We found the following complaints for FORD E150 (1989)
Read complaints for FORD E150 (1989)
Altenator heated up the wiring harness, resulting in a fire.
Altenateor harness plug connector suddenly short circuted, and caused vehicle to catchon fire. Dealer has not been contacted.
Ignition module has been giving us problems since purchased-1993- one time the module failed and another time it was replaced, still the problem persists.
Driving vehicle at speed 65mph, under the hood fire, smell of wiring burning, electrical short.
Began having serious problem with stalling approx. 2 mos ago , stalled while at highway speeds and while crossing intersections , endangering the safety of my family , which consists of myself ,my wife , and our four small children.this problem has occured 7 times. I have repaired it twice. Recently i took it to the local ford dealership. And at first they denied and problem and the recent recall in california. Ihave done a considerable amount of research regarding this problem including meeting with a regional ford district service manager. Please , pleasehelp me...
Ignition shorted out/failed. *dh
Ignition switch short due to looseness. *dh
Engine compartment fire, vehicle parked in driveway.tt
Fire started on drivers side near steering wheel and dashboard.nm
The air conditioning blower motor switch was melted i replaced it and it melted after 4000 miles. I went to a salvage yard and they were all melted in the hi position. When on hi the wiring get so hot you cannot hold the wires
Climate control fan switch melted/burned. *sd
While driving vehicle stalls and cuts off completly. Owner had to have vehicle towed to dealer.
Engine stalls.
Cracks developed on exhaust manifold gasket caused by overheating and poor design.tt
The muffler ruptured on top and toward thefuel line.
Manufacturer uses improper 'o' ring in air conditioner, causing air conditioner to leak. *dsh
Nhtsa campaign id# 91v146000 refers to a safety recall for a faulty dual fuel tank selector valve in ford econoline vans equipped with dual fuel tanks built between 1989 and 1991 and other similar models . I have contacted ford to investigate , but there are no records that confirm or disaffirm my vehicle's inclusion in this recall. Basically, i don't know if my van was affected by this recall and if any recall services were performed. I am experiencing a fault in the dual fuel tank system. It seems that the fuel selector valve will not switch to the main tank, and when filled, the main tank will flow past the filler cap and causes a fuel leakage, which can result in a fire when exposed to a source of ignition. I contacted a local ford dealer who advised me that no recall service can be performed to remedy this problem because my vin# does not register in the ford recall database. Again, ford cannot confirm or disaffirm any recall services performed on my vehicle. I am not the original owner of this vehicle so i do not have any service records prior to 2005. In an attempt to correct this concern, i have already replaced the secondary fuel pump, as advised by my local mechanic. I have also overhauled both fuel tanks to check for clogging, or any foreign materials, and i have replaced several seals and misc. Hardware in the fuel system. This concern has been a problem since i purchased the vehicle in 2005. I am only able to operate my vehicle on the auxillary (rear) fuel tank with a 13 gallon capacity. When the selector switch is on the front tank, the vehicle will eventually stall as if it is out of fuel. When the fuel selector switch is set to the rear tank, i am able to operate the vehicle normally with the exception of the limited range due to the small auxillary fuel tank.
Van died,towed to mechanics shop,was told switch valve between tanks was problem, looked on nhtsa website about recalls. Ford van 89 e-150 with duel gas tanks. Ford safety recall number is 91s39 went to ford web site,called them on phone, customer service and local dealership.both said there was no recall on my van.
The plastic fuel line melted off the fuel tank, causing fuel to leak out of the fuel tank.
Vehicle has auxiliary fuel tank.when first tank is filled with gas it causes spillage of second tank. Cause unknown.
When one fuel tank on a dual fuel tank assembly fills up it overflows,leaking gas.
Fuel is leaking from the gas tank of the vehicle.
He fuel tank selector valve malfunctioned causing fuel to spill. See recall mfg recall n0.91s39. Nhtsa 91v146.
The vehicle's dual gas tank is inoperative, causing front gas tank to overfill/spill when rear is switched.
The front brake still makes heat,the rear end axle was replaced .tt
Driving vehicle at speed 65mph, under the hood fire, smell of wiring burning, electrical short.
During a panic stop rear seat belts loosened, throwing child strapped in car seat on the floor.
The front brake still makes heat,the rear end axle was replaced .tt
Steering; the tie rod ball joint wears out.tt
Bumper assembly missing parts that are on assembly drawing, possible cause for the step bumper of the van to break away from the frame while towing.
Took all the grease fitting, resulting in constant alignment problem.tt
All four tires blistered between the treads.tt
Step bumper on the van broke away from the fram while towing a travel trailer, due to missing parts.
Read more
