We found the following complaints for CHEVROLET C3500 (1995)
Read complaints for CHEVROLET C3500 (1995)
Vehicle experienced electrical problems such as no start condition, headlights and tail lights failure etc, which may cause an accident.also, dealerreplaced fuel pump, ignition module and chips etc.dealer cannot determine the problem.please provide further information.
Fuel injection pump/computer/ air conditioning blower system failed. Also, poor engine performance and excessive oil consumption/transmission refuses to shift from first gear/alternator and both batteries failed.
Fuel injection pump/computer/ air conditioning blower system failed. Also, poor engine performance and excessive oil consumption/transmission refuses to shift from first gear/alternator and both batteries failed.
Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go.replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.
Vehicle experienced electrical problems such as no start condition, headlights and tail lights failure etc, which may cause an accident.also, dealerreplaced fuel pump, ignition module and chips etc.dealer cannot determine the problem.please provide further information.
Fuel injection pump/computer/ air conditioning blower system failed. Also, poor engine performance and excessive oil consumption/transmission refuses to shift from first gear/alternator and both batteries failed.
Vehicle experienced electrical problems such as no start condition, headlights and tail lights failure etc, which may cause an accident.also, dealerreplaced fuel pump, ignition module and chips etc.dealer cannot determine the problem.please provide further information.
The steering column tilt locked up,a week later the whole steering column locked up and released by itself; also, ignition key would not turn the switch.
Ignition switch failed causing engine to shut down.mjs
Ignition switch failed causing engine to shut down.mjs
Ignition switch failed causing engine to shut down.mjs
Brake light switch failed and wiring harness failed causing the cruise control and signal problems to the ecm. Mjs
Fuel injection pump/computer/ air conditioning blower system failed. Also, poor engine performance and excessive oil consumption/transmission refuses to shift from first gear/alternator and both batteries failed.
Engine head gasket failed while driving up hill with trailer.engine was replaced with no reason given for failure.less than 2000 miles later the fuel injection pump failed causing the truck to accelerate on its own uncontrollably.this is the second time in the history of this vehicle in which the truck has accelerated uncontrollably for fuel injection related reasons.another 170 miles later the fuel injection pump failed again and i was told it was replaced with a remanufactured pump which, in fact, did not come with the 12month/12,000 mile warranty i was told it came with 4 days earlier.gm customer service was contacted after the initial pump failure (4/30/00) seeking reimbursement.after four weeks(5/30/00) and several return calls to gm, i still have no answer on reimbursement for the original pump failure which cost me $1900.gm customer service agents have been very unhelpful and inconsistent in their reasons for failure to respond to my requests.i would like to have this reported to all consumer protection agencies possible which may help in my pursuit for reimbursement.thank you for the opportunity to complete this form.i can be reached at the office number given to answer any additional questions.thanks again!,john church.
While driving vehicle at varies speeds, the vehicle would stall/die out. Vehicle has a diesel engine. Had fuel injection pump replaced 4 times. Took to dealer & informed that until it dies out completely will not be able to do anything to vehicle.
Tech-cor, inc. Is a research subsidiary of the allstate non-life holding co. We receive and analyze inquiries from allstate insured customers. One, a mr. Henry alwardt, of key largo, fl, told of a defect in the fuel injector pump circuit of thegeneral motors 6.8l diesel engine, which was optional equipment on chev. & gmc trucks from 1995-2000. According to mr. Alwardt, the electronic control module for the fuel injector would fail without warniong, causing a loss of steering & brake control, which could contribute to an accident. He said that he has had 4 of these pumps and the electronic modules replaced on his 1995 chev. Truck , under warranty, since he bought it new in 1995. He further stated that as a result of personal contacts with other owners, that gm dealers have been inundated wit similar failures and subsequent warranty repairs. He is concerned about the potential risk of injury to drivers, passengers and occupants of other vehicles, if one of these vehicles experiences this problem, during operation. He is urging nhtsa to undertake efforts to get gm to fix this problem, once and for all and to alert insurers that their insureds, which own or drive these vehicles face increased risks of injury.
Both engine head gaskets cracked. As a result, water seeped into the engine which burned white smoke.the consumer was told that this was a common problem in 95 diesel 6.5 engines between 130k miles and 140k miles.(this was a metal problem) *sc
Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go.replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.
Engine fire.
A/c control selector switch failed.
Fuel injection pump/computer/ air conditioning blower system failed. Also, poor engine performance and excessive oil consumption/transmission refuses to shift from first gear/alternator and both batteries failed.
Brake light switch failed and wiring harness failed causing the cruise control and signal problems to the ecm. Mjs
Brake light switch failed and wiring harness failed causing the cruise control and signal problems to the ecm. Mjs
Brake switch light does not operate properly. Repairwork done at owner's expense, dealer could not remedyproblem. Provide further information.
Brake light switch failed and wiring harness failed causing the cruise control and signal problems to the ecm. Mjs
Head lamp switch failed.
I have a 1995 3500 dully 6.5 turbo, eng f, serial # [xxx]. I bought it 4 years ago 170,000 miles. This truck is used for towing and hauling heavy loads in my business.. One month after i bought it and after several stalls (creating some close calls) and hard starting and after several attempts at fixing stalling, starting problem ilearned of the pmd problem.i replacement and relocated pmd with stanadynepart # 34583, and relocated to firewall. After driving a few months started experiencing some hard starting and stalling again.this summer 2010 when temperatures reached the 90s it got really bad. Once dyeing on a right hand downhill curve that caused the truck to cross the center line forcing an on coming car to take evasive action to avoid a head on collision before i got it under control.i hope you never have to experience controlling a chevrolet 3500 dully without power going down a hill using extreme efforts to steer and stop. And i hope you never meet one in like condition heading in your direction. A very frightening experience.it stalled again on a curving uphill road with no shoulders with a trailer in tow, creating a hazard due to blind curves behind truck and having to let roll back down hill in order to get it off road and wait for it to cool down before it would restart.replaced pmd again, this time with new part stanadyne # 35976 and relocating to behind front bumper.now truck has started experiencing a hard start until cools down condition again.i am forced to continue using this truck against my better judgment because of economic conditions and my business. I have made my wife and other aware of this stalling, starting condition so that if i do have an accident they can have the proper investigation done.can you imagine how many of these heavy loaded trucks are still coming down the road toward your families?they are ticking bombs waiting to kill someoneinformation redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Vehicle experienced electrical problems such as no start condition, headlights and tail lights failure etc, which may cause an accident.also, dealerreplaced fuel pump, ignition module and chips etc.dealer cannot determine the problem.please provide further information.
Fuel pumps continuosly fail, causing vehicle to stall/loss of control.
While driving the vehicle shuts off.owner took vehicle to the dealer and had the fuel injection pump replaced.owner states that when going up a hill thevehicle backs up.owner will take vehicle to the dealershipfor repair.
Owner states that the fuel injection pump is faulty andmust be repaired constantly. He also notes that fuel injection pump can go without warning.
While driivng 70 mph, the fuel injection pump went out without warning. This pump has been replaced twice within a (2) year period. The pump needs to be replaced again. The truck has 33,500 miles at this time.
Engine head gasket failed while driving up hill with trailer.engine was replaced with no reason given for failure.less than 2000 miles later the fuel injection pump failed causing the truck to accelerate on its own uncontrollably.this is the second time in the history of this vehicle in which the truck has accelerated uncontrollably for fuel injection related reasons.another 170 miles later the fuel injection pump failed again and i was told it was replaced with a remanufactured pump which, in fact, did not come with the 12month/12,000 mile warranty i was told it came with 4 days earlier.gm customer service was contacted after the initial pump failure (4/30/00) seeking reimbursement.after four weeks(5/30/00) and several return calls to gm, i still have no answer on reimbursement for the original pump failure which cost me $1900.gm customer service agents have been very unhelpful and inconsistent in their reasons for failure to respond to my requests.i would like to have this reported to all consumer protection agencies possible which may help in my pursuit for reimbursement.thank you for the opportunity to complete this form.i can be reached at the office number given to answer any additional questions.thanks again!,john church.
While driving vehicle at varies speeds, the vehicle would stall/die out. Vehicle has a diesel engine. Had fuel injection pump replaced 4 times. Took to dealer & informed that until it dies out completely will not be able to do anything to vehicle.
Fuel injection pump/computer/ air conditioning blower system failed. Also, poor engine performance and excessive oil consumption/transmission refuses to shift from first gear/alternator and both batteries failed.
Fuel injection:the fuel injection pump known as injector pump constantly fails.has been in seven times for the same problem and was told that gm is having a problem with the pump.
The contact owns a 1995 chevrolet c3500.the contact stated that while driving approximately 70 mph, vehicle stalled without warning.the failure recurred multiple times and the vehicle was restarted.the vehicle was taken to the dealer where it was diagnosed that the injection pump needed to be replaced.the vehicle was repaired but the failure recurred.the manufacturer was notified of the failure.the approximate failure mileage was 30,000.the vin was unavailable.
While driving 60 mphfuel injector pump completely shut down, causing the fuel not to pump into the injectors.injector pump has been replaced eight times which has not corrected the problem.please give any further details.
Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go.replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.
Transmission problems, due to change of transmission from a 5-speed manual to automatic transmission, does not match up to computer unit.mjs
Transmission problems, due to change of transmission from a 5-speed manual to automatic transmission, does not match up to computer unit.mjs
While traveling noticed shifter would slip out of gear.cluch would also slip wiith noise. Had vehicle serviced.technician stated transmission needed to be replaced. Please provide further information.
Fuel injection pump/computer/ air conditioning blower system failed. Also, poor engine performance and excessive oil consumption/transmission refuses to shift from first gear/alternator and both batteries failed.
Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go.replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.
Transmission problems, due to change of transmission from a 5-speed manual to automatic transmission, does not match up to computer unit.mjs
Transmission can't be manually downshifted into low gear due to shift linkage being out of adjustment.
Rear axle seals are leaking causing the brake pads to saturate, resulting in brake failure.this problem has occured twice without warning, once while traveling and towing a travel trailer.*nlm
Clutch failed several times.
Clutch fluid overheated due to design flaw of the bell housing, general motors has replaced the bell housing with air holes to prevent overheating.
Clutch actuator failed.
Recall on seat belts.
Driver's seat bracket is broken.he was told that these seats break all the time.consumer stated it is the seat mounting bracket.
In dry weather when applying the brakes, theyfailed and pedal went to the floor,didn't come up,rearended car in front, no one was injured.
When driving at any speed and applying the brakes, the front brakes were working and the rear brakeswere not working. Replaced front brakes twice and had the rotors on the front replaced once, rear brakes adjusted on two occasions.*mjs
Vehicle's anti lock brakes lock up in wet conditions, causing vehicle to go sideways.
Brake switch light does not operate properly. Repairwork done at owner's expense, dealer could not remedyproblem. Provide further information.
Brakes failed.
When applying the abs brakes in normal conditions the abs system failed, causing extended stopping distance which nearly caused a collision.please give further details.
While driving at 65 mph brakes locked up, causingconsumer to lose control of vehicle. Consumer ran into a ditch andvehicle rolled over.dealer is aware of the problem.
When brakes are applied vehicle pulls to the left.
Front brakes locked up.
Brake calipers defective, causing pads to press against rotors.
Brake pads wore prematurely.
Brake rotor replaced.
Rear brakes adjusted.
Master cylinder replaced.
Brake master cylinder leaking.
Brake booster replaced.
Power steering pump failed.mjs
The steering column tilt locked up,a week later the whole steering column locked up and released by itself; also, ignition key would not turn the switch.
Power steering pump failed.mjs
Power steering pump failed.mjs
Power door lock actuator failed.mjs
Power door lock actuator failed.mjs
Power door lock actuator failed.mjs
Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go.replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.
Consumer purchased vehicle in february 95 used from cave city chevrolt buick&geo dealership.he noticed driver side door not aligned properly. Dealership (800-288-2438) took long bar to pry the door , resulting in the doorand the cab being slightly damaged.chevrolet manufacturer told consumer, to takevehicle to cambell chevrolet (502-781-7000). Cambell said that they did not want to get involved, and would not look at vehicle. Consumer's bbb case # is chv-974-6496. He was told he does not meet buy back standards. He also has a case with the state attorney general's office.
Left and right frame rails cracked at rear lower control arm mounting bracket.
Misalignment, causingvehicle to pull to right.
Front end shimmies when driver hits a bump.
Both upper control arms failed.mjs
Both upper control arms failed.mjs
Both upper control arms failed.mjs
Side wall failure resulting in blowout. (dot number: 8xor 65c 5tiresize: 235/85r16)
Tire tread came off and tire exploded whil i was coming from florida.tire maker in fayetteville said they were not interested in the tire because it was not part of the recall. I have proof that tire made prior to 1999, may have been defective.please contact me for more information.i still have the tire.( dot number: )
No summary( dot number: 2013ms tire size: lt225/75r/ )
Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go.replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.
Windshield wipers intermittently become inoperable in rainy weather conditions. Cause unknown.please give any further details.
Windshield wipers became inoperative, causing poor visibility. The vehicle was not included in the recall for windshield wiper,but is experiencing the same problem.
The windshield wiper motor malfunctioned,may cause visibility problem and could result in anaccident.there is a recall for chevrolet pickup, but not for c3500 which is having the same problem.please provide further information.
Wiper motor failed.
Windshield wiper motor and wipers failed during rain. Leave the switch on and hope they start working again. This truck not included in recall, but does the same thing as recalled trucks. Transmission refuses to shift from first to second gears. Stop truck, shut off engine, restart and proceed seems to work most of the time to get transmission working correctly. Sometimes must repeat several times. Cruise control failed. Both shifters replaced to fix this problem. Alternator replaced 3 times. Air conditioning pump replaced 3 times. This problem cannot be remedied because the clutch freezes up on each one shortly after installed. Harmonic balancer pulley was first to go.replaced it 1 time so far, vacuum pump blew a hole in side and replaced as well. Both doors had hinge pins replaced as both doors were hanging. Passenger door was the worst. Passenger door linkages replaced as well but failed within a few days after replacement. All problems started in fall of 2000.
Windshield wiper motor failed.yh
Windshield wipers become inoperable in rainy weather conditions due to problem with solder joints. Vehicle not included in recall number 98v1500001.
Read more
