The vin was not available. The approximate failure mileage was 3,000.
On may 13, 2014, a recall letter was received from ford. Ref. No. 09s09-speed control deactivation fire.i called sonora ford to schedule an appointment to repair the risk.according to [xxx] in the service department parts were on back order.he took my contact information and advised he would contact me in about a week when parts arrived.after no returned call i contacted both sonora ford and ford motor company customer relations center at 1-866-436-7332 & 1-800-392-3673.they advised parts were still 7 to 10 days out. Ford refused to have the switch removed or the circuit disconnected to prevent a fire until parts arrived when asked. With a known fire risk i am concerned more could be done by ford to address this issue while parts are not available.information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
On my way to work the turn signals failed and hazzzard lights no break litesor turn singnals the fuse panel was smoking and coused a wreckat 60 miles per hour
I have a 2002 ford f-350.i have just had to replace my alternator for the second time.i called ford customer relations and they said there was nothing they would do to help with the costs at this time.it is a part that should last many years and for me to be on my third with a truck this new means to me that there is a problem.the dealer did tell me that they were replacing a lot of them.i have numerous problems with thistruck.i kept having high pressure oil line problems until the block cracked and they replaced the motor.*la
1.on march 24, 2005 i started my 2002 ford 350 truck and drove about 15' when all of a sudden the truck died. Upon trying to start it again several people came over to tell me flames were shooting down on the ground from the engine. I immediately got out of the vehicle and the flames had stopped shortly thereafter.2.i had just recently had my vehicle serviced on 2.21.05 knowing i was driving to texas i had them check everything as well as whatever mileage maintenance that was due. Mileage at service date was 51,304. Everything checked out fine.3.my truck is currently at the five star ford dealership in fort worth texas.they have not reported the cause of the fire or damage incurred to the truck as of yet. Upon reading all the ford fire reports i am disgusted at the denial from ford. This is an extreme problem and needs to be corrected before too many people lose their lives.
Consumer states:3 times now, the starter burned up while setting in the garage and the wiring burnt out in the starter.after consumer had driven the vehicle, when you come back out, you can smell burnt wiring.dealer can not pin point the problem. The starter is engaging when there are no keys in the ignition.
The contact owns a 2002 ford f-350. The contact stated the starter engaged without the key being inserted into the ignition. The vehicle started moving on its own and crashed into a boat that was attached to it and then crashed into a refrigerator. There were no injuries. The contact stated that the starter was still engaged and could smell it overheating. The manufacturer was notified. The approximate failure mileage was 124,000.
My husband was driving about 25 mph on his way to take the ford f350 which was purchased on 2-11-02 to the ford dealership to have it looked at because it wasn't running right.about 1.5 miles from home, flames shot out of the defroster vent inside of the vehicle, went over his head and then the smoke got really bad.he had enough time to open the door, keep one foot on the running board and one on the brake to try not to let the truck and trailer he was towing jackknife.the airbag the blew his hand off of the steering wheel and the truck burned.the truck was burning and smoking as he was trying to stop it.he couldn't see inside of the vehicle at all during this time.he was watching the line on the road so he knew where he was at.he was able to grab 3 things out of the bed of the truck and as a passerby called 911, they watched the entire truck burn.the front tires blew off and the rims melted to the ground.all that is left of the vehicle is metal and the rear tires and rear axle.we have pictures if you want to look at them.we lost everything inside of the vehicle.we've been told of 2 possible causes, but there isn't anything left to even try to help determine the cause.as stated earlier, this vehicle only had 1700 miles on it and it was only 11 days old.
The contact owns a 2002 ford f-350 xlt. The contact stated that while stopped, the passenger's side spark plug shot out of the engine without warning. The contact also mentioned that the engine made a loud banging noise as the failure occurred. The vehicle was taken to a dealer where the mechanic stated that the compression from the engine caused the spark plug to fail. The vehicle was not repaired. The manufacturer was notified. The failure mileage was 180,000.
The contact owns a 2002 ford f-350. The contact stated that while driving 70 mph, the vehicle stalled without warning. The vehicle was merged to the shoulder and towed to the dealer. The dealer inspected and replaced the cam shaft position sensor. The initial failure occurred in 2006 and would recur every two years,and every two years since then the vehicle would stall and the cam shaft position failure had to be replaced. The cam shaft position was replaced five timesbut the failure was a constant recurrence. The manufacturer was notified of the issue, who offered no assistance to the contact. The failure mileage was 49,000 and the current mileage was 140,000.
The contact owns a 2002 ford f-350. While driving approximately 50 mph, the engine stalled. The vehicle was able to be restarted, but the failure recurred multiple times. The vehicle was taken to the dealer and an independent mechanic. The technician stated that the camshaft sensor needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was notified of the failure. The vin was not available. The approximate failure mileage was 3,000.
Consumer took vehicle to a dealership due to loss of power and unknown ticking noise from the engine.this had been a problem twice since the3,000 mile checkup. Dealership cleaned the engine, and returned the vehicle.dealership states noise was normal, and should not affect the engine's performance.took vehicle back to dealer, and was told that the engine blew out.another mechanic looked at the engine, and found the spark plugs were improperly installed.consumer was aware of other complaints on nhtsa's website.the conumer stated that the exhaust sounded like it had a leak.*tc
While driving approximately 35 mph the water pump started to leak. This caused the serpentine belt to become wet and slipped off the pulleys which caused the vehicles brakes and power steering to fail. I questioned the service advisor at the ford dealer(henry day ford) in west valley utah and they advised they had not heard of the problem. To me this is a very important safety hazard for occupants and could be a liability for ford motor company.
My husband was driving his ford f350 truck down the road when he smelled smoke at first he wasn't sure where it was coming from then helooked down and saw fire coming out of the fire wall and up his leg, he immediately stopped the vehicle and got out. He could not extinguish it and the fire department was called to put it out. He had no warning and heard no noise just smelled the smoke.
Ltr fm andrij andreitchux(nj) owner of a ford f350 truck unable to connect with 33 foot rv trailer hook system causes truck to lock-up defect reply to the elizabeth, nj district ofc. The vehicle was involved in an accident in which the consumer sustained injuries. Consumer also experienced problems with stalling of engine, transmission, power steering, acceleration, and fuel system on vehicle.*la
No summary listed for above vehicle.
When the gas pedal was depressed all the way to the floor for full throttle the vehicle's engine dies. *nlm
Consumer was told that injectors were faulty and needed to be replaced. When replacing the dealer found keeper pin was missing.the service dealer replaced the missing one with a used one from another vehicle.the vehicle continue to smoke and the vehicle was taken back to the dealer.the dealer determined that the engine needed to be replaced.
Dt: the consumer statedthat2002 ford f350 stalledand accelerated when the brakes were on. The truck stalled intermittently.this happened a couple of times a week. Accelerationwas happening all the time when theconsumer wasat a stop light. This was happening for a year. The consumerhas not had the truck checked nor inspected in the year thathe was having these problems. Theconsumercontacted the dealerand the consumer said that he would take the truck sometime next week for checkup.theconsumerhas not contacted ford. The vehicle was stalling at low speeds 0-20 mph.
2002 ford 350 crew cab 4x4 - 52,000 miles- blown spark plug at 42,000 and now again at 52,000 miles.
Dt*:the contact stated while traveling 30 mph, a bang was heard from the engine.the vehicle was idling rough and pulled over.upon inspection, the contact found a spark plug on top of the engine.the dealership was alerted, but the contact is repairing the vehicle.
The vehicle stalled, which caused consumer to abruptly pull over.
While driving 70 mph, the vehicle stalled.the consumer was concerned that she will be rear ended if the problem continued. The cd would not eject due to error. *sc
The contact owns a 2002 ford f-350.the contact stated that the engine oil pan was leaking. The vehicle was towed to a private mechanic where it was diagnosed that the oil pan was rusted and needed to be replaced. The manufacturer was notified of the failure. The vehicle was repaired on three occasions but the failure recurred. The approximate failure and current mileage was 140,000. Updated 3/12/14
The contact owns a 2002 ford f-350. While parked, the contact detected that the engine oil pan was leaking. The contact planned to have vehicle repaired by an independent mechanic. The manufacturer was notified of the problem. The approximate failure mileage was 123,000.updated 03/06/12 the consumer stated the oil leaked occurred due to rust. Updated 03/07/12
Engine began failing at 1200 miles and has gotten progressively worse. When the engine fails all power options are lost as well and has caused several close calls. Failure occurs without warning placing my life in danger. The ford regional representative has refused to talk with me until they try to repair the truck again. I can't trust this truck and feel it should not be on the highway. The dealer has the truck for the third time and hope they will replace it rather than use me as their crash dummy.
Vehicle stalled when making a turn or while driving. Vehicle been to the dealer on two occasions, andproblem reoccurred.feel free to provide any further information.
Truck went beyond 2500 rpms and serpentine belt squirled, and then there was a loss of power. Consumeralmost had anh accident because ofloss of power.
I have a 2002 ford f 350 with v10 engine. The manifold bolts keep rusting off and breaking. I only have about 11,000 miles on the truck now. Ford fixed the bolts on the right side on may 8, 2007 as i had purchased the extended warranty. They should have fixed both sides at the same time as this is an obvious problem. The truck only had 8500 miles on it then. They actually brought a rep in from ford on may 2, 2007 to photograph my truck during the repair at whited truck center in bangor, maine. *dtnow the warranty has run out and i noticed the bolts on the left side of the engine are rusted off and completely gone. Obviously this is a big ongoing problem with the v10 engines as there are many complaints posted on the internet about it. This is a safety problem as there are exhaust fumes leaking into the vehicle from these failed bolts. The fumes fill the engine compartment and then are drawn into the vehicle buy the heating/air-conditioning system every time i slow down or get stuck in traffic. This is by no means a safe situation and there needs to be a recall to fix the problem for good. Ford is dodging the problem as the cost of the repair is prohibitive, but the cost of a life is much dearer. I have had to park the truck for months now as i cannot afford the fix or to die. Thirty six thousand dollar truck with 11000 miles on it sitting around like it is a piece of scrap metal.information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Catalytic converter caught on fire and burned the entire right side of the vehicle. *scc
The contact owns a 2002 ford f-350. The contact stated that while driving 35 mph, the spare tire detached from the vehicle. The vehicle was taken to the dealer who diagnosed that the winch assembly cable had fractured and as a result, would need replacing. The manufacturer was made aware of the failure who did not offer any assistance since the vehicle was not included in any recalls. The vehicle was repaired. The failure and current mileage was 148,000.updated 11/16/11*ljthe consumer stated the cable broke at the end where it connected to the device that supported the spare cable. Updated 12/16/11
While driving 70 mph, the vehicle stalled.the consumer was concerned that she will be rear ended if the problem continued. The cd would not eject due to error. *sc
On my way to work the turn signals failed and hazzzard lights no break litesor turn singnals the fuse panel was smoking and coused a wreckat 60 miles per hour
Ltr fm andrij andreitchux(nj) owner of a ford f350 truck unable to connect with 33 foot rv trailer hook system causes truck to lock-up defect reply to the elizabeth, nj district ofc. The vehicle was involved in an accident in which the consumer sustained injuries. Consumer also experienced problems with stalling of engine, transmission, power steering, acceleration, and fuel system on vehicle.*la
The contact owns a 2002 ford f350. The contact stated that while driving approximately 65 mph, white smoke started to emit from the rear of the vehicle. After stopping to inspect the vehicle, the contact discovered fuel leaking from the engine area. The vehicle was towed to the dealer. The technician diagnosed that the fuel lines below the engine turbo had ruptured and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 175,000.
Purchased the 2002 f350 super duty dump truck new in 2003. It presently only has 20,200 miles on it. This past june the gas tank started leaking around the seam area. Thought that this was odd due to the low miles and soft usage the truck has had.has there been a recall on this truck for gas tank issues? if not, there should be.....as ita safety issue.
While drivingvehicle and with no warning the gas tank fell out of the vehicle. Dealer notified.
The vehicle is dependent upon a vehicle security module to open doors, show if doors are open or closed, automatically lock and unlock doors, turn on and off lights, etc. The unit installed in my vehicle has been replaced by another unit by ford. Ford has not recalled this device. Many owners have reported and have had to replace these devices because of the problems with locks not working (open and close), headlights not working or turning off while driving, false safety indications being displayed, etc. I am now experiencing this problem and have to replace this module to stop these same issues in my vehicle. It is a thermal problem and only occurs whenever the vehicle is warmed during the day in the heat. It begins to work properly after the air conditioner cools the cab down or at night when the temperatures are cooler. The original part # is 2c7t-15k602-aj, the replacement part # is 4c7z-15604-ac.every website blog that includes super duty trucks from 2002 have volumes of people with the same issue and ford replacing the vsm. The fact that the part number has changed to a new rev and a high volume of owners are experiencing the same issue is proof of a faulty part.
Consumer lost her husband after theparking brake system disengaged and ran over him on his 2002 ford f350.*njthe consumer was attempting to tow another vehicle. The consumer had planned to drive up a street ramp to the street. The consumer was unable to make the turn on the ramp with the other vehicle attached. In order to complete the tow, the consumer engaged the parking brake with his tow truck in neutral, engaged the power take off and lowered the vehicle being towed to the ground. A few seconds after the towed vehicle had been removed, the consumers vehicle began to roll.the consumer was found under his tow truck. The cause of death was declared as mechanical asphyxiation. Experts conducted extensive inspections and concluded the parking brake was defective. The lock pinion in the parking brake controller was capable of skipping out of place at its point of engagement with the lock sector stop, which created slack in the rear brake cables. The parking brake was missing several features would have prevented the consumers death, including a self adjusting drum in hat assembly, a more robust bump stop, more robust pinion teeth, a collar to secure the engagement of the pinion and the sector and an encapsulated take up spring.
Failure of the clutch master cylinder resulted in a stalled vehicle in the number 1 lane of i-80w out of sacramento, ca.very heavy labor day traffic prevented an accident. (stop and go traffic).as a result of the failure, the truck wouldn't shift into gear after the gear shift lever was placed in neutral.
The contact owns a 2002 ford f-350. While parked in the driveway, the vehicle rolled backwards approximately 300 feet and crashed into a fence. The contact stated that there was no warning indicator prior to the failure. The contact, an independent mechanic, inspected the vehicle and diagnosed that the bracket that secured the gear shift cable was loose which allowed the lever to go into different gears. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 160,000. The vin was unavailable.
Brake shift interlock, failed vehicle rolled without depressing brake petal.failure resulted in the death of ian joseph campbell4/14/04nothing has been done to correct problem.
Ltr fm andrij andreitchux(nj) owner of a ford f350 truck unable to connect with 33 foot rv trailer hook system causes truck to lock-up defect reply to the elizabeth, nj district ofc. The vehicle was involved in an accident in which the consumer sustained injuries. Consumer also experienced problems with stalling of engine, transmission, power steering, acceleration, and fuel system on vehicle.*la
The contact owns a 2002 ford f350.while driving at speeds greater than 40 mph, the vehicle's gear shifts into overdrive on its own.at speeds lower than 40 mph, it shifts violently into fifth gear.ford diagnosed the cause of failure as the torque converter and a solenoid.ford also stated that the vehicle is out of warranty, even though it has only 19,080 miles.this has been a persistent failure for more than two months.the purchase date was unknown.the current mileage is 19,080 and failure mileage was 18,000.
While driving 55 mph down a high way, the consumer heard a loud explosion,at first the consumer thought there was a tire blow out.when the vehicle was examined the consumer saw the axle had exploded and was on fire.there were no injuries in this incident.the manufacturer and the dealer are aware of the problem.
Dt*: the contact stated the rear left axle at the wheel joint collapsed while driving 25 mph.the vehicle was taken to the service dealer, who determined the bolt came loose inside the seal compartment.there were no warnings prior to the incident.the failure occurred under normal driving.updated 12/04/06.
When coming to a stop clutch will not disengage, and pedal stays on floor.
The consumer was pulling out of the driveway when he engaged the clutch, the clutch went to the floor, became stuck and continued to going forward.the consumer could not get the vehicle out of gear and applied the brakes as hard as possible.the consumer then got out of the vehicle and pulled the clutch with his hands and thought the problem was a fluke.the consumer continued down the highway shifting the gear with no problem until he had come to a stop, waiting on the light to change, and the clutch pedal went to the floor.this occurred when the vehicle was at an intersection. *mr *sc
The contact owns a 2002 ford f-350. The contact stated that the clutch pedal detached from the vehicle while driving 30 mph. The vehicle was safely driven home and parked. The vehicle was not taken to have the failure diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 270,000.
The contact owns a 2002 ford f-350. While parked, the contact engaged the front driver side seat belt. Once the vehicle was in motion the seat belt disengaged from the buckle. The failure recurred intermittently while traveling at different speeds. The vehicle was not taken to the dealer for diagnostic testing or repairs.the approximate failure mileage was 115,000.
The contact owns a 2002 ford f-350. While driving at 50 mph, the front driver and passenger side seat belts independently unlatched. The vehicle was taken to a dealer where it was diagnosed that the seat belts needed to be replaced. The vehicle was not repaired. The failure recurred on numerous occasions.the manufacturer was notified of the failure. The failure mileage was 70,000.
The contact owns a 2002 ford f-350. While driving various speed, the seat belt unlatched independently. The failure recurred numerous times. The vehicle was taken to the dealer where it was diagnosed that the seat belt needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 95,000. The vin was not provided.
Seat belts unbuckle by themselves. This has happens with the driver and passenger seat belts. Driver buckle failure is most frequent. One day it won't happen then the next day it will unbuckle 5 times in a short period of time. Afraid this will happen during an accident. The seatbelt buckle unbuckles stall speeds under any driving condition.
Seatbelt disconnects intermittently,button doesn't always fully pop back out when buckle is engaged
The contact owns a 2002 ford f-350. While driving approximately 20 mph, the contact depressed the brake pedal and the pedal erroneously traveled to the floorboard. The vehicle was taken to the dealer for diagnostic testing. The technician advised the contact that the brake lines were corroded and leaking brake fluid. The technician also advised that the brake lines would have to be replaced. The vehicle was repaired. The approximate failure mileage was 68,000.
While driving/braking low speeds, the consumer can hear/see the front passenger side brakes dragging/squeaking noise. The dealerships mechanic inform the consumer that the problem was pertaining to the brake caliper bolt failure , but did not resolve the problem. Please provide more information
Failure of the clutch master cylinder resulted in a stalled vehicle in the number 1 lane of i-80w out of sacramento, ca.very heavy labor day traffic prevented an accident. (stop and go traffic).as a result of the failure, the truck wouldn't shift into gear after the gear shift lever was placed in neutral.
Consumer indicated thatcruise controlshut off without warning when engaged. When this occurred there was a loss of power. Dealership indicated this was caused by a brake sensor failure.
While driving vehicle at any speed and apliying the brake vehiclewill pull to the right and the steering wheel will be hard to control. Dealear has inspected and could not duplicated or correct the problems. Please provide further information.ts
Repeated attempts to get this problem resolved have been ignored by ford motor. No safety defect listed.
At low speeds when applying brakes, steering wheel would lock up.dealer has inspected vehicle and changed rack and pinion. However,problem was not corrected.dealer put old parts back on vehicle.*yd
When vehicle is stopped and brakes are applied steering wheel does not move, cause unknown. Service manager stated that the hydraulic system for the brakes and steering are inter-related and the brake hydraulics apparenlty pre-empt the hydraulic pressure that would normally activate the brakes.
Consumer states the vehicle pulls to the right when the brakes are applied. The vehicle was involved in an accident one month prior to this problem. The dealer has replaced 3 times the calipers and pads and the problem repeats itself.please provide more information.mr
When applying the brakes the steering locked without warning. The dealer stated there wasno fix. A special service message was sent out which stated increased steering effort atlow speed or while stopped was a normal condition with hydroboost or vacuum operated brakes.
Steering wheel will not turn when brakes are applied. When brake pedal is released steering wheel can turn. Ford manufacturer was unaware.
While applying the brake the hydro boot doesn't work.causing problem in steering.when trying to back under the overhead camper it was hard to run into the jacks that hold up the camper. *nlm
Consumer states that steering wheel locks up if you slam on brakes or apply brakes farely hard.almost causing an accident.contacted dealer,they worked on it 3 times cannot fix problem.manufacturer know that problem assists.mr
It's difficult to turn steering wheel when applying brakes. Also, when vehicle is sitting still. Dealer cannot remedy the problem.
Hard steering with wineing noise. I was not able to steer the truck. Lucky for me i was going slow at the time. I traced the leaking fluid to a fitting on the power steering hose. Looks like a insulated steel pipe coming from the tubo rests on this steering hose. Constant rubbing and movement of this pipe causes damage to the hose fitting. Hose was repaired, however less than six months later it happend again same problem. I recognized the simptoms and was able to pull off the road safely. I do have the second hose and will keep if needed for inspection.
The contact owns a 2002 ford f-350. The contact stated that when driving at various speeds over road bumps, he would have to over steer in order to maintain the vehicle in one lane. The vehicle was taken to the dealer who replaced the gear box as a temporary remedy. The remedy failed to repair the problem. The manufacturer was made aware of the failure who did not offer any assistance. The vehicle was not repaired. The failure mileage was 175,000 and the current mileage was 187,000. Updated 8/23/12 the consumer stated in the attempt to repair the vehicle the following repairs were made: new ball joints, tie rod ends, 3 new gear boxes, 3 new steering pumps, new stabilizers, new u joints in the front axle, new steering column, and 3 alignments.updated 09/06/2012
When vehicle is stopped and brakes are applied steering wheel does not move, cause unknown. Service manager stated that the hydraulic system for the brakes and steering are inter-related and the brake hydraulics apparenlty pre-empt the hydraulic pressure that would normally activate the brakes.
At low speeds when applying brakes, steering wheel would lock up.dealer has inspected vehicle and changed rack and pinion. However,problem was not corrected.dealer put old parts back on vehicle.*yd
While driving steering column locked intermittently.
While the vehicle was parked, fluid was leaking from underneath.when the driver started up the vehicle a loud noise was heard coming from the steering wheel.the driver had the vehicle towed to the dealer for inspection.the mechanic informed the driver that the steering box needed replacement due to worn parts.the driver informed the mechanic this part has been replaced three times and the problem still exists.*la
While driving the vehicle at 55mph and applied the brake power steering will vibrate. Dealer has been notified an dealer was not willing to do anything... Ts
October 5, 2004 a fairfax county vehicle # 6382, 2002 ford f350 was involved in a vehicle accident that resulted in the possible injury of a pregnant female.the female driver stopped for a fast tran bus and the driver of the county vehicle attempted to stop and as he turned the steering wheel to the left the vehicle kept going straight and struck the car in front.the steering shaft broke and it was later confirmed that it was the steering shaft sector that broke.
While braking after driving 30 mph, vehicle lost power steering control. Consumer managed to regain control of vehicle, and pulled over to side of the road. Took vehicle to dealership where mechanic determined the cause of steering problem. *ph *nlm
When the brakes were applied the power steering failed.the dealer inspected the vehicle but could not duplicate or correct the problem.*nlm
Ltr fm andrij andreitchux(nj) owner of a ford f350 truck unable to connect with 33 foot rv trailer hook system causes truck to lock-up defect reply to the elizabeth, nj district ofc. The vehicle was involved in an accident in which the consumer sustained injuries. Consumer also experienced problems with stalling of engine, transmission, power steering, acceleration, and fuel system on vehicle.*la
While driving at any speed vehicleintermittently stalled in drive or in reverse.vehicle had been to the dealer eight times for this problem.each timedealer examines the vehicle, but the problem was not resolved. When vehicle stalled, this caused consumer to loose power steering and subsequently causing an accident to take place.consumer suffered sever pain in neck and back.expert's automotive report from nextech evaluated that vehicle has execessive effort required to turn steering wheel.condition occurs when the engine is at idle speed, with accessories operating and vehicle is in gear, forward or reverse.problem appeared to lessen when engine's rpm increased.also, the stalling of the vehicle was caused by a fault in the power steering system.*la
The spare tire carrier cable failed and dropped the spare on the ground which bounced and caught the rear bumper. No damage due to the slow speed i was traveling at the time, but this part has since been redesigned and should be recalled before someone gets hurt. New p/n is 6c3z-1a131-aa.
The paint on the hood began to slowly peel away an is now is very awful i was just told that ford recalled many on the bad paint i was never aware of that till last weeki was advised to write an find about this matter and that ford would stand behind that.
The contact owns a 2002 ford f-350. The contact stated that the frame of the vehicle was heavily corroded. Also, the fuel straps failed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000. Updated 04/05/17*lj
Vehicle wanders left and right with no handling control.vehicle constantly has to be counter steered just to keep straight. Vheicle was a dealerfour timesfor the problem.
Vehicle wonders from side to side constantly. Thd dealer has attempted to repair vehicle several times; however,problem still exists. Please provide additional information.
When the vehicle went down an incline, the front end vibrated. Which resulted in loss of control of the vehicle.
Within first 60 days after purchase, vehicle began to make thumping noise in floorboard after start of engine, after continued operation of vehicle out of necessity it began to have front end vibrations at 70 mph as well as a vibration during slow speed sharp turns. I am currently unable to take vehicle to be serviced due to lack of a second vehicle (see odi# 757078). Asked for assistance from dealership (jack roach ford houston tx) who contacted regional rep. Was told by dealership that the rep would not provide any assistance because i have a vehicle (odi# 757078) that is available to me. Problem is unresolved due to my requirement for transportation and ford motor company regional representative's vindicative efforts due to odi# 757078.
The contact owns a 2002 ford f350.while driving 60 mph, the contact lost control of the steering and the vehicle rolled over.the police inspected the vehicle and stated that there was a mechanical failure on the front suspension.the rollover crash destroyed the vehicle.the current and failure mileages were 10,000.
I noticed a slight rubbing sound coming from the front end of my f350 4x4 dually truck.i was pulling a 36 bumper pull camper at the time.the noise increased, and a squealing noise started.i pulled to the side of the road to prevent further damage.the drivers side front hub and fallen apart, and the wheel was about to come off the truck.the right side hub was worn out and could be moved two to three inches and required replacement.the truck has less than 55 thousand miles, and had only been serviced by a ford motor company dealer.the truck was towed and both front hubs were replaced.the truck had been taken to the dealership in february of 2003 and again in december 2004 with problems with the front end.the ford dealer said they could not find a problem.
My husband and i have 2 ford f350s that came with general tires of the 12 tires we have had 5 blow outs, the most recent was 4/23/2015 on i-80, in which my truck sustained over 2500.00 dollars in damage. Just wondering if we are lucky or if general tire company is just trying to kill people. The tires are 235x85x16 load range e and all had substantial tread when they blew. Thank you for looking into this.
A 6 inch split was noticed on both front tires and the steel belts were coming thourgh the tire. Original equipment, 2002 ford f350, tire size lt235/85r16 dot number unavailable.general dealer and manufacturer were notified. Consumer states that tires have severe spider web cracking.
Tire blew and came off the rim, totally separated. Dot 8xw81xl1402.for jpeg formated digital photos of tire email: [email protected].
The spare tire rack bolts snapped, causing the spare tire to fall in traffic while in vehicle was in motion.dealership was notified, but did not resolve the problem.
The spare tire carrier cable failed and dropped the spare on the ground which bounced and caught the rear bumper. No damage due to the slow speed i was traveling at the time, but this part has since been redesigned and should be recalled before someone gets hurt. New p/n is 6c3z-1a131-aa.
Consumer states that tires are losing tread. Dealer notified.
Ltr fm andrij andreitchux(nj) owner of a ford f350 truck unable to connect with 33 foot rv trailer hook system causes truck to lock-up defect reply to the elizabeth, nj district ofc. The vehicle was involved in an accident in which the consumer sustained injuries. Consumer also experienced problems with stalling of engine, transmission, power steering, acceleration, and fuel system on vehicle.*la
Wife parked the truck running at the top of a sloped driveway near our farm house, left the truck running and in park, got out to retrieve a forgotten item, walked downhill 75 ft., after a short timeturned to see the truck speed by backwards nearly hitting her.the truck rammed the carportcorner concrete support, jumped a two foot rock wall and came to rest against a three foot diameter birch tree.truckevaluated as total loss.a master mechanic brought to help get the truck started.damage only to rear but would not start. Battery plates had shorted due to the three severe jolts.the mechanic alsonoted the steering column bolts and screws seemed quite loose.the truck was started but moved to the body shop by a tow truck since the rear break line was severed.after totaling the vehicle the insurance company soldthe truck back to me for $5100.i got the truck repaired.today i took it to the ford dealer to check the steering column. The ford techniciannoted the severity of the loose steering column, replaced a couple bushings, tightened bolts and screws, and tested the vehicle. He specifically noted, in writing,the truck would not reliably stay in the selected gear.i paid ford $259 for the steering column work.the ford service manager told me when i scheduled the work that two other vehicles had just come in the same day with the same problem.this truck came out of park on its own and when rolling backwards barely missed my wife.she could have been easily killed.before this accident, it never occurred to me to take the truck into ford for a check of the steering column after 13 years but i should have been smarter.i bring this up to you for review because there could be lots more of these vehicles out there that could kill someone if they suddenly slip out of gear and roll.i have a copy of the ford service paperwork from today.
While coming to a stopaccelerated to a high rate. Consumer managed to stop the vehicle.dealership was notified, but did not resolve the problem. Dealer installed a flight recorder which was borrowed from another vehicle.with the flight recorder installed, consumer didn't experience any incident for 4 weeks.the dealer then called the consumer stating that the flight recorder had to be returned, and consumer's vehicle again malfunctioned 3 times.*la
On may 13, 2014, a recall letter was received from ford. Ref. No. 09s09-speed control deactivation fire.i called sonora ford to schedule an appointment to repair the risk.according to [xxx] in the service department parts were on back order.he took my contact information and advised he would contact me in about a week when parts arrived.after no returned call i contacted both sonora ford and ford motor company customer relations center at 1-866-436-7332 & 1-800-392-3673.they advised parts were still 7 to 10 days out. Ford refused to have the switch removed or the circuit disconnected to prevent a fire until parts arrived when asked. With a known fire risk i am concerned more could be done by ford to address this issue while parts are not available.information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Ltr fm andrij andreitchux(nj) owner of a ford f350 truck unable to connect with 33 foot rv trailer hook system causes truck to lock-up defect reply to the elizabeth, nj district ofc. The vehicle was involved in an accident in which the consumer sustained injuries. Consumer also experienced problems with stalling of engine, transmission, power steering, acceleration, and fuel system on vehicle.*la
On my way to work the turn signals failed and hazzzard lights no break litesor turn singnals the fuse panel was smoking and coused a wreckat 60 miles per hour
Dt: the consumer statedthat2002 ford f350 stalledand accelerated when the brakes were on. The truck stalled intermittently.this happened a couple of times a week. Accelerationwas happening all the time when theconsumer wasat a stop light. This was happening for a year. The consumerhas not had the truck checked nor inspected in the year thathe was having these problems. Theconsumercontacted the dealerand the consumer said that he would take the truck sometime next week for checkup.theconsumerhas not contacted ford. The vehicle was stalling at low speeds 0-20 mph.
Engine missfires and loses power at engine rpms of 1400-1600 light throttle.
Intermittently throttle would stick open.dealer has inspected vehicle several times, and could not duplicate or correct the problem. Feel free to provide any further information.
Consumer pressed down on the electrical button but window failed to roll up or down. It happened intermittently.driver's side window jammed and will not move.consumer took vehicle to the dealer for inspection.
This appears to be a problem with 2001 f350's as well.i talked with a few people that said "the passenger side mirror was there and then it wasn't."
Obvious design flaw with right side mirror, major blind spot. Almost in a major accident the first day i received the truck. *nlm**dimsii ivoq entry posted after 12-12-02 cut over to artemis*762450
During rainy weather traveling at 70 mph, the backwash from another vehicle covered consumers windshield.when attempting to activate the windshield wipers, it suddenly quit working causing zero visibility.dealer found a loose fuse.on another occasion, the windshield wiper failed again causing driver to hit the sidewalk.dealer daignosed the windshield wiper motor as faulty and replaced.
My husband and i have 2 ford f350s that came with general tires of the 12 tires we have had 5 blow outs, the most recent was 4/23/2015 on i-80, in which my truck sustained over 2500.00 dollars in damage. Just wondering if we are lucky or if general tire company is just trying to kill people. The tires are 235x85x16 load range e and all had substantial tread when they blew. Thank you for looking into this.
The spare tire carrier cable failed and dropped the spare on the ground which bounced and caught the rear bumper. No damage due to the slow speed i was traveling at the time, but this part has since been redesigned and should be recalled before someone gets hurt. New p/n is 6c3z-1a131-aa.
The contact owns a 2002 ford f-350 pickup truck. The contact stated that while driving 60 mph the vehicle started to shake violently. The contact mentioned that after maneuvering to the shoulder he noticed that six of the studs on the driver and the rear passenger side aluminum wheel snapped off causing the lug nuts to fall off. The vehicle was taken to an independent mechanic who replaced the studs and lug nuts. The manufacturer was made aware of the failure who did not offer any assistance since the vehicle was not included on any recalls. The failure mileage was 164,000 and the current mileage was 168,000.
The contact owns a 2002 ford f-350. The contact stated that the front passenger's side wheel spoke became fractured and caused the front passenger's side wheel to crack. The wheel was replaced with a spare tire by the contact. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate mileage was 137,000.
Read more
